POLAR CD086, CD087, CD088, CB921 Display Refrigerator Freezer Instruction Manual
- June 3, 2024
- Polar
Table of Contents
Display Refrigerator/ Freezer
Instruction manual
Refrigerators/Freezers
Handleiding
Model: CD086
Safety Instructions
-
Position on a flat, stable surface.
-
A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.
-
Consult Local and National Standards to comply with the following:
– Heal th and Safety at Work Legislation
– BS EN Codes of Practice
– Fir e Precautions
– IEE Wiring Regulations
– Building Regulations -
DO NOT use jet/pressure washers to clean the appliance.
-
DO NOT use the appliance outside.
-
DO NOT use this appliance to store medical supplies.
-
DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
-
DO NOT store products on top of the appliance.
-
Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.
-
Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance.
-
Always switch off and disconnect the power supply to the unit before cleaning.
-
Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities.
-
If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard.
-
Children should be supervised to ensure that they do not play with the appliance.
-
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.
-
POLAR recommends that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity, and Functional Testing.
-
POLAR recommends that this product is connected to a circuit protected by an appropriate RCD (Residual Current Device).
Caution: Risk of Fire
- Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of obstruction. The unit should not be boxed in without adequate ventilation.
- Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
- Warning: Do not damage the refrigerant circuit.
- Warning: Do not use electrical appliances inside the food storage compartments of the appliance.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
- POLAR Refrigerator / Freezer
- Shelves
- Keys x 2
- Spacers x 2
- Instruction Manual
POLAR prides itself on quality and service, ensuring that at the time of
unpacking the contents are supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR
dealer immediately.
Installation
Note: A bracket is used to support the door during transportation. On
receipt please remove the bracket.
Note: Not for use in vans or trailers, food trucks or similar vehicles.
If the unit has not been stored or moved in an upright position, let it stand
upright for approximately 12 hours before the operation. If in doubt allow
standing.
- Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
- To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE.
Note: Before using the appliance for the first time, clean the shelves and
interior with soapy water then dry well.
The appliance is supplied with feet by default. However, castors can be
supplied as an option from serial number range: 8124199-UK / 8128873-EU
onwards.
Reversing the door (excluding model CB921)
Depending on the location of the appliance, it may be necessary to change the
direction the door opens by changing the side of the door handle. (Tip: Images
in this section are for illustration only and may slightly differ from the
actual appliance appearances.)
To reverse the door handle:
- The door handle is on the left side. Disassemble the right lower hinge.
- Remove the door from the right upper hinge. Then remove the hinge sleeve from the door top.
- Remove the right upper hinge and install it on the left side. Afterward, install the hinge sleeve onto the hinge.
- Reverse the door and hang it onto the left upper hinge.
- Remove the pre-mounted screws on the left lower side.
- Install the previously removed right lower hinge on the left side.
- Secure the hinge in place using the previously removed screws.
- Now the door handle is installed on the right side.
Operation
Control Panel
The control panel is located on the front of the appliance.
Turn On
- Close the door of the appliance.
- Connect the appliance to a mains power supply.
Set the Operating Temperature
- Press the SET button for 3 seconds. The display will flash.
- Press the or buttons to display the required temperature.
- Press the SET button to store the temperature.
Manual Defrost
Press and hold the defrost button “aux” for 2 seconds to begin a manual
defrost. The defrost light illuminates.
Storing Food
To get the best results from your POLAR appliance, follow these instructions:
- Only store foodstuffs in the appliance when it has reached the correct operating temperature.
- Do not place uncovered items as below inside the appliance, as this can lead to a damaged and leaking evaporator, and thus void your warranty: hot food, hot liquids, acidic fluids, acidic products.
- Wrap or cover food where possible.
- Do not obstruct the fans inside the appliance.
- Avoid opening the doors for prolonged periods of time.
Lock/Unlock the Doors
- A lock is fitted to the doors to ensure foodstuffs are kept secure within your POLAR appliance.
- Use the keys provided to lock/unlock the door.
Cleaning, Care & Maintenance
- Switch off and disconnect from the power supply before cleaning.
- Clean the interior of the appliance as often as possible.
- Do not use abrasive cleaning agents. These can leave harmful residues.
- Clean the door seal with warm soapy water.
- Always wipe dry after cleaning.
- Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
- Take care when cleaning the rear of the appliance. Sharp edges can cut.
Condensation will form in refrigeration with the frequent opening of the doors
and on hot humid days, please ensure condensation is allowed to drain properly
or is wiped dry.
Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance.
POLAR recommends that a POLAR agent or qualified technician should clean the
condenser.
Note: if the condenser coil is not cleaned at least 4 times a year, the
efficiency of the appliance will decrease significantly.
Troubleshooting
A qualified technician must carry out repairs if required.
| Fault | Probable Cause | Solution |
|---|---|---|
| The appliance is not working | The unit is not switched on | Check the unit is |
plugged in correctly and switched on
Plug or lead is damaged| Replace Plug or lead
The fuse in the plug has blown| Replace the fuse
Mains power supply fault| Check the mains power supply
The appliance turns on, but the temperature is too high/low| Too much ice on
the evaporator| Defrost the appliance
Condenser blocked with dust| Clean the condenser
Doors are not shut properly| Check doors are shut and seals are not damaged
The appliance is located near a heat source or airflow to the condenser is
being interrupted| Move the refrigerator to a more suitable location
The ambient temperature is too high| Increase ventilation or move the
appliance to a cooler position
Unsuitable foodstuffs are being stored in the appliance| Remove any excessive
hot foodstuffs or blockages to the fan
Appliance is overloaded| Reduce the amount of food stored in the appliance
The appliance is leaking water| The appliance is not properly leveled| Adjust
the screw feet to level the appliance (if applicable)
The discharge outlet is blocked| Clear the discharge outlet
The appliance is leaking water| Movement of water to the drain is obstructed|
Clear the floor of the appliance (if applicable)
The water container is damaged| Call a POLAR agent or qualified Technician
The drip tray is overflowing| Empty the drip tray (if applicable)
The appliance is unusually loud| Loose nut/screw| Check and tighten all nuts
and screws
The appliance has not been installed in a level or stable position| Check
installation position and change if necessary
The display lamp does not light| Lamp needing replacing| Call a POLAR agent or
qualified Technician
Technical Specifications
Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice.
Model| Voltage| Power| Current| Temperature
Range| Gross
Capacity
(L)| Net usable
capacity
(1)| Refrigerant| Dimensions
HxWxDmm| Weight
(kg)
---|---|---|---|---|---|---|---|---|---
CD086| 230V
50Hz| 150W| 1.1A| 2°C — 8°C| 150| 118| R600a| 855 x 600 x619| 47
CD087| 185W| 1.5A| 2°C — 8°C| 400| 246| R600a| 1850 x 600 x600| 72
CD088| 185W| 1.5A| 2°C – 8°C| 600| 414| R600a| 1895 x 777 x735| 93
CB921| 500W| 2.35A| -10°C — -20°C| 365| 258| R290| 1855 x 600 x620| 76
Impact of temperature settings on food waste:
In order to reduce food waste from decomposition or dehydration, this
appliance should be operated in
its designated operating range.
Optimum temperature for food storage: 4°C (CD086/CD086/CD088), -18°C (CB921)
To order spare parts please contact your Polar Stockist:
https://www.polar-refrigerator.com/stockist
The minimum period of spares parts to be available: Door handles, door hinges,
knobs, dials and buttons, door gaskets, peripheral trays, baskets and racks
for storage, as appropriate to the appliance, will be made available to both
end users and professional users for a minimum of eight years after the last
unit of the model is placed on the market. A broader selection of parts will
also be made available to Professional users for this period
Model information can be found on the product database:
https://eprel.ec.europa.eu/screen/product/refrigeratingappliancesdirectsalesfunction
Model information can be found on the product:
The Model Identifier can usually be found on the inside wall and on the
reverse of the unit.
Note: Polar offers a 2-year minimum warranty, please contact the
authorized representative for more details.
Electrical Wiring
The appliance is supplied with a 3-pin BS1363 plug and lead.
The plug is to be connected to a suitable main socket.
The appliance is wired as follows:
- Live wire (colored brown) to the terminal marked L
- Neutral wire (colored blue) to the terminal marked N
- Earth wire (colored green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency, disconnection is required they must be readily accessible.
Disposal
EU regulations require refrigeration products to be disposed of by specialist
companies who remove or recycle all gasses, metal and plastic components.
Consult your local waste collection authority regarding the disposal of your
appliance. Local authorities are not obliged to dispose of commercial
refrigeration equipment but may be able to offer advice on how to dispose of
the equipment locally.
Alternatively, call the POLAR helpline for details of national disposal
companies within the EU.
Compliance
The WEEE logo on this product or its documentation indicates that the product
must not be disposed of as household waste. To help prevent possible harm to
human
health and/or the environment, the product must be disposed of in an approved
and environmentally safe recycling process. For further information on how to
dispose of
this product correctly, contact the product supplier, or the local authority
responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with
regulatory standards and specifications set by international, independent, and
federal authorities.
POLAR products have been approved to carry the following symbol:All rights
reserved. No part of these instructions may be produced or transmitted in any
form or by any means, electronic, mechanical, photocopying, recording or
otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to
press, however, POLAR reserve the right to change specifications without
notice.
DECLARATION OF CONFORMITY
| Equipment Type | Model |
|---|
C-Series Fridge
1. Stainless Steel Under
Counter 150Ltr
2. Stainless Steel Upright
400Ltr
3. Stainless Steel Upright
600Ltr
4. White Under Counter
150Ltr
5. White Upright 400Ltr
6. White Upright 600Ltr
| C-Series Freezer
7. Stainless Steel Under
Counter 140Ltr
8. Stainless Steel Upright 365Lt
9.Stainless Steel Upright 600Lt
10.White Under Counter
140Ltr
11.White Upright 365Ltr
12.White Upright 600Ltr
| C-Series Display
13.White Under Counter Fridge
150Ltr
14.White Upright Fridge 400Ltr
15.White Upright Fridge 600Ltr
16.White Upright Freezer
365Ltr
| 1.CD080
2.CD082
3.CD084
4.CD610
5.CD612
6.CD614 | 7.CD081
8.CD083
9.CD085
10.CD611
11.CD613
12.CD615
(including -E
& -A models) | 13.CD086
14.CD087
15.CD088
16.CB921
Application of Territory Legislation &
Council Directives(s) CB921 ( &-E) – EN60335-1:2012 +A11:2014 +A13:2017
only | Machinery Directive 2006/42/EC
Supply of Machinery (Safety) Regulations 2008
EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019
**+A14:2019 +A2:2019*
EN 60335-2-89:2010 +A1:2016 +A2:2017
EN 62233:2008
Electro-Magnetic Compatibility (EMC) Directive
2014/30/EU – recast of 2004/108/EC
Electromagnetic Compatibility Regulations 2016
(S.I. 2016/1091)
EN 55014-1: 2017
EN 55014-2:2015
EN 61000-3-2: 2014
EN 61000-3-3: 2013
Regulation (EU) 2015/1095 – Ecodesign professional refrigerators
EN 16825: 2016 +A1:2019
Regulation (EU) 2019/2024 – Ecodesign direct sales
refrigerators
ISO 23953-2:2015
Restriction of Hazardous Substances Directive
(RoHS) 2015/863 amending Annex II to Directive
2011/65/EU
Restriction of the Use of Certain Hazardous
Substances in Electrical and Electronic
Equipment Regulations 2012 (S.I. 2012/3032)| Electrical Safety
IEC 60335-1:2010 +A1:2013 +A2:2016
IEC 60335-2-89:2010 +A1:2012 +A2:2015
Electromagnetic Compatibility
EN 55014-1: 2017
EN 55014-2:2015
EN 61000-3-2: 2014
EN 61000-3-3: 2013
Producer Name| Polar**
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s).
Date
Signature
Full Name
Position
Producer Address
21 st April 2022
| |
Technical & Quality Manager| Commercial Manager/Importer| Commercial Manager/
Responsible Supplier
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom| Unit 9003,
Blarney Bus. Park,
Blarney,
Co. Cork
Ireland| 15 Bagdally Road,
Campbelltown
NSW 2560
+44 (0)845 146 2887
http://www.polar-refrigerator.com/
CD086-CD087-CD088_CB921_ML_A5_v21_2022/10/20
CD086-CD087-CD088_CB921_ML_A5_v21_20221020.indb 52
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>