CAMPLUX JK-5330 Camping Stove Instruction Manual

CAMPLUX JK-5330 Camping Stove

Product Information

• Product Name: Camping Stove
• Model No.: JK-5330
• Item No.: BBQ-136M
• Manufacturer: Camplux
• Address: 3330-A Marathon Ct Charleston, SC 29418
• Website: www.camplux.com
• Contact: 1(844) 538-7475
• Email: support@camplux.com

Product Usage Instructions

1. Danger: Carbon Monoxide Hazard
   • Carbon monoxide produced by this appliance is odorless and can be fatal if used in an enclosed space such as a camper, tent, car, or home.
   • Never use this appliance in an enclosed space.
2. Danger: Fire or Explosion Hazard
   • If you smell gas
   • Do not attempt to light the appliance.
   • Ensure the appliance is in the off position.
   • Extinguish any nearby flames.
   • If equipped with a fuel cylinder, shut off the cylinder fuel supply valve. If equipped with a disposable fuel cylinder, disconnect the cylinder.
   • Leave the area immediately and allow gas to dissipate for 5 minutes.
   • If the gas smell has dissipated, follow the gas connection procedures.
   • If you smell gas again, repeat steps 1-6 and have the appliance serviced.
   • Failure to follow these instructions could result in fire or explosion, causing property damage, personal injury, or death.
3. Warning: Improper Installation or Usage
   • Improper installation, use, adjustment, alteration, service, or maintenance can cause injury or property damage.
   • Refer to the manual for assistance or consult a qualified installer, service agency, or gas supplier for additional information.
4. For Your Safety
   • Do not store or use gasoline or other flammable liquids in the vicinity of this or any other appliance.
5. Warning: Propane Gas Usage
   • Do not use the camping stove on/in apartment complex balconies or patios, recreational vehicles, campers, or boats.
   • Propane gas is extremely flammable. Follow these instructions
   • Do not store or use gasoline or other flammable liquids/aerosols near the appliance.
   • Attach or detach the propane cylinder outdoors away from flames, pilot lights, or other sources of ignition and only when the appliance is cool to touch.
   • Ensure the gas hose does not come into contact with hot surfaces. Inspect the hose for damage before each use.
   • Read and follow all warnings and instructions on or accompanying Propane/Butane gas.
   • Inspect the appliance, Propane/Butane cylinder, and connections for damage, dirt, or debris before attaching the Propane/Butane cylinder. Do not use if any of them are damaged or modified.
   • Follow the directions in the Gas Leak Testing section on page 4 of the manual. Never test for gas leaks with a lit match or open flame.
   • When transporting, not using, or storing the stove, always disconnect the Propane/Butane gas. The Propane/Butane cylinder should remain upright to prevent liquid Propane/Butane flare-up.
   • Do not connect to a remote gas supply such as natural gas or a refillable Propane/Butane cylinder.
   • In case of fire, turn off the gas at the burner control knobs and use a Type ‘BC’ fire extinguisher or other appropriate means to extinguish the flame.
   • Keep hands, face, and hair away from burners. Use long matches or a long-nosed lighter to light the stove.

DANGER
CARBON MONOXIDE HAZARO
This appliance can produce carbon monoxide which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a camper, tent , car or home.

DANGER
FIRE OR EXPLOSION HAZARD

If you smell gas

• Do not attempt to light appliance.
• Make sure appliance is in the off position.
• Extinguish any nearby flame(s).
• Shut off cylinder fuel supply valve if so equipped, or if equipped with a disposable fuel cylinder, disconnect cylinder.
• Leave the area immediately.
• Allow gas to dissipate 5 minutes.
• If gas smell has dissipated from the area, of the appliance, and fuel supply, follow gas connection procedures.
• If you smell gas again, follow steps 1-6 and have appliance serviced.

Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

WARNING
Improper installation, use, adjustment, alteration, service or maintenance can cause injury or property damage.
Refer to this manual. For assistance or additional information consult a qualified installer, service agency or gas supplier.

FOR YOUR SAFETY
Do not store or use gasoline or other liquids with flammable vapors in the vicinity of this or any other appliance.

WARNING

• DO NOT use on/in apartment complex balconies or patios, recreational vehicles, campers or boats.
• Propane gas is extremely flammable, follow these instructions
• DO NOT store or use gasoline or other liquids/aerosols with flammable vapors n the vicinity of this appliance.
• Always attach or detach propane cylinder outdoors away from flame, pilot lights or other sources of ignition and only when appliances is cool to touch.
• DO NOT allow the gas hose to come into contact with any hot surfaces. Inspect the hose for damage such as burns, chafing, and kinks before each use.
• Read and follow all warnings and instructions on or accompanying Propane/Butane gas.
• Always inspect appliance, Propane/Butane cylinder, and its connections for damage, dirt or debris before attaching Propane/Butane cylinder.
• DO NOT use if either has been damaged or modified.
• Follow directions in the “Gas Leak Testing”section on page 4 of this manual. Never test for gas leaks with a lit match or open flame. DO NOT operate the stove with a gas leak.
• When transporting, not using, or storing stove always disconnect Propane/Butane gas.
• Propane/Butane cylinder should remain upright to prevent liquid Propane/Butane flare-up.
• DO NOT connect to a remote gas supply such as natural gas or a refillable Propane/Butane cylinder.
• In case of fire, turn gas “OFF” at burner control knobs and use Type ‘BC’ fire extinguisher or other appropriate means to extinguish flame.
• Keep hands, face and hair away from burners. Use long matches or long-nosed lighter to light the burners, DO NOT wear loose clothing or allow long hair to hang freely while lighting or using stove.
• Always snap down legs to form a”V” with the stove base to prevent the stove from becoming unstable while in use. Use only on a flat surface.
• DO NOT move stove while in use. Avoid touching hot surfaces.
• Properly dispose of all packaging materials.
• Any modification of the appliance maybe dangerous.
• Use protective gloves when handing hot components.
• Gas parts are sealed by the manufactures and must not be altered by user. When changing the gas container, please keep away from any source of ignition.
• Keep the hose position so as to ensure that it is not subjected to twisting.
• It is vital to replace the hose if it is worn, or damaged.
• The maximum diameter for pot/pan that to be used on the burners is 8.7 in. (220 mm), the minimum is 3.9 in. (100 mm).
• The cylinder supply system must be arranged to provide for proper fuel withdrawal from the operating cylinder.

Assembly Instructions
READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR STOVE.
Inspect contents of the box to ensure all parts are included and undamaged.

• Step 1 : Put the stove on a flat surface outdoor.
• Step 2 : Open the lid to stand position.
• Step 3 : Make sure the burner control knobs are in “OFF” position.
• Step 4 : Attach regulator assembly to stove fittings. HAND TIGHTEN ONLY. Do not cross-thread connection.
• Step 5 : Attach propane cylinder to the regulator assembly by turning propane cylinder clockwise. HAND TIGHTEN ONLY. Do not cross-thread connection.
• CAUTION : The cylinder must stay upright. See the diagram on this page.
• Step 6 : Apply “Gas Leak Testing” as described in this manual.
• NOTE : Propane cylinder should be positioned to a minimum of 7.9 in. (200 mm) from the stove.
• This appliance shall only be used with the regulator supplied with this appliance.
• This appliance shall only be used with a propane gas cylinder certified to DOT 39.
• IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF REGULATOR AND GAS CONTAINERS. ONLY USE IN WELL-VENTILATED AREAS.

Gas Leak Testing

WARNING

• Gas leak testing must be performed outdoors in a well ventilated area every time cylinder is connected to stove.

• Always keep unit away from open flames, sparks or lit cigarettes.

• Never use a flame to check for gas leaks.

• Step 1 : Assemble stove per “Assembly Instructions” in this manual. Make sure burner control knobs are in “OFF” position.

• Step 2 : Prepare a soapy water solution (one part dish washing liquid to three parts water) to test for gas leaks in  the connections. Apply a generous amount of the soapy mixture to the regulator assembly at the regulator, along entire length of hose, and at the stove fitting (located on the right side of stove).

• Step 3 : With the burner control knobs in the “OFF” position, check for the bubbles where gas cylinder attaches to regulator assembly, along entire length of hose, and at stove fitting if soapy mixtures starts bubbling, gas is leaking through the connections.

• Disconnect the gas cylinder, re-tighten the connection that is leaking gas, repeat procedure with soapy mixture until gas no longer leaks. NEVER USE A FLAME TO CHECK FOR GAS LEAKS.

• Step 4 : Once all gas leaks have been sealed, WAIT AT LEAST 5 MINUTES FOR GAS FUMES TO DISSIPATE BEFORE LIGHTING THE BURNERS.
  Carefully follow “Operating Instructions” to light the burner and properly operate this unit.

The stove have three burners. Consequently it have three venturies. On each venturie there are two holes acting as first air inlets. These venturies are protected by the control panel like the above illustration. So normally these venturies and those air inlets are free from obstacles. Even though, you will have to check these venturies and air inlets and clean them before every time of using to avoid unexpected obstructing of air supply.

The injector or orifice is well protected by specially designed structure.
Even though it should be cleaned once a year. If the injector hole is blocked and no gas provided from the injector under normal gas pressure, you can try to use a thin pin to pierce it open or you’d better contact with the after- sale center.

Operating Instructions

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY.

WARNING

• DO NOT allow gasoline or other flammable vapors or liquids to come in contact with stove while lighting or at any time during use of stove.
• DO NOT allow the gas hose to come into contact with any hot surfaces. Inspect the hose for damage such as burns, chafing, and kinks before each use.

Step 1 : Make sure “Gas Leak Testing” is completed and the burner control knobs are closed and the stove is on a flat surface away from combustible material. The two side burners are to be ignited by piezo. The middle grill burner is to be ignited by manual. We suggest to ignite one of the two side burners first.

WARNING
The stove shall not be exposed to flammable vapors or liquids during lighting.

Step 2 : Decide which burner to light. Find the right ignition button which ignites this burner. Turn the burner control knob to BIG FLAME position, then push the ignition button to ignite. If no ignition, push the button again. If the burner is the middle burner, then no ignition button equipped. You can just ignite it with a long match.

WARNING
If the burner does not light within 5 seconds, close the burner control knob immediately. Wait at least 5 minutes until gas fumes dissipates before attempting to light burner again.

Step 3 : To light the other burners, reduce the flame on the first lit burner and repeat Step 2 to the other burners.

WARNING
If any of the burners does not light within 5 seconds, close the burner control knob immediately. Wait at least 5 minutes until gas fumes dissipates before attempting to light burner again.

WARNING
When you use the middle burner, the baking pan must be in place.

Step 4 : Adjust burner flame as necessary by using burner control knob. Close the burner control knobs when the
stove is not in use.

Step 5 : After use each time, allow stove to cool completely, then follow instructions in the “After Use Safety” and “Proper Care and Maintenance” sections of this manual.

The appliance shall be used away from flammable materials. Clearance to combustibles : top 48 in. (122 cm), sides 24 in. (61 cm).

Warning
When you use the middle burner, the baking pan must be in place.

After-use Safety

• Always allow the stove to cool completely before handling.
• Always disconnect the gas cylinder from stove when not in use, a safety cap should be placed on the gas cylinder.
• Detach regulator assembly and store under grill inside stove.
• Never store gas cylinder in an enclosed area like house, garage, etc. Store the gas cylinder outdoors in well ventilated, shaded area away from any heat source or open flame.
• Fold lid back into their closed position.

Proper Care & Maintenance

• Do not leave this appliance unattended while the appliance is in operation; keep children and pets away from the appliance at all times.
• Wash cooking grill with hot, soapy water, rinse well and dry before storing. Wipe remaining exposed parts of stove with damp cloth. Do not use abrasive materials.
• To protect your stove, the unit must be kept clean and covered at all times when not in use. Cover and store stove in a protected area away from children and pets.
• After product has been stored and prior to reusing, verify that burners are free from leaves, insects, spider webs, dirt, etc., as these items can obstruct the flow of combustion air.
• Prior to each use, visually check the burner flame for proper operation as described in this manual.
• DO NOT use if burner/flame is not operating properly.
• This stove requires an unobstructed airflow to operate correctly.
• During use or storage, always keep the stove area clear and free of combustible materials, gasoline and other flammable vapors and liquids.

NOTE: Due to the intense heat from burner, it is normal for discoloration to occur on stove during the first few uses.
NOTE: Do not allow a build-up of grease or fat to occur, this could inadvertently ignite and cause a fire.

Abnormal Operation

WARNING

• Do not connect the stove to a gas cylinder when the valve is open.
• Do not set up the stove when any part of the stove is broken.
• Close the stove when the flame is too high.
• Close the stove when you smell the flavor of gas.
• Close the stove when you see flame on anywhere other than the burners.
• Clean the stove after each time of cooking.
• If any part of the stove is broken, do not try to repair it. What you should do is to ask the after-sale center for help.
• Always ask the after-sale center to change any part of the stove.
• Do not modify this appliance.
• Using dampened cloth to clean the stove when needed.
• Check that seals between the appliance and the gas container are in place and in good condition before connecting the gas container.
• Do not use this appliance if it has damaged or worn seals.
• Do not use this appliance if it is leaking, damaged or does not operate properly.
• The appliance is to be operated on a horizontal surface.
• Gas containers shall be changed in a well-ventilated location, preferably outside away from people and any sources of ignition, such as naked flames, pilot flames, electric heaters/ equipment.
• If there is a leak from your appliance (smell of gas), turn off the control valve, and disconnect gas cylinder.
• If there is a leak from your appliance (smell of gas) and you cannot stop the gas flow, remove the appliance to a well-ventilated location away from any ignition source.
• heck for leaks using soapy water. Do not try to detect leaks using a flame.
• This appliance must only be serviced by an authorized person.
• When the stove is in hot, just wait until it gets cool down, other wise you will be burned. If you have to deal with the stove when it is hot, you will have to have a heat insulating glove to avoid being hurt.
• Storage of the appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance.
• Warning: Do not move the appliance during operation.
• When the normal flame starts to getting weak and finally distinguishes, it means the gas in the gas cylinder is used up. You will have to use a new gas cylinder with gas.

The LP-gas cylinder(s) used with this stove shall be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation or Transport Canada, the Standard for Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA B339.
Only cylinders marked with the proper fuel type approved for the appliance shall be used. The cylinder supply system be arranged to provide for proper fuel withdrawal from the operating cylinder. It may be hazardous to attempt to fit other types of gas containers. Do not use the stove in temperatures below -4 ºF (-20 ºC). Do not store the stove in temperatures below -4 ºF (-20 ºC).

Specifications

3330-A Marathon Ct Charleston, SC 29418

• Visit Us : Camplux.com
• 1(844) 538-7475
• support@camplux.com

References

• Camplux | Top-rated Tankless Water Heaters | Adventure Enhanced
• Camplux | Best Tankless Water Heaters | Camplux

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>