CHAMPION POWER EQUIPMENT 200961 2500 Watt Dual Fuel Portable Inverter Generator User Manual
- June 14, 2024
- CHAMPION POWER EQUIPMENT
Table of Contents
CHAMPION POWER EQUIPMENT 200961 2500 Watt Dual Fuel Portable Inverter
Generator User Manual
INVERTER GENERATOR PARTS DIAGRAM
INVERTER GENERATOR PARTS LIST
| # | Part Number | Description | Qty. |
|---|---|---|---|
| 1 | 100010946-0001 | Screw M4 x 10 | 5 |
| 2 | 100095857-0005 | Bolt M4 x 18 | 1 |
| 3 | 100715787 | Fuel Valve Lever | 1 |
| 4 | 100711112-0003 | Panel Assembly | 1 |
| 5 | 100731574 | Receptacle Cover GFCI 5-20R, Duplex | 1 |
| 6 | 100010886-0004 | Spring Washer Ø6 | 1 |
| 7 | 100092320 | Ground Stud | 1 |
| 8 | 100735685-0002 | Parallel Port Cover, Square, Black | 1 |
| 9 | 100735685-0001 | Parallel Port Cover, Square, Red | 1 |
| 10 | 100746006-0002 | Parallel Port, Square, Black | 1 |
| 11 | 100746006-0001 | Parallel Port, Square, Red | 1 |
| 12 | 100120180 | Cover, Circuit Breaker | 2 |
| 13 | 100019747 | 20Amp Circuit Breaker, Push Button | 1 |
| 14 | 100715673 | Wire Harness Assembly | 1 |
| 15 | 100020029 | Receptacle 5-20R, Duplex | 1 |
| 16 | 100011421-0003 | Flange Nut M6 | 1 |
| 17 | 100715356 | LED Display Module | 1 |
| 18 | 100010910-0003 | Flat Washer Ø6 | 1 |
| 19 | 100011025-0001 | Lock Washer Ø6, Toothed | 1 |
| 20 | 100019782 | Receptacle, 12 VDC | 1 |
| 21 | 100714541 | Cable | 1 |
| 22 | 100712960 | Switch Block | 1 |
| 23 | 100091757 | Circlip, Bearing Holder, Ø1.8 x Ø6 | 2 |
| 24 | 100081995 | Step Bolt | 16 |
| 25 | 100142063-0001 | Front Panel, Black | 1 |
| 26 | 100141146 | Fuel Valve, Angle 45° | 1 |
| 27 | 100011571-0001 | Big Flange Bolt M6 x 14 | 2 |
| 28 | 100005149 | Clamp 1, Ø7.5 | 2 |
| 29 | 100011570-0001 | Big Flange Bolt M6 x 12 | 13 |
| 30 | 100711113 | Inverter, 120V 60Hz | 1 |
| # | Part Number | Description | Qty. |
| --- | --- | --- | --- |
| 31 | 100000671 | Clip Ø13 | 1 |
| 32 | 100011249-0003 | Bolt M5 x 12 | 1 |
| 33 | 1ZC7DFB19 | Engine 79cc | 1 |
| 34 | 100033099-0006 | Big Flange Bolt M6 x 18 | 2 |
| 35 | 100131884 | Tube Sheath, Silicon Resin | 1 |
| 36 | 100131883 | Fuel Tube, L=275mm | 1 |
| 37 | 100090871 | Clamp 2, Ø9.7 x 8 | 1 |
| 38 | 100009020 | Fuel Strainer | 1 |
| 39 | 100072874 | Rear Air Guide | 1 |
| 40 | 100011004-0001 | Self-tapping Screw ST4.2 x 25 | 4 |
| 41 | 100092440-0007 | Housing Assembly, Left Handle, Black | 1 |
| 42 | 100139137 | Housing, Left Handle, Black | 1 |
| 43 | 100050562 | Threaded Clamp | 12 |
| 44 | 100033079-0003 | Screw M5 x 16 | 4 |
| 45 | 100713139-0005 | Side Cover Plate, Left, Yellow | 1 |
| 46 | 100081994 | Shaft Locating Bolt | 6 |
| 47 | 100713141 | Deco Trim, Recoil | 1 |
| 48 | 100072727 | Rubber Pad | 2 |
| 49 | 100087371 | Fuel Tank, 4 L | 1 |
| 50 | 100073150 | Rubber Washer | 1 |
| 51 | 100008887 | Lock Nut | 1 |
| 52 | 100072726-0001 | Fuel Tank Cap | 1 |
| 53 | 100142062-0001 | Rear Panel, Muffler, Black | 1 |
| 54 | 100072722 | O-ring Seal | 1 |
| 55 | 100087972 | Retainer Ring | 4 |
| 56 | 100011000-0001 | Self-tapping Screw ST4.2 x 9.5 | 1 |
| 57 | 100085794 | Spark Arrester Assembly | 1 |
| 58 | 100072875 | Front Air Guide | 1 |
| 59 | 100072878 | Oil Seal | 1 |
| 60 | 100097811 | Ignition Coil | 1 |
| # | Part Number | Description | Qty. |
| --- | --- | --- | --- |
| 61 | 100093250-0005 | Self-tapping Screw ST4.8 x 20 | 2 |
| 62 | 100092441-0007 | Housing Assembly, Right Handle, Black | 1 |
| 63 | 100139138 | Housing, Right Handle, Black | 1 |
| 64 | 100092444-0005 | Spark Plug Maintenance Plate, Black | 1 |
| 65 | 100714542 | Block, Swing Arm | 1 |
| 66 | 100011001-0004 | Self-tapping Screw ST4.2 x 10 | 1 |
| 67 | 100714558 | Wire Stop Block | 1 |
| 68 | 100096063-0001 | Flange Nut M2.5 | 2 |
| 69 | 100010919-0002 | Flat Washer Ø5 | 1 |
| 70 | 100010885-0003 | Spring Washer Ø5 | 1 |
| 71 | 100719040-0001 | Screw M2.5 x 18 | 2 |
| 72 | 100072715 | Vibration Mount, Support | 4 |
| 73 | 100088546 | Housing Assembly, Bottom, Black | 1 |
| 74 | 100072711 | Housing, Bottom, Black | 1 |
| 75 | 100072994 | Step Nut M6 | 6 |
| 76 | 100072710 | Rubber Damper | 1 |
| 77 | 100011452-0003 | Nut M6 | 4 |
| 78 | 100072712 | Foot, Bottom Housing | 4 |
| 79 | 100011419-0001 | Nut M5 | 1 |
| 80 | 100713140-0005 | Housing Assembly, Right, Yellow | 1 |
| 81 | 100159468-0001 | Clamp, Fuel Hose | 2 |
| 82 | 100711152-0001 | LPG Hose with Regulator | 1 |
| 83 | 100158478 | Protector Cover, Quick Connector | 1 |
| 84 | 100157219 | Self-locking Quick Connector, Female | 1 |
| 85 | 100157218 | Mounting Seat, Self-locking Quick Connector | 1 |
| 86 | 100011065-0002 | Nut M4 | 4 |
| 87 | 100157217 | Sliding Block, Mounting Seat | 1 |
| 88 | 100157221 | Spring, Mounting Seat | 1 |
| 89 | 100157215 | Mounting Plate | 1 |
| 90 | 100160807 | Nut M10 | 1 |
| 91 | 100160808 | Gas Hose | 1 |
| 92 | 100715460 | Fuel Solenoid Valve Controller | 1 |
| # | Part Number | Description | Qty. |
| --- | --- | --- | --- |
| 93 | 100715007 | Mounting Cover, Gas Pressure Valve | 1 |
| 94 | 100032967-0004 | Self-tapping Screw ST4.2 x 16 | 1 |
| 95 | 100714544 | Mounting Plate, Recoil Cord | 1 |
| 96 | 100098271 | Switch Spring | 1 |
| 97 | 100099173 | Steel Ball | 1 |
| 98 | 100715786-0001 | Cover, Fuel Switch Handle | 1 |
| 99 | 100714543 | Swing Arm | 1 |
| 100 | 100057719 | 8Amp Circuit Breaker, Push Button | 1 |
| 101 | 100716268 | Rectifier Bridge, Capacitance | 1 |
| 102 | 100011264-0003 | Flange Bolt M6 x 16 | 1 |
| 103 | 100011570-0007 | Big Flange Bolt M6 x 12, GB16674 | 4 |
| 104 | 100163606 | Screw | 4 |
| 105 | 100031552 | O- Ring | 1 |
ENGINE PARTS DIAGRAM
ENGINE PARTS LIST
| # | Part Number | Description | Qty. |
|---|---|---|---|
| 1 | 100033099-0006 | Big Flange Bolt M6 x 18 | 4 |
| 2 | 100097810 | Spark Plug(E6RTC) | 1 |
| 3 | 100154528 | Breather Tube | 1 |
| 4 | 100072876 | Cylinder Head Cover Assembly | 1 |
| 5 | 100085696 | Strainer, Cylinder Head Cover | 1 |
| 6 | 100085695 | Inner Cover, Cylinder Head Cover | 1 |
| 7 | 100005133 | Cross Screw M3 x 6.5 | 3 |
| 8 | 100075052 | Gasket, Cylinder Head Cover | 1 |
| 9 | 100075054 | Rocker Arm Assembly | 2 |
| 10 | 100075053 | Shaft, Rocker Arm | 1 |
| 11 | 100075055 | Valve Collet | 2 |
| 12 | 100075058 | Oil Drip Pan | 1 |
| 13 | 100075056 | Valve Spring Seat, 182F | 2 |
| 14 | 100159357 | Spring Valve | 2 |
| 15 | 100011275-0002 | Flange Bolt M6 x 50, GB5789 | 4 |
| 16 | 100160845 | Cylinder Head | 1 |
| 17 | 100088412 | Stud Bolt M6 x 73 | 2 |
| 18 | 100075043 | Muffler Pad | 1 |
| 19 | 100065662 | Exhaust Muffler Assembly | 1 |
| 20 | 100011277-0001 | Flange Bolt M6 x 60, GB5789 | 4 |
| 21 | 100011452-0003 | Lock Nut M6, Flange | 4 |
| 22 | 100010348 | Stud Bolt M6 x 87 | 2 |
| 23 | 100075048 | Gasket, Insulator | 1 |
| 24 | 100075049 | Insulator, Carburetor | 1 |
| 25 | 100075050 | Gasket, Carburetor | 1 |
| 26 | 100160764 | Carburetor | 1 |
| 27 | 100061512 | Stepper Motor | 1 |
| 28 | 100723700 | Cylinder Head Assembly | 1 |
| 29 | 100005149 | Clamp 1, Ø7.5 | 1 |
| 30 | 100087351 | Fuel Tube | 1 |
| # | Part Number | Description | Qty. |
| --- | --- | --- | --- |
| 31 | 1E+08 | Air Filter Hose | 1 |
| 32 | 1E+08 | Gasket, Cylinder Head | 1 |
| 33 | 1E+08 | Dowel Pin Ø8 x 12 | 4 |
| 34 | 1E+08 | Push Rod | 2 |
| 35 | 1E+08 | Valve Exhaust | 1 |
| 36 | 1E+08 | Valve Intake | 1 |
| 37 | 1E+08 | Lifter, Valve | 2 |
| 38 | 1E+08 | Piston Ring Set | 1 |
| 39 | 1E+08 | 1st Piston Ring | 1 |
| 40 | 1E+08 | 2nd Piston Ring | 1 |
| 41 | 1E+08 | Oil Ring | 1 |
| 42 | 1E+08 | Circlip | 2 |
| 43 | 1E+08 | Wrist Pin | 1 |
| 44 | 1E+08 | Piston | 1 |
| 45 | 1E+08 | Connecting Rod | 1 |
| 46 | 1E+08 | Bolt, Connecting Rod | 2 |
| 47 | 1E+08 | Crankcase | 1 |
| 48 | 1E+08 | Oil Level Sensor | 1 |
| 49 | 100031967-0007 | Big Flange Bolt M6 x 16 | 2 |
| 50 | 100011570-0001 | Big Flange Bolt M6 x 12 | 5 |
| 51 | 1E+08 | Crankshaft | 1 |
| 52 | 1E+08 | Camshaft | 1 |
| 53 | 1E+08 | Gasket, Crankcase Cover | 1 |
| 54 | 1E+08 | Cover, Crankcase | 1 |
| 55 | 100031968-0002 | Big Flange Bolt M6 x 20 | 7 |
| 56 | 100084322-0003 | Oil Dipstick Assembly, Black | 1 |
| 57 | 1E+08 | Trigger | 1 |
| 58 | 1E+08 | Oil Seal Ø20 x Ø32 x 6 | 1 |
| 59 | 1E+08 | Alternator Assembly, Ø150 x 44.5 mm | 1 |
| # | Part Number | Description | Qty. |
| --- | --- | --- | --- |
| 60 | 100159545 | Stator Assembly, Fe, Ø120 x 21 mm | 1 |
| 61 | 100085871 | Rotor Assembly, Permanent Magneto, Ø150 x 44.5 mm | 1 |
| 62 | 100011223-0001 | Flange Bolt M6 x 32 | 2 |
| 63 | 100072871 | Cooling Fan | 1 |
| 64 | 100159015 | Pulley, Starter | 1 |
| 65 | 100033063-0001 | Flange Nut M12 x 1.25 | 1 |
| 66 | 100072873 | Fan Cover Assembly | 1 |
| 67 | 100085054 | Fan Cover, Black | 1 |
| 68 | 100075483 | Air Filter Element | 1 |
| 69 | 100075482 | Air Filter Cover | 1 |
| 70 | 100000655 | Wire Clip B | 1 |
| 71 | 100748946-0002 | Recoil Starter Assembly, Black | 1 |
| 72 | 100011571-0001 | Big Flange Bolt M6 x 14 | 3 |
| 73 | 100715797 | Fuel Bowl Mounting Bolt | 1 |
| 74 | 100131960 | Fuel Bowl O-Ring | 1 |
| **75** | 100005736 | Main Jet Standard (61) | 1 |
| 100005742 | Main Jet Altitude 1000-2000m (60) | / | |
| 100030032 | Main Jet Altitude 2000-3000m (58) | / | |
| 76 | 100715796 | Fuel Bowl Mounting Bolt Gasket | 1 |
| 77 | 100000656 | Wire Clip C | 1 |
WIRING DIAGRAM
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>