HAYWARD HP50CL Swimming Pool Heat Pump Unit Instruction Manual
- September 20, 2024
- Hayward
Table of Contents
SWIMMING POOL HEAT PUMP UNIT
Installation & Instruction Manual
Model HP50CL
HP65CL
HP80CL
Swimming Pool Heat Pump Unit
There will be malfunction code showing on the controller screen when relative
malfunction occurs.
If there are more than one malfuctions occurs at the same time, you can check
the current error codes list by pressing “ ” or “ ” key.
You can refer to the malfunction table to find out the failure cause and
solution. For example:
ERROR CODE
The common failure cause and solution.
| Malfunction | Display | Cause | Solution |
|---|---|---|---|
| Water inlet temp. Sensor failure | P01 | The water inlet temp. Sensor is open or | |
| short circuit | Check or change the water inlet temp. Sensor | ||
| Water outlet temp. Sensor failure | P02 | The water outlet temp. sensor is open | |
| or short circuit | Check or change the water outlet temp. Sensor | ||
| Ambient temp. Sensor failure | PO4 | The ambient temp. sensor is open or short | |
| circuit | Check or change the ambient temp. Sensor | ||
| Pipe temp. Sensor failure | P05 | The pipe temp. sensor is open or short | |
| circuit | Check or change the pipe temp. Sensor | ||
| Evaporator temp.Sensor failure | P07 | The evaporator temp. Sensor is open or | |
| short circuit | Check or change the evaporator temp. Sensor | ||
| High pressure protect | E01 | The exhaust pressure is high , high pressure | |
| switch action | Check high pressure switch and cooling return circuit | ||
| Low pressure protect | E02 | The suction pressure is low, Low pressure switch | |
| action | Check low pressure switch and cooling return circuit | ||
| Flow switch failure | E03 | No water or litter water in water system | Check the |
flow volume ,water pump is failure or not
between water-inlet and outlet| E06| Temp. is too much different
Water flow volume not enough,
Water system pressure difference is small| the flow volume,water system is
jammed or not
Antifreezing under cooling mode| E07| Water flow volume not enough| Check the
flow volume,water system is jammed or not
The primary anti-freezing protection start.| E019| Ambient temperature is too
low|
The second anti-freezing protection start| E029| Ambient temperature is too
low|
Communication failure| E08| Communication failure between remote wire
controller and main board| Check the wire connection between remote wire
controller and main board
Exploded View(HP50CL)
(1) Complete machine structure explosion diagram
(2) Electrical control structure explosion diagram
Spare Parts List
| SN | HPX Code | Description | Specifications | Qty |
|---|---|---|---|---|
| 1 | HPX80900197 | Front frame | ABS | 1 |
| 2 | HPX72200268 | LED207 Wire controller | 82300029+82400226 | 1 |
| 3 | HPX20000-220188 | Plastic fan net | Ф507 ABS+30%GF | 1 |
| 4 | HPX3500-2701 | Fan blade | Ф440×152 AS+20%GF | 1 |
| 5 | HPX20000-330124 | Motor | YDK45-6(YY060-1206P01-004) UL | 1 |
| 6 | HPX32008-210069 | Before the fixed plate | Galvanized sheet | 1 |
| 7 | HPX32012-210737 | Support plate | Galvanized sheet | 1 |
| 8 | HPX32012-120165 | Finned heat exchanger | 746.5×284×600×Ф7×2 2.0 | 1 |
| 9 | HPX32012-210742 | Motor bracket | Galvanized sheet | 1 |
| 10 | HPX32012-220009 | Top | ABS | 1 |
| 11 | HPX80700707 | On the left side of the plate | Galvanized sheet | 1 |
| 12 | HPX80700713 | Partition | Galvanized sheet | 1 |
| 13 | HPX20000-110041 | Compressor | PA270X3CS-3MUU | 1 |
| 14 | HPX32012-210739 | Electrical box | Galvanized sheet | 1 |
| 15 | HPX32012-210740 | Cover plate | Galvanized sheet | 1 |
| 16 | HPX32012-210220 | Fire damper | Galvanized sheet | 1 |
| 17 | HPX32012-120036 | Titanium tube heat exchanger | Ф12.7×9m Ф160 | 1 |
| 18 | HPX80700706 | Right side of the plate | Galvanized sheet | 1 |
| 19 | HPX32009-220029 | Junction box body | ABS | 1 |
| 20 | HPX80700708 | Chassis | Galvanized sheet | 1 |
| 21 | HPX2002-1443 | Get straight through | Ф19-Ф12.9×1.0 T2M | 1 |
| 22 | HPX2001-1499 | Check valve | PKV-6X1 | 1 |
| 23 | HPX20000-140150 | Needle valve | 40mm 1/2″ | 2 |
| 24 | HPX2000-1460 | Tee | Ф6.5-2×Ф6.5(T)×0.75 T2M | 2 |
| 25 | HPX20000-140058 | Get straight through | Ф9.52-Ф3.×0.75 T2M | 1 |
| 26 | HPX20000-140067 | Double capillary joint | 2×Ф3.4-Ф9.52 | 1 |
| 27 | HPX2004-1444 | Filter | Ф9.7-Ф9.7（Ф28） T2Y2 | 2 |
| 28 | HPX2000-3603 | Pressure switch | 0.30MPa/0.15MPa ±0.05 NO | 1 |
| 29 | HPX2001-3605 | Pressure switch | 3.2MPa/4.4MPa ±0.15 NC | 1 |
| 30 | HPX20000-360059 | Pressure switch | 3.2MPa/4.0MPa ±0.15 NC | 1 |
| 31 | HPX2001-1418 | Four-way valve | SHF-7H-34U-P/C02C00S | 1 |
| 32 | HPX2000-3505 | Compressor capacitor | CBB65-50µF/450V P2 Blv | 1 |
| 33 | HPX95005-310145 | PC1001 | 20000-430001+35005-310145 | 1 |
| 34 | HPX20000-390231 | Five position connector | UTD-32/5P(L1、L2、PE、1、2) | 1 |
| 35 | HPX2000-3501 | Fan capacitor | CBB61-3µF/500V(450V)P2 | 1 |
| 36 | HPX2000-3909 | Two position connector | RS9211(450V~ 4mm²) | 1 |
| 37 | HPX20000-370006 | Power transformer | 41X26.5F+red(VH-3)、yellow(VH-2) | 1 |
| 38 | HPX20000-360103 | Single-phase ac contactor | HCC-2XU04AA415 | 1 |
Exploded View(HP65CL)
(3) Spare Parts List
| SN | HPX Code | Description | Specifications | Qty |
|---|---|---|---|---|
| 1 | HPX20000-110192 | Compressor | C-SBP105H16A | 1 |
| 2 | HPX20000-140153 | Needle valve | 90mm 1/2″ T0306-10 | 2 |
| 3 | HPX2004-1444 | Filter | Ф9.7-Ф4.2(Ф28) T2Y2 | 2 |
| 4 | HPX20000-360005 | Water Flow switch | PSL-1 3/4 | 1 |
| 5 | HPX2000-3603 | Pressure switch | 0.30MPa/0.15MPa ±0.05 | 1 |
| 6 | HPX20000-360059 | Pressure switch | 3.2MPa/4.0MPa ±0.15 | 1 |
| 7 | HPX2004-1437 | 4-way vlave | SHF-9H-35U-P/C03C01S | 1 |
| 8 | HPX80901028 | Front panel | ABS | 1 |
| 9 | HPX72200268 | LED207 Wire controller | 82300029+82400226 | 1 |
| 10 | HPX20000-220169 | Plastic fan net | Ф500 | 1 |
| 11 | HPX20000-270004 | Axial flow fan | Z500-145 | 1 |
| 12 | HPX20000-330143 | Axial flow fan | YDK90-6(YY070-1206P01-001) | 1 |
| 13 | HPX32009-210204 | Fan Motor bracket | Galvanized sheet | 1 |
| 14 | HPX80708920 | Back net | Galvanized sheet | 1 |
| 15 | HPX32009-210331 | Top cover | ABS | 1 |
| 16 | HPX32009-210220 | Middle partition | Galvanized sheet | 1 |
| 17 | HPX80711034 | Right panel | Galvanized sheet | 1 |
| 18 | HPX20000-220284 | The junction box body | ABS | 1 |
| 19 | HPX2000-3909 | 3-position terminal block | RS9211(450V~ 4mm2) | 1 |
| 20 | HPX20000-370006 | Transformer | 41X26.5F+(VH-3)ծ(VH-2) | 1 |
| 21 | HPX2000-3524 | Compressor capacitor | BB65A-98µF/300VAC | 1 |
| 22 | HPX95005-310145 | PC1001 Controller | 82300022+35005-310145 | 1 |
| 23 | HPX20000-360125 | Ac contactor | XTCG032C00AO | 1 |
| 24 | HPX2000-3509 | Fan capacitor | CBB61-5uF/500V(450V)P2 | 1 |
| 25 | HPX2000-3242 | Sensor | 150-502-98674(5K) 800mm | 1 |
| 26 | HPX2000-3223 | Sensor | 714×353×800×Ф7×2 2.0 | 1 |
| 27 | HPX32009-120025 | Titanium Tube Heat Exchanger | Ф12.7×12m Ф160 | 1 |
| 28 | HPX32009-120021 | Fin Heat Exchanger | 150-503-96115(50K) 600mm | 1 |
Exploded View(HP80CL)
Spare Parts List
| SN | HPX Code | Description | Specifications | Qty |
|---|---|---|---|---|
| 1 | HPX20000-110038 | Compressor | C-SBP120H16A | 1 |
| 2 | HPX20000-140153 | Needle valve | 90mm 1/2″ T0306-10 | 2 |
| 3 | HPX2004-1445 | Filter | Ф9.7-Ф4.2(Ф28) T2Y2 | 2 |
| 4 | HPX20000-360005 | Water Flow switch | PSL-1 3/4 | 1 |
| 5 | HPX2000-3603 | Pressure switch | 0.30MPa/0.15MPa ±0.05 | 1 |
| 6 | HPX20000-360059 | Pressure switch | 3.2MPa/4.0MPa ±0.15 | 1 |
| 7 | HPX2001-1491 | 4-way vlave | SHF-20A-46/V6-412080-1XX | 1 |
| 8 | HPX80901028 | Front panel | ABS | 1 |
| 9 | HPX72200268 | LED207 Wire controller | 82300029+82400226 | 1 |
| 10 | HPX20000-220169 | Plastic fan net | Ф500 | 1 |
| 11 | HPX20000-270004 | Axial flow fan | Z500-145 | 1 |
| 12 | HPX20000-330143 | Axial flow fan | YDK90-6(YY070-1206P01-001)UL | 1 |
| 13 | HPX32009-210204 | Fan Motor bracket | Galvanized sheet | 1 |
| 14 | HPX80708920 | Back net | Galvanized sheet | 1 |
| 15 | HPX32009-210331 | Top cover | ABS | 1 |
| 16 | HPX32009-210220 | Middle partition | Galvanized sheet | 1 |
| 17 | HPX80711034 | Right panel | Galvanized sheet | 1 |
| 18 | HPX20000-220284 | The junction box body | ABS | 1 |
| 19 | HPX2000-3909 | 3-position terminal block | UTD-63A/3P(L N PE) | 1 |
| 20 | HPX20000-370006 | Transformer | 41X26.5F+(VH-3)、(VH-2) | 1 |
| 21 | HPX2000-3524 | Compressor capacitor | BB65A-98µF/300VAC | 1 |
| 22 | HPX95005-310145 | PC1001 Controller | 82300022+35005-310145 | 1 |
| 23 | HPX20000-360125 | Ac contactor | XTCG032C00AO | 1 |
| 24 | HPX2000-3509 | Fan capacitor | CBB61-5uF/500V( 450V)P2 | 1 |
| 25 | HPX2000-3242 | Sensor | 150-502-98674(5K) 800mm | 1 |
| 26 | HPX2000-3223 | Sensor | 150-503-96115(50K) 600mm | 1 |
| 27 | HPX32010-120012 | Titanium Tube Heat Exchanger | Ф12.7×14m Ф160SSSS | 1 |
| 28 | HPX32009-120021 | Fin Heat Exchanger | 714×353×800×Ф7×2 2.0 | 1 |
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>