Champion Power Equipment 100900 2000W Dual Fuel Inverter Generator User Guide

Champion Power Equipment 100900 2000W Dual Fuel Inverter Generator

Product Information

Specifications

• Model: 100900 – 2000W Dual Fuel Inverter Generator
• Power Output: 2000W
• Fuel Type: Dual Fuel (Gasoline and Propane)

Product Usage Instructions

Engine will not start

Possible causes:

• No fuel
• Faulty spark plug
• Low oil level
• Spark plug wire loose
• Fuel valve is closed
• Old fuel or water in fuel
• Flooded with fuel
• Choke in the wrong position

Engine starts but runs roughly

Possible causes:

• Dirty air filter
• Dirty fuel valve
• Clogged spark arrestor
• Out of fuel

Engine shuts down during operation

Possible causes:

• Low oil level
• Clogged spark arrestor

Generator cannot supply enough power or overheating

Possible causes:

• Generator is overloaded
• Dirty air filter
• Choke in wrong position

Engine is running but no AC output

Possible causes:

• Poor cord connection
• Circuit breaker is open
• Loose wiring

AC Overload: Button illuminated red

Possible causes:

• Engine hunts or falters
• Other issues
• Engine governor defective
• Dirty fuel valve
• Carburetor is dirty and running lean
• Choke in wrong position

Dual Fuel Models Only: Engine will not stop

Possible causes:

• Propane valve is still open
• Overload

Repeated circuit breaker tripping

Possible causes:

• Faulty power cords or device
• Circuit breaker still too hot

TROUBLESHOOTING

Problem

• No fuel. – Add fuel.
• Faulty spark plug. – Clean and adjust spark plug or replace.
• Low oil level. – Fill crankcase to the proper level.
• Spark plug wire loose. – Attach wire to spark plug.
• Fuel valve is closed. – Open fuel valve.
• Old fuel or water in fuel. – Drain fuel and replace with fresh fuel.
• Flooded with fuel. – Let unit stand for 10 mins.
• Choke in the wrong position. – Move choke until it stops under RUN position or push in completely.

Engine starts but runs roughly.|

• Dirty air filter. – Clean or replace air filter.
• Dirty fuel valve. – Clean the fuel valve.
• Clogged spark arrestor. – Clean spark arrestor.
• Out of fuel. – Fill fuel tank.

Engine shuts down during operation.|

• Low oil level. – Fill crankcase to the proper level. Place generator on a flat, level surface.
• Clogged spark arrestor. – Clean spark arrestor.

Generator cannot supply enough power or overheating.|

• Generator is overloaded. – Review load and adjust. See “Connecting Electrical Loads.”
• Dirty air filter. – Clean or replace air filter.
• Choke in wrong position. – Move choke until it stops under RUN position or push in completely.

Engine is running but no AC output.|

• Poor cord connection. – Check all connections.
• Circuit breaker is open. – Reset circuit breaker.
• Loose wiring. – Inspect and tighten wiring connections.
• AC Overload: Button illuminated red – Reduce AC load and press Overload Reset Button until illuminated green.

Engine hunts or falters.|

• Other. – Contact the help line.
• Engine governor defective. – Contact the help line.
• Dirty fuel valve. – Clean the fuel valve.
• Carburetor is dirty and running lean. – Contact the help line.
• Choke in wrong position. – Move choke until it stops under RUN position or push in completely.

DUAL FUEL MODELS ONLY: Engine will not stop.|

• Propane valve is still open. – Turn the propane valve to the CLOSED position on the tank.

Repeated circuit breaker tripping.|

• Overload. – Review load and adjust. See “Connecting Electrical Loads.”
• Faulty power cords or device. – Check for damaged, bare or frayed wires. Replace defective device.
• Circuit breaker still too hot. – Let unit sit for 5 mins.

For other issues and technical support:

Technical Support Team
Toll Free 1-877-338-0999
support@championpowerequipment.com

Specifications

FAQ (Frequently Asked Questions)

Where can I get technical support for my generator?

What should I do if the AC overload button is illuminated red?

Check if the engine is hunting or faltering. If not, there may be other issues like a defective engine governor, dirty fuel valve, dirty carburetor, or choke in the wrong position.

Why does the engine shut down during operation?

The engine may shut down due to a low oil level or a clogged spark arrestor.

What should I do if my generator won't start?

Check for common issues such as no fuel, a faulty spark plug, or a low oil level, and follow the corresponding solutions provided in the troubleshooting guide.

How can I prevent my generator from shutting down during operation?

Ensure the oil level is proper and the spark arrestor is clean. Place the generator on a flat, level surface.

Who do I contact for technical support if the troubleshooting guide does not resolve my issue?

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>