DURACELL PowerBlock™ 500 Gasless Generator User Guide

DURACELL PowerBlock™ 500 Gasless Generator

Product Details

• A. Intelligent LCD screen: See details at right
• B. USB power button and ports
• C. AC power button and outlets
• D. 12V power button and accessory socket
• E. AC input port: Use AC charging cord (included)
• F. Solar charge controller
• G. AC charging cord

Intelligent LCD Screen Details

• A.Charging Input Indicators

  •  Time to fully charge (hours to full)
  •  AC or solar charge detected
  •  Input wattage

• B Fuel Gauge Indicators

  •  Percentage of available battery power
  •  Battery graph fuel gauge

• C. Power Output (Usage) Indicators

  •  Total output wattage
    Time remaining to empty at current output

• D. Warning Indicators

  •  HI TEMP/LO TEMP
  •  OUTPUT OVERLOAD
  •  LOW BATTERY

Getting Started: Charging the PowerBlock

• The PowerBlock can be charged from grid power (AC) or solar energy (solar panels).
•  When it is being charged and discharged (used to power your items) at the same time:
•  If the input power (charging the PowerBlock) is greater than the output power (used to power your items), the intelligent LCD screen will show the “Hours to Full”.
•  If the input power (charging the PowerBlock) is less than the output power (used to power your items), the intelligent LCD screen will show the “Hours to Empty”.
•  The LCD screen stays on during charging but it can be turned off by pressing the DISPLAY button below the screen.
• If your PowerBlock is fully discharged (0% available power), the intelligent LCD screen will be completely dark. This screen will illuminate as soon as the PowerBlock is connected to power, letting you know that the
  unit is charging, and will continually display the growing power status as the PowerBlock charges.

Charging the PowerBlock from an AC outlet

Charging the PowerBlock from a solar panel

Using the PowerBlock

Household Items: Typical Estimated Run Times With PowerBlock

Troubleshooting Guide

Your PowerBlock features several built-in protection features to ensure safe and efficient operation. Below is a guide which shows the typical faults that occur during normal operation and how to correct them and resume use.
If a fault occurs, the following warning(s) will appear on the intelligent LCD screen. Please refer to the table below to safely correct any problems and allow your PowerBlock to reset and resume operation. If you have additional
questions, please contact Customer Service at 800-300-1857

Safety Information

This section contains important safety information. Before using the product, READ ALL instructions and cautionary markings on or provided with the product, and all appropriate sections of this guide. The product contains no user- serviceable parts. SAVE THESE INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

•  When using this product, basic precautions should always be followed, including the following:
•  Read all the instructions before using the product.
•  To reduce the risk of injury, close supervision is necessary when the product is used near children.
•  Do not put fingers or hands into the product.
•  Do not expose PowerBlock to rain or snow.
•  Use of an attachment not recommended or sold by PowerBlock manufacturer may result in a risk of fire, electric shock, or injury to persons.
•  To reduce risk of damage to the electric plug and cord, pull the plug rather than the cord when disconnecting the PowerBlock.
•  Do not use the PowerBlock or appliance that is damaged or modified. A damaged or modified PowerBlock may exhibit unpredictable behavior resulting in fire, explosion or risk of injury.
•  Do not operate the PowerBlock with a damaged cord or plug, or a damaged output cable.
•  Do not disassemble the PowerBlock, take it to a qualified service person when service or repair is required. Incorrect reassembly may result in a risk of fire or electric shock.
• To reduce the risk of electric shock, unplug the PowerBlock form the outlet before attempting any instructed servicing.

PERSONAL PRECAUTIONS

•  When charging the internal battery, work in a well ventilated area and do not restrict ventilation in any way.
• Do not expose a PowerBlock to fire or excessive temperature. Exposure to fire or temperature above 130°C / 266°F may cause explosion.

SAVE THESE INSTRUCTIONS

WARNING: NO USER-SERVICEABLE PARTS

There are no user serviceable parts in this unit, DO NOT attempt to open the PowerBlock; this is dangerous and will void the warranty..

WARNING: HEAT GENERATION DURING CHARGING AND USE

Charging and discharging generates heat and requires proper air flow. Use in a ventilated area and ensure adequate clearance for the ventilation grills. Blocking the grills may cause overheating and damage to the unit.

WARNING: RISK OF ELECTRIC SHOCK INJURY

•  Do not operate or store in moist conditions to avoid electric shock.
•  If the unit gets wet wait for it to dry completely before using it.
•  Do not insert foreign objects into any of the ports or openings.

WARNING: RISK OF ELECTRIC SHOCK OR FIRE HAZARD

•  Review the specifications of the PowerBlock ports and all connected devices you intend to use.
•  The output ports can generate dangerous voltages.
•  Do not use the PowerBlock if it is damaged or any of the input or output cords are damaged.

Maintenance

•  Clean the surface of the PowerBlock when necessary. Always use a soft sponge or cloth for cleaning. A mild, non-abrasive cleaning detergent may be used to remove stubborn dirt.
• Avoid using your PowerBlock in dirty conditions where foreign matter such as dust, dirt and moisture can clog the AC and USB outlets and charging ports. Keep the PowerBlock in a well-ventilated area away from direct exposure to outside elements whenever possible.

Product Specifications

FCC Information

This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmtul interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and the receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.

Support and Warranty

Contacting Customer Support

If you experience any problems or have any questions regarding your DURACELL product, free technical support is available. Call from a phone where you have access to your DURACELL product.

Be prepared to provide the following information:

• Name, address and telephone number
• Name of the DURACELL product
• Make and model of any items or devices that you are using with the DURACELL product
• Symptoms of the problem(s) and what led to them

Technical Support is available by telephone:

• U.S. and Canada 800-300-1857
• Outside of the US/Canada: 805-437-7765
• Written inquires should be directed to: Battery-Biz Inc.;
• DURACELL Product Inquiry
• 1380 Flynn Road, Camarillo, CA 93012, USA

Recycling Information
Battery-Biz is committed to environmental responsibility and recommends that electronic devices be disposed of properly. Please contact your local city offices for information on recycling and disposal programs for e-waste. For instructions on how to recycle this product visit http://www.call2recycle.org

Two Year Warranty

Limited Warranty

The DURACELL product carries a limited warranty against defects in material and workmanship under normal use and service for two (2) years from the original date of purchase. The manufacturer or distributor, at its option, shall repair or replace the defective unit covered by this warranty. Please retain the dated sales receipt as evidence of the date of purchase as it wil be required for any warranty service. In order to keep the warranty in effect, the product must have been handled and used as described in the instructions accompanying this warranty. This warranty does not cover any damage due to accident, misuse, abuse or negligence.

Disclaimer Of Warranty

The limited warranty described herein is your sole remedy. To the extent permitted by law, the manufacturer and distributor disclaim all other implied or express waranties including all warranties of merchantability and fitness for any particular purpose.

Limitation Of Liability

Except to the extent of repairing or replacing this product as expressly stated in the limited waranty described hrein, the manufacturer and distributor shall not be liable for any damages, whether direct, indirect, incidental, special, consequential, exemplary, or otherwise, including lost revenues, lost profits, loss of use of software, loss or recovery of data, rental of replacement equipment, downtime, damage to property, and third-party claims, arising out of any theory of recovery, including statutory, contract or tort. Notwithstanding the term of any limited or implied warranty, or in the event that any limited warranty fails of its essential purpose, in no event will the manufacturer’s and distributors’ entire liability exceeds the purchase price of this product. Some states and provinces do not allow the exclusion or limitation of incidental or consequential damages so the above limitations or exclusions may not apply to you. This limited warranty gives you specific legal rights. You may have other rights which vary from state to state and province to province.

Product Registration

For complete warranty coverage, please register your Duracell product within fourteen days of purchase. Visit DuracelIPower.com/Register or scan the QR code below to register.

References

• Duracell Power | Gasless Generator, Jump Starters, Maintainers – DuracellPower
• Product Registration – DuracellPower
• Call2Recycle | Leading the Charge For Battery Recycling
• Batteries | #1 Trusted Battery Brand | Duracell

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>