HENDI 149508 Gas Barbecues Green Fire User Manual

HENDI 149508 Gas Barbecues Green Fire User Manual

Read user manual and keep this with the appliance.

NOTE: This manual is translated from original English manual using AI and machine translations.

Use outdoors only.
Read the instructions before using the appliance.
WARNING: accessible parts may be very hot.
Keep young children away.

Dear Customer,
Thank you for purchasing this HENDI appliance. Read this user manual carefully, paying particular attention to the safety regulations outlined below, before installing and using this appliance for the first time.

Safety instructions

• Only use this appliance outdoors.
• Incorrect operation and improper use of the appliance can seriously damage the appliance and injure users.
• The appliance may only be used for the purpose it was intended and designed for. The manufacturer is not liable for any damage caused by incorrect operation and improper use.
• Never try to open the casing of the appliance yourself.
• Do not insert any objects in the casing of the appliance.
• Do not use the appliance after it has fallen or is damaged in any other way. Have it checked and repaired, if necessary, by a certified repair company.
• Do not try to repair the appliance yourself. This could give rise to life-threatening situations.
• Always keep an eye on the appliance when in use.
• Children do not understand that incorrect use of appliances can be dangerous. Therefore, never let children use appliances without supervision.
• Do not use any extra devices that are not supplied along with the appliance.
• The use of the installation must comply with the applicable national and local regulations.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
• This appliance is intended solely for preparing food.
• Gas and electrical installations should be checked at least once a year.
• Note: the griddle is hot. Let it cool down before touching or removing it.
• We recommend to use only gas cylinders with a capacity of more than 10 kilograms.
• Perform gas cylinder replacement away from potential ignition sources.
• Always place the gas cylinder adjacent to the appliance, not underneath it.
• If a gas leak is detected immediately close the gas valve.
• Note that parts of the barbecue can become very hot. Wear protective clothing (gloves) if you must touch them anyway.

Special safety instructions

• Use only the supplied pressure regulator.
• This appliance is suited for propane and butane gas.
• Check that there are no kinks in the gas hose.
• Keep the appliance away from (easily) flammable materials.
• If a gas leak is detected immediately close the gas valve on the gas bottle.
• Certain accessible parts of the barbecue can become extremely hot during operation. In view of this, keep the barbecue out of reach of children.
• The barbecue may only be installed against or on fire-resistant surfaces.
• The barbecue is intended for professional use and can only be used by authorized personnel.
• The barbecue must be installed in accordance with the applicable national regulations.
• Do not move the barbecue during use.
• Always close the gas valve on the gas bottle if the barbecue is no longer being used.
• Changing or modifying this equipment is dangerous and therefore not allowed.
• Parts which are fastened or sealed by the manufacturer, are not to be loosened or adjusted by the user.
• Install the barbecue as level as possible with regard to the grease drain.
• Do not cover the ventilation openings in the barbecue.
• To prevent blockage of the ventur is, keep the ventur is and the surrounding area clean of dust, cobwebs, etc.
• Place the gas bottle in the designated container, maximum dimensions of the gas bottle: diameter 40 cm and height 59 cm.

WARNING: some parts of the appliance can become hot. Keep children away from the barbecue.

Connecting the gas bottle

1. Main tap
2. Pressure regulator
3. Gas hose
4. Gas Bottle
5. Rubber washer

Attach the pressure regulator to the gas bottle using the large nut. Always ensure that the rubber sealing washer is present in the nut. Tighten the nut well. Note that the nut has a lefthand thread. Check the connections for leaks using a soap and water solution.
Every time a newly filled gas bottle is connected, a new rubber washer must be fitted. In most cases, your gas supplier will include it with the bottle.

Igniting the gas barbecue

Turn the knob fully to the right. Press the knob and turn left to the maximum position. Keep the knob pressed and press the ignition button a few times. Keep the knob pressed in for approximately 10 more seconds. The burner will continue to burn.
Let the barbecue burn for approximately 15 minutes before putting meat on the grid, as the burners must first heat the chamber before it can pass its heat to the upper grid.

Extinguishing the gas barbecue:

Turn the knob fully to the right. Note! After turning off the burners, wait approximately 10 minutes before reigniting the burners.
When disconnecting the gas bottle or after turning off the burners, always turn off the regulator on the gas bottle!
Note! After turning off the burners, wait approximately 10 minutes before reigniting the burners. After turning off the burners, always turn off the main tap on the gas bottle and the tap on the appliance!

If your barbecue has a griddle

Before you start using the griddle for the first time, please follow the following procedure:

• Remove the grids and place the griddle above the burners.
• Pour a layer of oil in the pan and heat the pan until the inside smokes and darkens.
• Sprinkle the pan generously with salt (unwanted substances like water and dirt will be absorbed by the salt).
• Clean the pan using kitchen paper. The pan is now ready to be used.

Note! Keep the griddle slightly greased at all times to prevent oxidation.
If you barbecue is equipped with a heat shield
The heat shield must be cleaned and degreased thoroughly after each use in order to prevent the risk of fire!

Cleaning & maintenance

• Clean and degrease the barbecue after each use (to prevent the risk of fire!)
• Thoroughly clean the upper grid after each use
• Clean the stainless steel burner container after each use

If the barbecue will not be used for an extensive period of time, it is recommended to lightly oil the non-stainless steel, non-lacquered parts using an acid free oil. The gas hose must be replaced every 2 years, as it becomes porous over time. Gas bottles, even when empty, must be stored in an upright position.
It is recommended to sign a maintenance contract with your supplier to ensure you can make optimal use of your barbecue. Please contact your supplier for more information about the conditions.

Troubleshooting

If the appliance does not function properly, please check the below table for the solution. If you are still unable to solve the problem, please contact the supplier/service provider.

Note

• It is recommended to replace the gas hose and pressure regulator after 2 years (check the production date), as they become porous over time. Also check the hose assembly (incl. quick coupling and pressure regulator) for leaks at least once a year and each time after using the appliance. U must always check the condition of the hose assembly (including quick coupling and pressure regulator).
• Check the hose/quick coupling and the pressure regulator for cracks/damage before each use. In case of damage/cracks, replace the affected parts immediately.
• Always observe the local safety regulations (such as the local fire regulations). These may differ depending on your location.
• Use only original parts when replacing or changing parts.
• Always store gas bottles in an upright position, in use as well as when empty.

Warranty

Any defect affecting the functionality of the appliance which becomes apparent within one year after purchase will be repaired by free repair or replacement provided the appliance has been used and maintained in accordance with the instructions and has not been abused or misused in any way. Your statutory rights are not affected. If the appliance is claimed under warranty, state where and when it was purchased and include proof of purchase (e.g. receipt). In line with our policy of continuous product development we reserve the right to change the product, packaging and documentation specifications without notice.

Discarding & Environment

When decommissioning the appliance, the product must not be disposed of with other household waste. Instead, it is your responsibility to dispose to your waste equipment by handing it over to a designated collection point. Failure to follow this rule may be penalized in accordance with applicable regulations on waste disposal. The separate collection and recycling of your waste equipment at the time of disposal will help conserve natural resources and ensure that it is recycled in a manner that protects human health and the environment. For more information about where you can drop off your waste for recycling, please contact your local waste collection company. The manufacturers and importers do not take responsibility for recycling, treatment and ecological disposal, either directly or through a public system.

HENDI B.V.
Innovatielaan 6
6745 XW De Klomp, The Netherlands
Tel: +31 317 681 040
Email: info@hendi.eu

HENDI Polska Sp. z o.o.
ul. Firmowa 12
62-023 Robakowo, Poland
Tel: +48 61 658 7000
Email: info@hendi.pl

HENDI GmbH
Ehring 15
5112 Lamprechtshausen, Austria
Tel: +43 6274 200 10 0
Email: office.austria@hendi.eu

HENDI Romania S.R.L.
Str. 13 decembrie 94A, Hala 14
Brașov, 500164, Romania
Tel: +40 268 320330
Email: office@hendi.ro

PKS HENDI South East Europe SA
5 Metsovou Str.
18346 Moschato, Athens, Greece
Tel: +30 210 4839700
Email: info@pks-hendi.com

HENDI Italia S.R.L.
Via Leonardo da Vinci 4
39100 Bolzano (BZ), Italy
Tel: +39 800 727 438
Email: office.italy@hendi.eu

HENDI HK Ltd.
1208, 12/F Exchange Tower
33 Wang Chiu Road, Kowloon Bay, Hong Kong
Tel: +852 2154 2618
Email: info-hk@hendi.eu

Find HENDI on internet:
www.hendi.com
www.facebook.com/HENDIToolsforChefs
https://www.linkedin.com/company/hendi-tools-for-chefs/
www.youtube.com/HENDIEquipment

Changes, printing and typesetting errors reserved.
© 2023 HENDI B.V. De Klomp – The Netherlands Ver: 24-02-2023

References

• hendi.com
• hendi.com

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>