LITEHAWK BIG TOM 4×4 Remote Controlled Rock Racer Vehicle Toy Instruction Manual

LITEHAWK BIG TOM 4×4 Remote Controlled Rock Racer Vehicle Toy

PLEASE DO NOT RETURN THIS PRODUCT TO ANY RETAIL STORE.
For any questions or problems with this product please visit our website www.litehawk.ca
Made for and distributed by Borgfeldt (Canada) Limited 50 Konrad Cres., Markham, ON L3R 8T4

LiteHawk BIG TOM Precautions –
The LiteHawk BIG TOM is not intended for children under the age of 6 unless closely supervised by an adult. Improper use may cause serious injury. Please read NIMH Battery section before use. Do not run in rain, snow or if there is lightning and/or thunder. Do not touch ANY moving parts while the model is powered.

WARNING: CHOKING HAZARD – Small parts. Not For Children under 3 years
CAUTION: Do not touch the running model! Adult supervision is required!
CAUTION: Never insert any sharp objects, pins or screws into the model as this may puncture the internal battery!

SAFETY PRECAUTIONS

• Keep hands, hair and loose clothing away from moving parts when the model is powered ON.
• Turn off controller/charger and BIG TOM when not in use.
• Remove battery from controller/charger when not in use.
• Parental guidance is recommended for use.
• Keep your BIG TOM in your sight so that you can supervise it at all times.
• New AA alkaline batteries are recommended for use in the controller to obtain maximum performance.
• Your charger is tailor made for the NIMH battery used in your LiteHawk BIG TOM. Do not use it to charge any battery other than that in the LiteHawk BIG TOM.

BATTERY SAFETY INFORMATION

• Requires 3 x 1.SV AA batteries (not included)
• Batteries are small objects .
• Replacement of batteries must be done by adults.
• Follow the polarity(+/-) diagram.
• Promptly remove dead batteries from the toy.
• Dispose of used batteries properly.
•  Remove batteries for prolonged storage.
• DO NOT incinerate used batteries
• DO NOT dispose of batteries in fire, as batteries may explode or leak.
• DO NOT mix old and new batteries or different types of batteries (i.e. alkaline/standard)
• Always replace the whole set of batteries at one time.
• DO NOT short-circuit the supply terminals

CARE AND MAINTENANCE

• Always remove batteries from the controller when it is not being used for a long period of time.
• Unplug battery from toy when not in use.
• Keep the toy away from direct heat or extreme cold.
• Do not expose the toy’s interior to water or moisture. This can damage the electronic assemblies.

Your LiteHawk BIG TOM is equipped with a NIMH battery.
Special NIMH Battery Instructions:

• Never charge battery unattended.
• Charge battery in isolated area. Keep away from flammable materials.
• Do not expose to direct sunlight. There is a risk of the batteries exploding, overheating or igniting.
• Do not disassemble, modify, heat or short-circuit the batteries. Do not place them in fires or leave them in hot places.
• Only charge the batteries with the specified battery charger.
• Only use the batteries in the device specified by LiteHawk.
• Batteries must be recycled or disposed of properly.
• Do not leave plugged into model when not in use.
• Do not charge if battery or connector is wet.

Before charging the LiteHawk BIG TOM please read the following!

• DO NOT leave the battery unattended during charging.
• DO NOT leave the battery plugged into the charger any longer than 5 hours maximum. If the charging light does not turn off in this time, the charger or battery could be faulty – unplug immediately!
• DO NOT install another battery without letting the motor cool first! 5-10 minutes is sufficient.
• DO NOT recharge the battery until it is cool to the touch! 10 minutes is sufficient.
• DO NOT charge if the battery or connector are wet.
• Remove battery from model when charging.

Welcome to the World of LiteHawk!

Before we get ready for your first driving adventure, let’s cover the basics together!
BIG TOM is a scaled down version of an Off Road Truck – it will blast across all types of terrain and thrill with big slides! The chassis is designed with 4-wheel independent sus­pension, and long travel shocks that soak up bumps.
Attempting to use your LiteHawk BIG TOM without completely reading the manual may cause injury to yourself and people in the vicinity, as well as damage to the R/C model. Please read the Instruction Manual thoroughly before using this product.

LiteHawk R/C Car and Truck Terms 101
Transmitter: The hand-held radio unit that sends throttle and steering inputs to your model. Also known as the radio or controller.
Servo: Small motor unit in your model that operates the steering mechanism.
ESC: The Electronic Speed Control provides digital proportional throttle control to the model’s motor based upon your throttle input on the radio.

LiteHawk BIG TOM – Transmitter Set Up

• Always use fresh AA batteries in the Pistol Grip Radio Controller (Transmitter).

1.  Make sure the transmitter is turned off.
2. / Open the Battery Cover using a Phillips screw driver (not included).
3. / Insert 3 x AA batteries, noting correct polarity.
4. / Replace battery door securely.

•  ALWAYS REMOVE THE BATTERIES FROM THE TRANSMITTER WHEN YOU WILL NOT BE USING YOUR MODEL FOR LONG PERIODS OF TIME.
• Dispose and recycle correctly when there is no longer power in the batter­ies, they should be disposed of at an approved battery recycling center. DO NOT THROW IN HOUSEHOLD WASTE!
• Never expose the transmitter or bat­teries to moisture.

LiteHawk BIG TOM – 2.4 Ghz
Your LiteHawk BIG TOM comes with a 2.4 Ghz radio system, which allows you to play without the fear of ever losing control! Race or play with countless other drivers. The range of your model is approximately 150ft which, due to its small size, is in excess of normal vision. The farther the model goes away from you the smaller it will become and the harder it will be to determine the model’s direction We suggest you stay at a distance between 20ft-50ft, this keeps your BIG TOM within a safe operational distance.

LiteHawk BIG TOM – Controller Functions

LiteHawk BIG TOM – Battery & Charger

Your LiteHawk BIG TOM comes with a NIMH battery and a USB charger.

Battery
The rechargeable battery provides the power to propel your model at high speeds. You should expect 7-10 min run time. Extra batteries are available at www.litehawk.ca

• Once the model starts to slow, drive your model to a safe place, walk over and turn it off.
• Never dead short a NIMH battery (never touch positive and negative together)!
•  You Must FULLY charge the battery before using your new model.
• Do not leave the battery plugged into the model when it is not being used.
• Keep the battery dry at all times.

NIMH Battery and Charger Instructions

Your New LiteHawk comes with a rechargeable NIMH battery. This battery powers the vehicle.
Please read the following information before using your new LiteHawk.
Always have your model turned off when not in use.

1. STEP 1: Plug the USB into your computer, TV, or USB charger. The LED light on the USB will be ON.

2. STEP 2: Connect the battery to the USB charger. The LED light will blink red.

3. STEP 3: When the LED indicator light on the charger turns off, the battery is fully charged.
   Charge times are (180-240 minutes) do not leave on charge overnight. Battery should be unplugged from the charger after a maximum 5 hours.

4. STEP 4: Unplug the battery from the charger.

5. STEP 5: Install battery into your vehicle.

During charging

• It is normal for the battery to get warm during the charging process. Do not charge the battery on a surface that is flammable or can be damaged by heat.
• Do not leave the battery and charger unattended while charging.
• Do not store the battery plugged into the charger

Installation of battery into the BIG TOM

Place your BIG TOM on a clean flat surface. Avoid areas where small parts may be lost. The battery is housed in the battery compartment located in the top of the chassis. You will see 4 turn tabs or posts that hold the cover in place.

• Turn the tabs, open the battery compartment door.
• Place your fully charged battery in the battery slot. Connect the battery connector. Don’t force it, it only goes one way!
• Close the battery compartment door and turn the tabs back into place.

How to Start!
The BIG TOM is ready to play right out of the box! To get it started:

1. . Plug in the battery in the BIG TOM.
2. Switch ON the transmitter.
3. Turn the BIG TOM power switch ON.

Battery Guidelines

•  The battery can be re-charged many times, however over time the battery will lose its ability to take or hold a charge. At this point the battery will need to be properly recy­cled.
• Do not store or leave batteries in areas with extreme heat or cold. Batteries should be left and stored at room temperature.
• Always have the battery unplugged from the toy or charger when not being used.
• Do not submerge batteries under water. Always wipe off any water with a clean towel or rag.
• It is best to store the battery out of the toy and on a non-flammable surface.

Before you drive:

Before every use it’s recommended to check that the steering and drivetrain are moving freely and nothing is binding. Next ensure that the model and the transmitter are working correctly. Before you drive your model, range test the radio system to ensure that it operates properly! Turn on the transmitter and then the model, check its operat­ing as it should. Walk away from the model giving steering input with the radio until you reach the maximum distance you are planning to drive your model. If you lose input control walk back towards the model. You now know the safe operating distance for your immediate environment. Do not attempt to operate the model if there is any problem with the radio system/external interference with your radio signal at your location.

Let’s hit the road!
The ESC system is not waterproof. Avoid driving through puddles, mud, or snow. If water gets into the electronics it could damage them.

• Avoid overloading your model. Never run it in areas where its movement will be restrict­ed, thick grass, weeds, mud etc. as this can over-stress the motor and bind the drive­train.
• Ensure nothing prevents the smooth running of the moving parts.
• Do not run your model in confined spaces. This is an outdoor toy, do not run in your home.
• Never run your model in a public space where it might upset or endanger people or wild­life.
• Immediately discontinue use of your vehicle and transmitter if you see lightning or hear thunder. Never use your vehicle in the rain.
• Do not dismantle or tamper with this R/C vehicle or its transmitter. The manufacturer and distributor will accept no responsibility, expressed or implied, for accidents or injuries caused as a result of disassembly, modification and/or usage against the instructions for this product.
• The transmitter’s range will vary depending on your surroundings and battery strength. Do not operate the model too far away or control could be lost (stay within 20-50 ft).
• Ensure that all batteries are correctly installed and that the NIMH battery is fully charged and in good condition.
• Do not touch ANY moving parts during operation.
• Don’t run in public roads with traffic!
• If your Car/Truck becomes stuck against something, release the throttle. Do not continue to push the throttle or run the motor. Do not try to push, pull, or tow objects of any weight as this will increase heat in the electronics and cause failures.

LiteHawk BIG TOM – After Use Care

1. When you have finished using your LiteHawk BIG TOM you should first disconnect the NIMH battery, then switch OFF the transmitter.
2. Remove the NIMH battery from the vehicle.

Care and Maintenance:

When you are finished running your model for the day, blow it off with compressed air or use a soft bristled paint brush to dust-off the vehicle. Always disconnect and remove the battery from the model whenever the model is stored.
Your model is going to require maintenance in order to stay in tip top running order. Check for the following:

1.  Check the wheels and steering for binding.
2. Check the tightness of the wheel nuts with the wheel wrench.
3.  Look for any cracked, bent, or damaged parts
4. Check for any loose screws in the chassis structure or suspension
5. Inspect the gears for wear or broken teeth.

LiteHawk BIG TOM – Storage

• Remove all batteries before storing your vehicle.
• Never store your LiteHawk BIG TOM near open flames, in high temperatures (including near radiators) or in direct sunlight. Ideally, place the model in a warm dry location.
• Care must be taken when handling rechargeable batteries to avoid the possibility of injury and/or damage to property.

LiteHawk Parts & Tech
There’s nothing worse than buying a new toy, having a question, or needing a replacement part, and then being left out in the cold. No worries! We pride ourselves on the very best customer service!
We have all the parts you’ll ever need to keep your new LiteHawk in tip top shape! Like we always say, “accidents happen, even to the best of us” …. with that in mind www.litehawk.ca is always available!
We ship your parts Same Day! Except weekends of course – that’s when we are out playing too!

LiteHawk Guarantee
All LiteHawk products have been tested and designed to perform as claimed out of the box. If you have an issue with a product or part of a product please contact us directly. We cover claims towards manufacturing defects. We know that there is nothing worse than having a question or needing a replacement part and having nowhere to go. LiteHawk is not responsible for covering the costs of replacement parts or repair on products that have been damaged due to product use.

www.litehawk.ca

See all of our Litehawk products in action! Everything from videos that show LiteHawks in their natural environments – flying, sailing, power boating …. to helpful In-Depth product  information too! It’s all just a mouse click away!

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>