Ramvac 900246 Slug Buster Dental Vacuum Line Cleaner Instruction Manual
- June 6, 2024
- Ramvac
Table of Contents
Ramvac 900246 Slug Buster Dental Vacuum Line Cleaner
SLUGBUSTERTM DENTAL VACUUM LINE CLEANER
NOTE: SlugBuster is a non-foaming, non-chlorinated dental vacuum line
cleaner that is compatible with ALL dental vacuum systems and amalgam
separators (8 pH).
NOTICE: Ensure that vacuum system is turned OFF when indicated.
CLEAN VACUUM SYSTEM LINES
Daily
- Turn OFF vacuum system.
- Clean or replace solids separator screen in operatory.
- Turn vacuum system back ON.
- Rinse vacuum lines by drawing one quart of HOT water through each high-volume evacuation (HVE) line and a few ounces of HOT water through each saliva ejector (SE) line.
- Draw a few ounces of SlugBuster through each HVE line and a few ounces through each SE line (SlugBuster pre-mixed 1 ounce per 2 gallons of water).
During Surgery
Every few minutes, draw a few ounces of water through aspirator(s) used.
Following Surgery
Draw several ounces of SlugBuster through aspirator(s) used.
HELPFUL HINTS
- Prophy agents, pumice and fluoride gels tend to accumulate in vacuum lines.
- Flushing lines with ample quantities of HOT water is the most effective and economical way to assist in their removal.
- Increase quantity of SlugBuster used to remove heavy deposits from solid separators and hoses.
- Finish each operatory by opening and closing HVE several times to thoroughly clean risers to overhead lines.
- Rinsing and using vacuum line cleaners will not eliminate need to empty solids separators in the operatory.
- It is not necessary to rinse vacuum lines that have been inactive.
NOTICE: SlugBuster is available in powder and liquid forms, and can be ordered through any authorized Ramvac® dealer.
RAMVAC PART NO. CONTENTS
- 900143 Powder Starter Pack: Mixing jug, two 40-ounce containers of SlugBuster
- 900146 Powder Six Pack: Six 40-ounce containers of SlugBuster (makes 480 gallons of solution)
- 900241 Liquid Single Gallon: One gallon of SlugBuster concentrate and hand pump dispenser
- 900243 Liquid Starter Pack: Mixing jug, one gallon of SlugBuster concentrate and hand pump dispenser
- 900246 Liquid Four Pack: Four single gallons of SlugBuster concentrate and four hand pump dispensers
866-DTE-INFO dentalez.com September, 2021 © 2021 DENTALEZ, Inc. DENTALEZ is a registered trademark. SlugBuster is a trademark of DENTALEZ, Inc. Ramvac is a registered trademark of Ramvac Dental Products, Inc.