beurer MG 180 Massage Gun Instruction Manual

: June 6, 2024
: Beurer

beurer MG 180 Massage Gun

SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE

If the instruction manual is damaged or if you no longer have the instruction manual in your possession, please contact customer service. See warranty for service contact.

Dear Valued Customer,
Thank you for choosing one of our products. Our name stands for high-quality, thoroughly tested products for application in the areas of heating, weight management, blood pressure, body temperature, pulse, gentle therapy, massage, and beauty.

Register your product today to receive further benefits:

added protection for your purchase
health and wellness tips
new product information
continual outstanding customer service and support.

Visit www.registerbeurer.com or contact customer service at 1-800-536-0366. Please read these instructions for use carefully and keep them for later use. Make them accessible to other users and observe the information they contain.

With kind regards, Your Beurer team

1. IMPORTANT SAFETY NOTES

Signs and symbols
Whenever used, the following signs identify safety and property damage messages and designate a level of hazard or seriousness.

READ THIS ENTIRE MANUAL, THE SAFETY SECTION AND ALL INSTRUCTIONS AND WARNINGS COMPLETELY AND CAREFULLY BEFORE USING THIS PRODUCT. FOLLOW ALL SAFETY INSTRUCTIONS AND WARNINGS TO AVOID HAZARDOUS SITUATIONS AND TO MAKE CORRECT USE OF THIS PRODUCT.

| This is the safety alert symbol. It alerts you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death.
---|---
| Indicates a potentially hazardous situation, which, if not avoided, could result in death or serious injury.
| Indicates a potentially hazardous situation, which, if not avoided, may result in minor/moderate injury.

NOTICE

WARNING:  To reduce the risk of fire, electric shock, or serious personal injury:

This device is intended solely for indoor domestic/private use; it is not intended for commercial use.
Children must not play with the device.
Keep packaging material away from children to avoid danger of suffocation.
Prevent unintentional starting. Ensure the switch is in the off-position before connecting to battery pack, picking up or carrying the appliance. Carrying the appliance with your finger on the switch or energizing appliance that have the switch on invites accidents.
Under no circumstances use the device for massaging the area around the heart.
Do not use massager on children, animals, or on persons suffering from a herniated disk or other spinal problems.
Never use the massager near the heart of a person with a pacemaker. Always consult a doctor before using the massager on other parts of the body of a person with a pacemaker.
Never use the massager on swollen, burned, inflamed, or damaged skin or body parts.
Do not use the massager on the head.
Do not use the massager on the spine.
Do not use the massager in the pubic area.
Do not use outdoors.
Do not operate where aerosol (spray) products are being used or where oxygen is being administered.
Do not use the massager in a car.
Do not use the device on cuts, capillaries, acne, couperose, herpes or other skin diseases.
Do not use massager while pregnant.
Do not use the massager on the face (eyes), on the larynx or on other particularly sensitive parts of the body.
Never use the massager while you are asleep.
Never use the massager after taking medication or consuming alcohol (reduced levels of awareness).
Keep out of reach of children.
Consult your doctor before using the massager if you suffer from
A serious illness or are recovering from an operation
Any of the following: Cold accompanied by a fever, varicose veins, thrombosis, phlebitis, jaundice, diabetes, nervous system diseases (e.g. sciatica) or acute inflammation.
The device is intended solely for the purpose described in these operating instructions. The manufacturer cannot be held liable for damage occurring as a result of inappropriate or careless use.
Do not use the device if you suffer from a medical abnormality or injury in the area to be massaged (e.g. slipped disc, open wounds).
Recharge only with the charger specified by the manufacturer. A charger that is suitable for one type of battery pack may create a risk of fire when used with another battery pack.
Only use the device with the supplied accessories.
Never use the device if you notice any damage to the massager or any massage heads.
Do not use during a thunderstorm.
In the event of a malfunction, shut the massager off immediately and disconnect it from the power supply. Never pull on the power cable or on the appliance in order to disconnect the plug from the electrical outlet. · Never hold or carry the device by the power cable.
Keep the cables away from hot surfaces.
Never use the device near petrol or other highly flammable substances. · Never open the device for any reason.
If the power cord of the device is damaged, it must be replaced by the manufacturer or an authorized customer service technician.
Have servicing performed by a qualified repair person using only identical replacement parts. This will ensure that the safety of the product is maintained.
Do not use a battery pack or appliance that is damaged or modified. Damaged or modified batteries may exhibit unpredictable behavior resulting in fire, explosion or risk of injury.
Do not modify or attempt to repair the appliance or the battery pack (as applicable) except as indicated in the instructions for use and care.
Make sure that the massage device, the plug and the cable do not come into contact with water or other fluids.
Do not place or store appliance where it can fall or be pulled into a tub or sink. Do not place in or drop into water or other liquid.
Do not operate massager with wet hands, in the bathtub or shower, or in or near a swimming pool or the like.
If the massager falls into water, do not try to retrieve it. Immediately disconnect the power cord from the electrical outlet.
Only operate the massage device for a maximum of 15 minutes continuously. After 15 minutes of operation, shut it off and let it cool for at least 15 minutes before resuming.
Never leave the device unsupervised, particularly if children are around. · Never operate the appliance with the air openings blocked. Keep the air openings free of lint, hair, and the like. Never operate on a soft surface such as a bed or couch where the air openings may be blocked.
Never use the device under covers, such as blankets or pillows.
Excessive heating can occur and cause fire or injury to persons.
Cleaning and user maintenance must not be performed by children unless supervised.
Do not disassemble, repair, and transform this product, or it might cause malfunction or electric shock.
Do not insert any objects into the opening in the device or into the moving parts. Ensure that the moving parts can move freely at all times.
Do not force or jam any part of your body, in particular your fingers, between the moving massage elements or their holder in the device.
When battery pack is not in use, keep it away from other metal objects, like paper clips, coins, keys, nails, screws or other small metal objects, that can make a connection from one terminal to another. Shorting the battery terminals together may cause burns or a fire.
Under abusive conditions, liquid may be ejected from the battery; avoid contact. If contact accidentally occurs, flush with water. If liquid contacts eyes, additionally seek medical help. Liquid ejected from the battery may cause irritation or burns.
Do not expose a battery pack or appliance to fire or excessive temperature. Exposure to fire or temperature above 130 °C may cause explosion. The temperature of 130 °C can be replaced by the temperature of 265 °F.
Follow all charging instructions and do not charge the battery pack or appliance outside of the temperature range specified in the instructions. Charging improperly or at temperatures outside of the specified range may damage the battery and increase the risk of fire.

CAUTION – To reduce the risk of personal injury or product/property damage:

Switch the device off and disconnect the power supply after every use and before cleaning.
Never operate this appliance if it has a damaged cord or plug, if it is not working properly, if it has been dropped or damaged, or dropped into water. Return the appliance to a service center for examination and repair.
Keep hair, jewelry, and loose clothing away from the massage head. · Avoid contact with sharp or pointed objects.
Make sure that the device is not too close to heat sources such as ovens, radiators, or direct sunlight.

SAVE THESE INSTRUCTIONS

Notes on electromagnetic compatibility

The device is suitable for use in all environments listed in these instructions for use, including domestic environments.
The use of the device may be limited in the presence of electromagnetic disturbances. This could result in issues such as error messages or the failure of the display/device.
Avoid using this device directly next to other devices or stacked on top of other devices, as this could lead to faulty operation. If, however, it is necessary to use the device in the manner stated, this device as well as the other devices must be monitored to ensure they are working properly.
The use of accessories other than those specified or provided by the manufacturer of this device can lead to an increase in electromagnetic emissions or a decrease in the device’s electromagnetic immunity; this can result in faulty operation.
Failure to comply with the above can impair the performance of the device.

Battery Handling Safety Precautions

Protect batteries from excessive heat.
Do not dispose of batteries in fire, batteries may explode or leak.
If a battery has leaked, put on protective gloves and clean the battery compartment with a dry cloth.
Keep batteries away from children and pets. Batteries may be harmful if swallowed. Should a child or pet swallow a battery, seek medical assistance immediately.
Do not disassemble, split or crush the batteries.
Only use chargers specified in the instructions for use.
Only charge the device using the supplied AC adapter.
In order to achieve as long a battery service life as possible, fully charge the battery at least 2 times a year.
Always switch the device off in advance of charging.
Batteries must be charged correctly prior to use. The instructions from the manufacturer and the specifications in these instructions for use regarding correct charging must be observed at all times.

Getting to Know your Instrument

Using this Massage Gun, you can provide yourself or others with a soothing, effective trigger point massage with no help required. Trigger point massages can relax the muscles or be stimulating and work effectively to relieve fatigued muscles. The Massage Gun provides a powerful, intensive massage for the thighs, calves, shoulders, arms and back region (excluding the spine).

Package Contents

Check that the exterior of the delivery cardboard packaging is intact and make sure that all components are present. Before use, ensure that the device and accessories show no visible damage and all packaging

1 x Massage Gun
6 x Massage Heads
1 x AC adapter
1 x Instruction manual

Parts and C ontrols

Massage Head (six heads included)
Power Button
LED Battery Level Indicator
1 red + 4 green LEDs = Battery state at 100%
1 red + 3 green LEDs = Battery state at 75%
1 red + 2 green LEDs = Battery state at 50%
1 red + 1 green LED = Battery state at 25%
1 red LED flashes = Low Battery
Power Switch
AC Adapter Jack
Handle
LED Display

| Ball Head For massaging large areas and large muscle groups
---|---
| Small Round head For massaging small areas of muscle and muscle groups
| Bullet Head For massaging deep muscle tissue and for targeted spot massages
| Fork Head For massaging deep muscle tissue in the lower back area (excluding the spine) and Achilles tendons
| Fork Head For massaging deep muscle tissue in the lower back area (excluding the spine) and Achilles tendons
| Fork Head For massaging deep muscle tissue in the lower back area (excluding the spine) and Achilles tendons

To Set Up

Before using the Massager for the first time, charge it first for a minimum of 3 ½ hours. To do so, proceed as follows:

Remove the Massager and all massage heads from the packaging.
Check the massager, power adapter, and massage heads for damage.
Ensure device is switched off and then attach the AC Adapter to the jack on the bottom of the handle. Plug the AC Adapter into a standard 110 VAC electrical outlet.
Route the power cord safely so that there is no risk of anyone tripping over it.
During charging, all five LEDs will flash from right to left. When fully charged, all LEDs will illuminate steadily in green. A full charge will last about three hours. Charge the Massage Gun again when one red LED flashes.

To Use

NOTE: This device has an auto shutoff feature, which will shut the massager off after 15 minutes of use. To reactivate, press and hold the Power Button for 2 seconds.

WARNING: After 15 minutes of operation, shut it off and let it cool for at least 15 minutes before resuming

Massage treatment should feel pleasant at all times. Some redness underneath the skin may occur, which is a normal effect. In rare instances, areas of redness may also occur on the skin. If you experience excessive skin irritation, stop using the Massage Gun and consult a doctor. Depending on how tense/ tight your muscles are, we recommend using the device for approx. 10-15 minutes on the area you wish to treat (legs, shoulders, arms and back).

Choosing a Massage Head

Refer to the “Parts and Controls” section to select an appropriate Massage Head. If a different Massage Head is already in place on the Massager, pull it straight out of the socket to remove. Press the selected Massage Head firmly onto the Massager until it clicks into place.

Slide the Power Switch on the bottom of the handle to the “ON” position.
Press and hold the Power Button for 2 seconds; the Battery Level Indicator will illuminate and the Massager will activate.
To change intensity levels, press the Power Button. If the Massager is on the highest setting, pressing the Power Button again will shut the Massager off. To shut the Massage Gun off at any time, press and hold the Power Button for about two seconds; the Battery Level Indicator and massage function will shut off.
After using the massager for a maximum of 15 minutes, slide the Power Switch on the bottom of the massager to the “OFF” position, unplug the AC Adapter from the electrical outlet, and let the massager cool.

CAUTION: The massage should be pleasant and relaxing at all times. Stop the massage or
change the position of the massage device if you find it is painful or unpleasant. NOTE: Do not use the massage device right before going to bed. The massage can have an invigorating effect and may cause difficulties in falling asleep.

Usage Examples

Legs
Shoulders, Arms, and Back
NOTE: Do not massage directly over bones.

Care, Maintenance and Disposal

Unplug massager and let cool. Wipe exterior with a soft, damp cloth.

WARNING

Disconnect the device from the electrical outlet before cleaning it.
Only clean the appliance in the manner specified. Liquids must never be allowed to enter the device or accessories.
Do not use the device until it is completely dry.
Do not clean the device in the dishwasher.
Do not use any abrasive cleaning products or hard brushes.

Storage: Keep the massage device in a cool and dry place out of the reach of children. When possible, store the device in its original packaging in a dry, climate-controlled environment out of direct sunlight.

Disposal

Observe the local regulations for material disposal. Dispose of the device in accordance with local regulations. If you have any questions, please contact the local authorities responsible for waste disposal.

Troubleshooting Guide

Problem	Solution
The Massager stops during use.	Make sure that you do not exert too much

pressure on the Massage Gun when using it. If you exert too much pressure, the device will stop briefly.

Technical Specifications

Type	MG 180
Art. No.	644.49
Power Supply Model No.: Input: Output:	**** MX24D1-2601000 100-240 V~, 50 –

60 Hz, 0.7 A 26.0 V __ 1.0 A, 26.0 W
Dimensions| 6.9 x 2.75 x 9.4 inches (17.5 x 7 x 24 cm)
Weight| 37.1 oz (1052 g)
Charging and Operating Range: Storage Range:| 39.2 °F – 104 °F (4 °C – 40 °C), 30 – 85% relative humidity 14 °F – 122 °F (-10 °C – 50 °C), 10 – 95% relative humidity
Battery: Capacity Nominal Voltage Type| **** 2500 mAh 22.2 V Lithium-ion

FCC Compliance Information

Massage Gun MG 180

Responsible Party U.S. Contact Information:
Beurer North America LP
1 Oakwood Boulevard, Suite 255
Hollywood, FL 33020, United States
1-800-536-0366, info@beurer.com

FCC Compliance Statement

This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. Changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment.
NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.

Warranty

Limited Lifetime Warranty For Original Purchaser

Your Beurer Massage Gun, model MG 180, is warranted to be free from defects in materials and workmanship for the life of the product under normal conditions of intended use and service. This warranty extends only to the original retail purchaser and does not extend to retailers or subsequent owners.

We will, at our option, repair or replace the Beurer Massage Gun, model MG 180, without additional charge, for any part or parts covered by these written warranties. No refunds will be given. Repair or replacement is our only responsibility and your only remedy under this written warranty. If replacement parts for defective materials are not available, Beurer reserves the right to make product substitutions in lieu of repair or replacement.

For warranty service contact our customer service department at 1-800-536-0366 or at info@beurer.com to provide a description of the problem. If the problem is deemed to be within the scope of the limited lifetime warranty, you will be asked to mail the product at your costs in its original package with proof of purchase, your name, address and phone number. If the problem is not deemed to be within the scope of the limited lifetime warranty, we will provide a quotation for repair respectively replacement and return shipping fee.

This warranty does not cover damage caused by misuse or abuse; accident; the attachment of unauthorized accessory; alteration to the product; improper installation; misapplication; lack of reasonable care with respect to the product; unauthorized repairs or modifications; improper use of electrical/power supply; old worn batteries; normal wear; loss of power; dropped product; malfunction or damage of an operating part as a result of failure to comply with instructions for use or to provide manufacturer’s recommended maintenance; transit damage; theft; neglect; vandalism; or environmental conditions; loss of use during the period the product is at a repair facility or otherwise awaiting parts or repair; or any other conditions whatsoever that are beyond the control of Beurer. This warranty is void if the product is ever used in a commercial or business environment. The maximum liability of Beurer under this warranty is limited to the purchase price actually paid by the customer for the product covered by the warranty, as confirmed by proof of purchase, regardless of the amount of any other direct or indirect damage suffered by the customer.

This warranty is effective only if the product is purchased and operated in the country in which the product is purchased. A product that requires modifications or adaptation to enable it to operate in any other country than the country for which it was designed, manufactured, approved and/or authorized, or repair of products damaged by these modifications is not covered under this warranty.

THE WARRANTY PROVIDED HEREIN SHALL BE THE SOLE AND EXCLUSIVE WARRANTY. ANY IMPLIED WARRANTIES, OBLIGATIONS, OR LIABILITES, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO THE DURATION OF THIS APPLICABLE WRITTEN WARRANTY. Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you.

IN NO EVENT SHALL BEURER BE LIABLE FOR ANY SPECIAL, INCIDENTAL, INDIRECT OR CONSEQUENTIAL DAMAGES FOR BREACH OF THIS OR ANY OTHER WARRANTY, EXPRESS, IMPLIED OR ANY OTHER THEORY OF LIABILITY, WHATSOEVER. Some states do not allow the exclusion or limitation of special, incidental, or consequential damages, so the above limitation may not apply to you.

Beurer does not authorize anyone, including, but not limited to, retailers, the subsequent consumer purchaser of the product from a retailer or remote purchaser, to obligate Beurer in any way beyond the terms set forth herein.

This warranty does not extend to the purchase of opened, used, repaired, repackaged and/or resealed products, including but not limited to sale of such products on Internet auction sites and/or products by surplus or bulk resellers. Any and all warranties or guarantees shall immediately cease and terminate in connection with any products or parts thereof which are repaired, replaced, altered, or modified, without the prior explicitly written consent of Beurer.

This warranty gives you specific legal rights, and you may also have other rights which may vary from state to state. For more information regarding our product line in the USA, please visit: www.beurer.com

Distributed by:
Beurer North America LP, 1 Oakwood Boulevard, Suite 255 Hollywood, FL 33020, USA, www.beurer.com

Questions or comments? Call our US-based customer service toll free at 1-800-536-0366. Made in China

Read User Manual Online (PDF format)

Read User Manual Online (PDF format) >>

Download This Manual (PDF format)

Download this manual >>