CAMPLUX GG301S Table Top Gas Griddle Instruction Manual

TABLETOP GAS GRIDDLE
Instruction For Installation And Use

Model: GG301S & GG302S

FOR YOUR SAFETY

DANGER
If you smell gas:

• Turn off gas to the appliance.
• Put out any open fire.
• If smell continues, walk away from the appliance and call your gas dealer or firemen at once.
• Do not leave this appliance unattended.
• Don’t use this appliance within 25 ft of any flammable liquid.
• In the event of a fire, walk away from the appliance and call your firemen at once. Do not try to put out any oil or a grease fire with water.

Not following these instructions may cause fire or explosion which may cause property damage, personal injury, or death.

WARNING
Consumers must take responsibility to make sure the griddle is properly assembled, installed, and maintained. Not following the instructions could result in liver injury and/or property damage.

WARNING
Please read all necessary information for the proper assembly and safe use of the appliance before installing this appliance.
If you have any problems, please call us. Do not try to fix the problems yourself, or it will cause injury or property damage.
Installing this appliance must conform with state or other codes, or, in the absence of such codes, with either the National Fuel Gas Code, ANSI Z223.1 /NFPA 54.

WARNING
CALIFORNIA PROPOSITION 65 WARNING:
The State of California is aware of this product can cause cancer and birth defects or other reproductive hard. (California law requires this warning be given to customers in the State of California.)

**WARNING**

• Only 1 Pound of Propane Gas shall be used;
•  The cylinder used, if in excess of 2.2lb (1.00kg) propane capacity, must include a collar to protect the cylinder valve

DANGER

• Do not store a spare LP gas cylinder under or near this appliance.
• Never fill the cylinder beyond 80 percent full.
• If the instructions in(l) and (2) are not followed exactly, a fire causing death or serious injury may occur.

WARNING

• The cylinder supply system is arranged for vapor withdrawal.

WARNING

• This appliance is not intended to be installed in or on a boat to keep the fuel supply away from any heated surface.
• The appliance shall not be located or used under overhead unprotected combustible construction.
• This appliance must not be used on flammable items. such as a table covered with cloth or cotton.
• Never use it within a dangerous distance of flammable items.
• Never operate this appliance unattended.
• Never operate this appliance within 10 ft (3.0 m) of any structure, combustible material, or gas cylinder.
• Never operate this appliance within 27 ft (7.5m) of any flammable liquid.
• Heated liquids remain at scalding temperatures long after the cooking process.
• Never touch the cooking appliance until liquids have cooled to 115SF (45°C) or less.
• If a fire should occur, keep away from the appliance and immediately call your fire department. Do not attempt to extinguish oil or grease fire with water. Failure to follow these instructions should result in fire, explosion, or burn hazards which could cause property damage, personal injury, or death.

**WARNING**

• If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.
• If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with the risk of injury.

WARNING

• Turn controls and gas source or tank OFF when not in use.
• The cylinder shall be disconnected when the appliance is not in use.
• When not in use, the gas must be turned off and the cylinder shall be disconnected.

WARNING

• The manufacturer has made every effort to eliminate any sharp edges. However, you should handle all components with care to avoid accidental injury. The pressure regulator with the appliance must be used. Replacement pressure regulators shall be those specified by the appliance by Complex. An instruction to clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

WARNING

• Consumers are not allowed to disassemble the combustion system principally. If there is a problem, please refer to the manual or the repair method provided by the point of sale.
• If you do need to disassemble and check the system:firstly you need to remove the whole panel, then pull out the knob on the panel, then remove the screws that lock the switch valve on the panel, then you can check Nozzles switch valves, gas lines, pressure regulator valve and so on.
• However, we do not recommend you do it in case of dangers that would arise in the event of a leak.

DANGER

• Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING

• Be alert to the possibility at serious bodily injury if the instructions are not followed.
• Be sure ‘to read and carefully follow all of the messages.

CAUTION

• Indicates a potentially hazardous situation that, if not avoided, may result in minor or moderate injury.

Precautions

1. Don’t use the appliance indoors. It is only to be used outdoors.
2. Before using this appliance, please check the gas regulator in the gas tank. If there is any wear, tear, crack, cut, or intrusion. If you find any of these, replace the gas regulator before operation.
3. Under the condition of rain, snow, hail, sleet, or other forms of precipitation while cooking with oil or grease, it is necessary that you must cover the cooking vessel immediately and turn off the appliance burners and gas supply. Don’t try to move the appliance or cooking vessel.
4. Make sure the appliance must be on a level, stable non-combustible surface in an area clear of combustible material during cooking. An asphalt surface (blacktop) can not be accepted for this purpose.

WARNING

• This device is to be used outdoors only, and can not be used in a building, garage, or any other enclosed area.

• It is not acceptable to be used on or under any flats or condominium balcony or deck.

• Using alcohol, prescription or non-prescription drugs may damage the consumers’ ability to properly assemble or safely operate the griddle.

• Type BC or ABC fire extinguisher is necessary to be ready during cooking.

• When an oil or grease fire arises, don’t attempt to extinguish it with water. Must call the fire Department or use A Type BC or ABC fire extinguisher.

• The appliance operation must be watched. Don’t let children and pets near the appliance at all times.

• This appliance is not designed and used as a heater and is not suitable for frying turkeys.

• During and after use of the appliance, use insulated oven mitts or gloves for protection from hot surfaces or splatter from cooking liquids.

•  Never put an empty cooking vessel on the appliance while in operation. Be cautious when placing anything in the cooking vessel while in operation.
  Never move the appliance during use. Must make sure the cooking vessel cools to 115°F before moving or storing.

• Commercial purpose is not allowed to act on this griddle.

Installation Safety Precautions

• The installation of this appliance must conform with local codes, or in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1 or Propane Storage and Handling Code, B149.2.
• It is not acceptable to operate inside RVs or on boats.
• It is safely certified to be used in the countries of the United States and Canada. Never modify and use in any other countries. The modification will cause a safety hazard or damage.
• Replacing pressure regulators need to be those that are specified by the appliance manufacturer. After you have read and understand all safety information, warnings and precautions, you can proceed to the next page for assembly & installation instructions regarding your particular model.

What’s In the Box

|
GG301S & GG302S

Key| Description| Qty
1| 9/16″-18 UNF Gas Regulator| 1
2| Rubber Foot| 4
3| Body| 1
4| Grease Cup| 1
5| Griddle Plate| 1

**WARNING**
Never use this appliance under extended awnings as it may cause a fire or personal injury. Install it on the opposite side from the fuel distribution/dispensing system of the recreational vehicle.
Never let it be located or used under overhead unprotected combustible buildings or roofs.
If not in operation or when traveling, make sure all low-pressure propane gas system precautions are in place and all propane gas shut-off valves are shut off.

CAUTION
BEFORE STARTING THE INSTALLATION
MUST fit the recommended minimum clearances to combustible constructions:

WARNING

Don’t check leaks with an open fire. When not used, it is the correct way by opening the gas and apply soapy water to all joints to see if bubbles are formed.

Installation Guide for GG301S Gas Griddle

1. Remove the griddle body from the package.
2. Put the griddle upside down on a soft surface. Put the four rubber feet to the bottom of the griddle as shown below.
3. In order to be sure that the ignition can be efficient and stably. You need to check whether the igniter is above the burner and make sure that the distance between the igniter and the burner is within 3-7mm.
4. Insert the gas regulator and tank into the gas line of the griddle. Turn the collar of the gas regulator clockwise to secure it to the gas line.
5. Install the grease cup.
6. Place the griddle plate on the griddle body.

**WARNING**
Never check leaks with an open flame. Turn on the gas and apply soapy water to all joints to see if bubbles are formed.

Installation Guide for GG302S Griddle

1. Remove the griddle body from the package.
2. Put the griddle upside down on a soft surface. Put the four rubber feet to the bottom of the griddle as shown below.
3. In order to be sure that the ignition can be efficient and stably. You need to check whether the igniter is above the burner and make sure that the distance between the igniter and the burner is within 0.12-0.27 in.
4. Insert the gas regulator and tank into the gas line of the griddle. Turn the collar of the gas regulator clockwise to secure it to the gas line.
5. Install the grease cup.
6. Place the griddle plate on the griddle body.

Instruction of Operation

To light griddle
Must read all steps carefully

1. Push the control knob in and turn counter-clockwise to the “Light” position.
2. If fire does not appear in 5 seconds, shut the burner control off, wait for 5 minutes, and repeat the lighting procedure.

Use match for lighting

1. Don’t lean over the griddle while lighting. Ensure no gas leaks occur.
2. Control knob must be in the “OFF” position. Get the griddle top off.
3. Light a long match, then put the match on the right or left side of the burner.
4. Press the control knob in and turn counterclockwise to the “HIGH” position.
   Be sure the burner lights and keep it lit.

Check burner fire
Remove the griddle plate or the grease cup before lighting to visually check the fire. Light the burner and turn the knob from high to low you will see a smaller fire in the low position and bigger in the high position.
Check the fire before each use. If you only see the low flame, refer to Burner has a low flame regardless of knob position in the TROUBLESHOOTING GUIDE.

Model: GG301S

Model: GG302S

To turn off griddle
Turn the control knob to the “OFF” position.

Seasoning
Seasoning is baking oil into the metal to make a sticky-resistant surface and protect against oxidation.
There is a layer of soy oil on the appliance to protect against rust during transport. It can be cleaned off with warm soapy water when you begin your initial seasoning.

The choice of oil
The choice of some oils is important for seasoning.
Using Flaxseed oil for your initial seasoning as it creates a very durable bond. Any of the following oil can be used:

• Flax Seed Oil
• Extra Virgin Olive Oil
• Vegetable Oil
• Soy Oil

The purpose behind your initial seasoning is to create a bond with the griddle top by coating your griddle with oil and heat the oil above its smoke point to polymerize the oil. You will make a black, stick-resistant surface easy to clean.

Seasoning the griddle

1. Put a small amount of chosen oil to the surface of the griddle top and spread it around with a cloth or paper towel (use tongs or metal spatulas to hold the cloth or paper towel).
2. Make it medium-high heat.
3. It is good to heat the oil until it reaches its “smoke-point” and let it continue to discolor.
4. To make a good black surface, make sure to repeat steps 1 through 3 a few times after it cools down.

Proper installation of burner and switch valve’s nozzle:
The nozzle of the switch valve must be inside the bumper.

WARNING

The nozzle of the switch valve must be connected to the burner and must not be exposed to air.

Wrong installation:
The nozzle of the switch valve does not connect to the burner.

WARNING

WARNING: If “growing” bubbles appear, do not use or move the gas cylinder. Contact an gas supplier or your fire department!
If a leak is detected, close the pressure regulator lever (b) immediately and tighten the loose connection or replace the leaking part.
Repeat the leak test.
WARNING

DANGER: Never search for gas leaks using an open flame. Before checking for leaks, make sure that no sparks or open flames can form in the vicinity.Sparks or flames can cause an explosion which can lead to serious or even fatal injuries or material damage. If a leak is detected, close the pressure regulator lever (b) immediately and tighten the loose connection or replace the leaking part. Repeat the leak test.

The Storage of Griddle

DANGER
Never put the griddle in storage or travel mode at once after use when it is too hot to touch and make sure it cools down. Not following the direction could result in a fire resulting in property damage, personal injury, or death.

• For portable/tabletop griddles, disconnect from the recreational vehicles’ low-pressure LP gas supply system via quick-disconnect fitting (following applicable safety steps).
• Turn it off before storing the portable griddle indoors. Disconnect it from the low-pressure gas system, and the unit itself is at room temperature.

Clean the Burner

Follow these instructions to clean the burner.

1. Shut gas “OFF” at the control knob.
2. Ensure the entire griddle is cooled down.
3. Remove griddle plate from the assembly.
4. Use a wire brush to clean the entire outer surface of the burner to remove food residue and dirt.
5. Clean any blocked ports with a stiff wire such as an open paper clip.
6. Wear eye protection and use an air hose to force air into the burner tube and out the burner ports.
   Ensure each port to make sure air is flowing out each respective nozzle.

Safety of Food

The safety of food is a key part of enjoying outdoor cooking. For keeping food safe from harmful bacteria, read these four basic steps:

1. Clean: Use HOT SOAPY water to wash hands, utensils, and surfaces before and after contacting raw meat and poultry.
2. Separate: To avoid cross-contamination, separate raw meats and poultry from ready-to-eat foods. Use a clean platter and utensils when removing cooked foods.
3. Cook: Make sure meat and poultry are cooked thoroughly to kill bacteria. You can use a thermometer to test proper internal food temperatures.

Troubleshooting Guide

positioned as shown in “ignition electrodeposition”. Call customer service
Obstructions in the burner| Clean the burner by following steps outlined in “CLEAN THE BURNER”
Burner can’t be light with a match| No propane supply/empty supply| Have shut off valves checked fill propane supply
Defective regulator| Check regulator. Call customer service
Obstructions in the burner| Refer to “CLEANING THE BURNER” to clean the burner
Burner has small fire regardless of knob position| Low inlet gas supply pressure| Verify gas pressure on both the inlet side and outlet side of the appliance regulator. Call customer service
Low gas supply| Replenish propane supply
Defective control valve| Call customer service
Burner has a hissing or roaring noise| Obstructions in the burner| Refer to “cleaning the burner” to clean the burner
The burner could be damaged| Call customer service

Specification of the Griddle

Conforms to ANSI STD Z21.89-2017 Certified to CSA STD 1.18-2017 Outdoor Cooking Specialty Gas Appliance
This appliance is not intended for commercial use

Portable / Tabletop

Model| GG301S| GG302S
Burner Input Rate| 13000 BTU/h| 22000 BTU/h
Unit Size| 22.0″x18.8″x8.1″| 27.3″x18.8″x8.1″
Unit Weight| 21.4 LB| 27.6 LB

illustrations below show the Griddle Plate in the stored position.

https://camplux.com/

| 3330-A Marathon Ct Charleston, SC 29418
Visit Us: Camplux.com| 1(844) 538-7475

| support@camplux.com

---|---|---|---

References

• Camplux | Top-rated Tankless Water Heaters | Adventure Enhanced
• Camplux | Best Tankless Water Heaters | Camplux

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>