VonHaus 2500546 6 – Burner Free Standing Natural Gas Instruction Manual
- June 4, 2024
- vonhaus
Table of Contents
VonHaus 2500546 6 – Burner Free Standing Natural Gas
INTENDED USE WARNING
The product is for outdoor use only. DO NOT use indoors. This product should NOT be used in motor homes, tents, sheds or any similar locations where ventilation is limited. Use only in an uncovered, well ventilated area. Position on a suitable heat-resistant surface such as a concrete patio slab. This product is not intended as a climbing structure and it is not a toy. Children should be supervised to ensure that they do not play with the product. Keep children and pets away from the product at all times when cooling.Flammable materials and heat-sensitive items should be kept away from the product during use and when cooling. Keep loose fitting clothing away and long hair tied back. Do not overload the product.
IMPORTANT SAFETY INFORMATION
-
IMPORTANT : The product should only be lit by safe means such as firelighters complying with EN1860-3.
Pay close attention to all warnings and instructions provided with any lighting equipment/fuels. Always keep a fire extinguisher, garden hose, or bucket of sand nearby to smother the fire if necessary. -
WARNING! DANGER OF CARBON MONOXIDE POISIONING.
-
Do not light this product or let it smoulder or cool down in confined spaces. Do not use under awnings, parasols or gazebos. Never handle charcoal after lighting. Always use the Poker provided.Always use the Mesh Guard when a fire is lit.
-
WARNING! The BBQ will become extremely hot during use and cannot be moved.
-
To avoid injury, be aware that the resting surface directly underneath the BBQ will become very hot during operation and will remain hot for some time afterwards.
-
Keep feet, other limbs and all property/items well away from this area.
-
To avoid burns, do not touch metal parts of the product until it has completely cooled.
-
Handles will become very hot and unsafe to touch during use, unless you are wearing rated protective gear (pot holders, thermal proof mittens, hot pad etc). Standard household oven gloves will NOT offer sufficient protection and should not be used.
-
Hot embers may be emitted during use.
-
Never leave a burning fire unattended.Extinguish immediately after use.
-
Do not splash water over a fire to extinguish as the resulting smoke can cause eye/respiratory irritation.
-
Carefully douse using a suitable extinguishing medium, keeping sufficient distance for safety.
-
The product may appear cool but may still be retaining dangerous heat.
-
Exercise extreme caution when handling. Ensure the coals have completely burnt before removing the ash.
-
Do not dump ashes where they could start a fire. Always dispose of ashes in a proper receptacle.
-
The product should only be moved and stored when it has completely cooled and all flammable materials have been extinguished and disposed of safely.
-
Store away ONLY when the product is completely extinguished and cool. This may take some time after use.
BEFORE FIRST USE
Follow each step of the assembly as outlined by the steps in this Instruction
Manual.
Assemble close to the products intended position.
Locate the product in a suitable area where it will not create an obstruction.
Locate away from sources of combustion.
GENERAL SAFETY
The assembly pack contains small parts which can pose a choking hazard to
children and pets. Place on solid and even ground.
Only use in an upright stable position.
Do not overload the product as this may result in damage to the product or
personal injury.
CLEANING & MAINTENANCE
Do not clean the product with any abrasive cloths or chemicals. Solvents or detergents can cause damage to the surface.Components Periodically check and re-tighten fittings where necessary. Re-tighten all fittings after first week following assembly. To clean, sponge down with warm water, a soft cloth and mild detergent. Ensure you have all the pieces listed. If you are missing any components, contact our customer services department at support@domu.co.uk DO NOT proceed with assembly if any components are missing.
TECHNICAL SPECIFICATION
-
TYPES OF GAS Butane Gas
-
GAS PRESSURE 28-30mbar
-
CONSUMPTION 1450g/h
-
INJECTOR SIZE MAIN BURNER 0.83mm
-
INJECTOR SIZE SIDE BURNER 0.88mm
-
TYPES OF GAS Propane
-
GAS PRESSURE 37mbar
-
CONSUMPTION 1450g/h
-
INJECTOR SIZE MAIN BURNER 0.83mm
-
INJECTOR SIZE SIDE BURNER 0.88mm
Hardware
Installation
Step-1
Step-2
Step-3
Step-4
Step-5
Step-6
Step-7
Step-8
Step-9
Step-10
Step-11
Step-12
Step-13
Step-14
Step-15
Step-16
Step-17
Step-18
Step-19
Step-20
Step-21
Step-22
Step-23
Step-24
CONNECTING THE GAS CYLINDER TO THE APPLIANCE
The appliance may only be used with butane, propane or a low pressure LPG
mixture and with a suitable low pressure regulator and a flexible hose. The
hose must be securely connected to the regulator and the appliance with hose
clips. The barbe-cue operates with a 28-30 mbar regulator for butane, 37 mbar
for propane and 30 mbar for an LPG gas mixture. Use a suitable regulator
certified to BSEN 16129: 2013. Contact your LPG supplier for further
information on
suitable regulators for gas cylinders.
REGULATOR & HOSE
These items are not supplied with the barbecue but are available separately
from your retailer or approved LPG gas distributor. Use only regulators and
hoses intended for use with LPG at the pressures indicated above. The service
life of a regulator is estimated at 10 years. It is recommended that you
change the regulator 10 years after its date of manufacture. The hose should
be changed when national regulations require. It is recommended that you
change the hose 5 years after its date of manufacture.
Using an unsuitable regulator or hose is dangerous. Ensure that the products
that you have are suitable for use with your barbecue.
The hose used must comply with the standards in force in the country of use.
The hose must be a minimum of 0.6 metres long and a maximum of 1.5 metres. A
damaged regulator or hose must be replaced. Ensure that the hose is not
blocked, kinked or in contact with any part of the barbecue other than the
connection point.
STORAGE AFTER USE
Store the appliance indoors only if the cylinder has been disconnected and
removed. If the appliance is not used for a long period, it should be stored
in its original packaging, in a dry, dust-free location.
GAS CYLINDER
The barbecue may be used with 11 or 15 kg cylinders. The maximum size is 310
mm (diameter) x 600 mm (height). The barbecue will run better if propane or
LPG mixtures are used. Butane can be used but, due to the appliance’s power,
the cylinder will have a tendency to freeze and supply gas at a lower
pressure, thus affecting the barbecue’s performance. The gas cylinder must be
outside the barbecue.
The gas cylinder should be handled with care! Always dis-connect the gas
cylinder when not using the barbecue. Re-place the protective cap on the
cylinder when not connected to the appliance.
Keep any source of ignition well away when changing the gas cylinder.
Cylinders should always be stored outdoors, vertically and out of the reach of
children. Cylinders should never be stored in temperatures in excess of 50°°C.
Never store gas cylinders close to flames, burners or other heat sources.
NEVER SMOKE NEAR A GAS CYLINDER
This barbecue is designed for outdoor use, well away from any flammable
material. Ensure that any item located above the appliance cannot obstruct it
and that both sides and the front of the appliance are at least 1 metre from
any item that could impede its operation. Ensure that the appliance’s
ventilation holes are not obstructed. the barbe-cue should be place on a flat,
stable surface. The appliance should be protected from direct draughts and bad
weather (rain, etc.). Parts sealed by the manufacturer or its agent should not
be disassembled by the user. Do not modify any part of the barbecue. Repairs
and mainte-nance should only be carried out by an accredited technician.
CONNECTING THE GAS CYLINDER TO THE GRILL
Before connection, ensure that nothing is obstructing the top of the cylinder,
the regulator, burner or burner ports. Spiders and insects can get into and
obstruct the burner’s supply tube orifice. An obstructed burner could cause a
fire under the appliance.
Clean the burner orifices using a stout pipe cleaner.
Secure the hose to the appliance using a spanner to tighten it on to the
connection cable. When replacing the hose, it should be fixed to the appliance
and to the regulator using hose clips. Disconnect the regulator from the
cylinder (follow-ing the instructions supplied with the regulator) when the
barbecue is not in use.
The barbecue should be used in a well ventilated area. Do not obstruct the
flow if combustion air to the burner when using the barbecue.
LEAK TEST
Mix one part washing up liquid to three parts water to make 60 to 90 ml of
leak finding solution.
Ensure that the control valve is closed.
Connect the regulator to the cylinder and the open/close valve to the burner.
Ensure that connections are correctly made and then open the gas inlet valve.
Spread the solution over the hose and all joins with a brush. If any bubbles
appear, then there is a leak, which must be repaired before the barbecue is
used.
Test again, once the leak is repaired.
Close the gas inlet valve on the cylinder, when the test is complete.
If a leak is detected which cannot be repaired, do not at-tempt any other
action but contact your distributor.
LIGHTING INSTRUCTION
-
Open the lid.
-
Turn the control knobs clockwise to the off position.
-
Connect the regulator to the gas cylinder. Open the gas inlet valve on the cylinder. Using a soap solution, look for any gas leak between the cylinder and the regulator.
-
Push down the second control knob and turn it anti-clock-wise to the position, this will
-
Turn other burners on by turning the control knob to “HI” position. They will be light through flame channel. Always start from left side to right side burner.
-
Adjust the power of the flame by turning the knob to the High/Low position.
-
If the burner does not light, light it with a match in the orifice at the side of the appliance.
Contact your gas distributor to have the ignition system repaired. -
To switch the barbecue off, close the valve on the cylinder or the switch on the regulator if you have finished using the barbecue, then turn the appli-ance’s control knobs clockwise to “OFF” position.
NOTICE FOR FIRST TIME USING
Close the hood and left the gas burn at Min setting for 15 minutes.
The smells from the treated surface are eliminated by the high temperature.
CLEANING & MAINTENANCE
- General Warning
- Before cleaning, wait until the gas barbecue has cool down sufficiently.
- Before cleaning, remove the gas cylinder.
- Do not use any flammable detergents.
- Do not use wire brush or other abrasive utensils for cleaning. Do not use any oven cleaners. Oven cleaner attacks painted surface.
- Clean the barbecue after each use.
- Exterior surface
- Use mild detergents, caustic soda and hot water.
- Mild abrasive agents can be used for stubborn stains. Following this, rinse thoroughly with water.
- Interior surface
- Does the inner surface of the grill lid looks as paint may flake? There is burnt-on grease which is flaking.
- Clean the surface thoroughly with highly concentrated , hot soap suds.
- Rinse thoroughly with water and allow the lid to dry.
- Interior surface of the barbecue bottom
- Remove residue with a brush or a scraper.
- Using soap suds and a sponge, finish by washing the surface.
- Rinse thoroughly with water and allow the surface to dry.
DISPOSAL INFORMATION
Please recycle where facilities exist. Check with your local authority for
recycling advice.
CUSTOMER SERVICE
If you are having difficulty using this product and require support, please
contact support@domu.co.uk
WARRANTY
To register your product and find out if you qualify for a free extended warranty please go to www.vonhaus.co.uk/warranty Please retain a proof of purchase receipt or statement as proof of the purchase date. The warranty only applies if the product is used solely in the manner indicated in the warnings page of this manual, and all other instructions have been followed accurately. Any abuse of the product or the manner in which it is used will invalidate the warranty. Returned goods will not be accepted unless re-packaged in its original packaging and accompanied by a relevant and completed returns form. This does not affect your statutory rights. No rights are given under this warranty to a person acquiring the appliance second-hand or for commercial or communal use.
COPYRIGHT All material in this instruction manual are copyrighted by DOMU Brands. Any unauthorized use may violate worldwide copyright, trademark, and other laws.
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>