TOLL4EUROPE 20210610 Toll Box Europe User Guide

TOLL4EUROPE 20210610 Toll Box Europe

Technical Data OBU C3080

Ⓐ| Operation: -40°…+85 °C (with limited GSM functionality)

-30°…<+70 °C (full functionality) Storage: -40°…+85 °C

---|---
Ⓑ| 8….32 V DC
Ⓒ| Standby typical: ≤ 55 mA at 24 V DC Normal operation: 819 mA at 24 V DC Current consumption: ≤ 1 A
Ⓓ| GNSS/GPS receiver module with internal antenna
Ⓔ| GSM module with internal antenna
Ⓕ| Microwave DSRC EETS standard with internal antenna
Ⓖ| Lithium-Ion battery 3,6 V DC, 2100 mAh (satisfies UN transport test 38.3)
Ⓗ| IP54 acc. IEC 60529
Ⓘ| 260 g
Ⓙ| 145 x 93 x 36 mm
①| Display
②| Status indication
③| Four direction navigation button
④| Rear: battery compartment

Ⓐ–Ⓙ / ①–④ Please find detailed explanation on rear page.

Please check if the package content is complete and undamaged.

1. for cigarette lighter socket
2. for DIN standard socket

Usage with flexible power connection

Usage with permanent power connection

As soon as you start the vehicle, the OBU is switched on automati-cally.
For a permanent power connection please contact a qualified garage for installation.

Information for fixed installation by a professional workshop

Vehicle electrical system

1. Red: constant voltage (+)
2. Black: ignition
3. Brown: ground (-)

*Fuses (2A) not included

GREEN
EETS Service is activated for this toll domain. You can continue to drive.

YELLOW
EETS Service is either

not activated > not available or > not mandatory: check message on OBU. In case of obligation to pay toll, use tolling equipment of local toll provider.

RED

• Technical failure. OBU not ok.
  1. Stop driving and exit road.
  2. Check message on OBU display.
  3. Call your customer support.

• If no GPS for more than 30 minutes
  1. If you are e.g. in a garage, drive to a place with GPS reception.
  2. If the problem persists, call your customer support.

OBU parameter settings

Driver must entry correct values via OBU and control the setting on the OBU display

Toll Service| Trailer axles| Truck weight| Trailer weight| **OBU beep***
---|---|---|---|---
DE| x| x| |
BE/tunnels| | | |
AT| x| | | x
CH| x| | x|
BG/FR/HU/IT/(ES/PT)| x| | |

*Each successful transaction is reflected by one buzzer of the OBU when passing a toll station

Editable values

Notes on safety

• Usage in potential explosive atmosphere:
  According EU Directives 2014/53/EU, usage of OBU in potential explosive atmosphere in general is not permitted. For usage in potential explosive atmosphere please comply with procedure described in detailed instruction manual.

• Danger caused by (rechargeable) battery:
  Protect battery from mechanical strain (shock, drop, vibration) as well as tem-peratures >+85 °C! Fire hazard! For further safety precautions and directives please follow detailed instruction manual.

• Danger of obstructed line-of-sight:
  Allways mount the OBU in such a way that driver‘s field of vision is not impai-red! If in doubt, please contact Customer Service.

• Risk of accident:
  Handling of the OBU while driving is not permitted! The navigation button is locked to prevent any operation during vehicle movement.

• General instructions:
  Do not operate the OBU with pointed or sharp-edged objects.
  For cleaning use only a damp cloth, no solvents or abrasive cleaners. Replace damaged power supply cables immediately – danger of fire by short circuit!

• Hints for mounting:
  In the OBU fixing area the windscreen must be clean, dry and free from grease or oil. Mounting the holder to the windscreen has to be done at temperature above +20 °C. If necessary, please bring windscreen and holder to appropriate temperature. At temperature > +20 °C, the glue of the adhesive pads reaches its final strength 72h after application.

Instructions for installation and commissioning:
The Sitraffic Sensus Unit C3080 (OBU) is an easy-to-install, reusable device. Initial set-up is carried out automatically.
Further safety notes and a detailed instruction manual can be obtained at: www.toll4europe.eu
Custome r support:
If you have any queries about your OBU, please get in touch with your sales partner.

CE Marking and Declaration of Conformity

The OBU complies with the provisions of the following directives and regulations:

2014/53/EU

DIRECTIVE 2014/53/EU OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 16 April 2014 on the harmonisation of the laws of the Member States relating to the making available on the market of radio equipment and repealing Directive 1999/5/EC

2011/65/EC

DIRECTIVE 2011/65/EU OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 8 June 2011 on the restriction of the use of certain hazardous substances in electrical and electronic equipment

2009/750/EG  Annex III/2.1.2

COMMISSION DECISION of 6 October 2009 on the definition of the European Electronic Toll Service and its technical elements; Annex III/2.1.2

The Declaration of Conformity can be obtained from web page:
www.siemens.com/mobility-sensusunit-certificates Sitraffic Sensus Unit C3080
This product uses open source software.
Further information on this subject can be obtained from web page:
www.siemens.com/mobility-sensusunit-certificates License terms

Explanations

1. Front:

2. display,

3. status-indication,

4. four direction navigation button
   Rear:

5. battery compartment

Package content

⑤ box,
⑥ inlay,
⑦ quick start guide,
⑧ OBU C3080 with cable,
⑨ cleaning cloth,
⑩ holder with adhesive pads

Technical Data:

temperature, Ⓑ voltage, Ⓒ current consumption, Ⓓ internal GNSS, internal GSM, Ⓕ internal DSRC, Ⓖ battery, Ⓗ protection class, Ⓘ weight (without holder), Ⓙ dimensions (without holder)

Technical data made available by:

Siemens AG, RC-DE
Otto-Hahn-Ring 6
81739 Munich
Germany

www.toll4europe.eu

References

• Sensus On-Board Units | Yunex Traffic - A Siemens Business
• EETS Lkw-Mautbox | Toll4Europe

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>