MINN KOTA MKR-23 ON-BOARD CHARGER POWER PORT 1865110 Installation Guide
- June 7, 2024
- MINN KOTA
Table of Contents
MKR-23
ON-BOARD CHARGER POWER PORT
1865110
Convenient adapter that allows quick thru-hull connections to an AC extension cord – with no cutting or splicing of wires required – using the AC plug from any Minn Kota charger. The splash-resistant cover and gasket prevent corrosion on the AC plug when not in use.
Item /
Assembly
| Part #| Description| Qty.
---|---|---|---
| | CARD-WARNING, POWER PORT| 1
| | FASTENER, WARNING CARD, PWR PORT| 1
2| | BASKET, POWER PORT, WHT INCLUDES 6| 1
4| | LUNE, POWER PORT, WHAT| 1
6| | MAIN-PLUG, POWER PORT, WHT INCLUDES 2| 1
8| | COVER-PLUG, POWER PORT, WHAT| 1
10| | SCREW, SS-POWER PORT| 2
12| | SCREW, PH-OVAL, SS| 3
| | INSERT, BRASS-POWER PORT| 2
Not shown on Parts Diagram.
This part is included in an assembly and cannot be ordered individually.
TOOLS AND RESOURCES REQUIRED
| • Drill | • 1/8” drill bit | • 1-7/8” hole saw |
|---|---|---|
| • Pen or similar marking tool | • 9/64” drill bit | • Screwdriver |
INSTALLATION
-
Select a location on the boat that is at least 21” away from all batteries and fuel fill lines.
NOTICE: Before drilling holes check for wires and supports on the area being drilled. -
Drill a 1/8” pilot hole in the center of the selected location.
-
Using the pilot hole, align a 1-7/8” hole saw to cut the mounting hole.
-
Place the AC Power Port in the 1-7/8” hole to mark and drill holes for the 3 mounting screws.
-
Put the AC cord through the 1-7/8” hole from the inside the boat and place the AC plug into the AC Power Port and tighten the 2 screws (Item #10).
-
Mount the AC Power Port in place with the 3 Stainless Screws (Items #12) provided. Your new AC Power Port is now ready for use.
WARNING
Avoid serious injury or death from fire, explosion, or electrical shock. This device must be connected to a Ground Fault Circuit Interrupt (GFCI) protected AC outlet. When using an extension cord, connect the AC charger before connecting to the GFCI protected AC outlet. Make connections in a secure manner that will avoid contact with the water. TAG ONLY TO BE REMOVED BY CONSUMER.
minnkotamotors.com
Part #2377125
Minn Kota Consumer & Technical Service Johnson Outdoors Marine Electronics,
Inc.
PO Box 8129, Mankato, MN 56001
121 Power Drive
Mankato, MN 56001, Phone 800-227-6433,
Fax 800-527-4464
©2021 Johnson Outdoors Marine Electronics, Inc.
All rights reserved.