POLAR GG755 Counter Top Cooler Instruction Manual

Counter top Cooler
Instruction manual

Counter top cooler
Instruction manual
Model: GG755

Safety Instructions

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out installation and any repairs if required.

• Consult Local and National Standards to comply with the following:
  – Health and Safety at Work Legislation
  – BS EN Codes of Practice
  – Fire Precautions
  – IEE Wiring Regulations
  – Building Regulations

• DO NOT immerse the appliance in water, or use jet/pressure washers to clean the appliance.

• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.

• DO NOT store products on top of the appliance.

• Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance.

•  Always switch off and disconnect the power supply to the appliance when not in use.

• Not suitable for outdoor use.

• Keep all packaging away from children. Dispose of the packaging in accordance to the regulations of local authorities.

• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard.

• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.

• Children should be supervised to ensure that they do not play with the appliance.

• POLAR recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing.

• POLAR recommend that this product is connected to a circuit protected by an appropriate RCD (Residual Current Device).

Caution: Risk of fire/Flammable materials

• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation.

• Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food storage compartments of the appliance.

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

Pack Contents

The following is included:

• Counter top cooler
• Instruction Manual

POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Note: Not for use in vans or trailers, food trucks or similar vehicles.
Note: If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand.

1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top.
   NEVER LOCATE NEXT TO A HEAT SOURCE.

Note: Before using the appliance for the first time, clean the interior with soapy water then dry well.

Operation

• The appliance is designed for display purpose only and not for storage.
• Remove any water that may be present before and after use, using the drain hose beneath the base.

Control panel

| Refrigerant LED:
|During refrigerating, LED is on; When the set temperature is reached and constant, LED is off.
---|---
| Defrost LED:
During defrosting, LED is on; When defrosting finishes, LED is off.
| Up Button
| Down Button
| Manual defrost button/light button
SET| Set button

Turn On

1. Close the door of the appliance.
2. Connect the appliance to the mains power supply.
3. Press On/off switch located on the rear.

Adjusting the Temperature

1. Press SET button. The set temperature is displayed.
2. Press up button or down button to change the set temperature.
3. Press SET button to exit.

Internal light
Press the button on the controller to turn the internal light on/off.
Manual Defrost
To start/stop manual defrost, press and hold defrost button for 6 seconds.
Tips for use:

• Only store foodstuff in the appliance when it has reached the correct operating temperature.
• Avoid opening the door too often. Opening the door for long periods can cause a significant increase of the temperature in the appliance.
• Clean regularly surfaces that can come in contact with food and accessible drainage system.

Cleaning, Care & Maintenance

• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Always wipe dry after cleaning.

Condensation and ice will form with frequent and prolonged opening of the doors.
Operating outside of the recommend temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth.
Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components.
If the gasket or seal is damaged or deformed, energy consumption will increase. To restore efficiency, replace gasket.
Cleaning the Condenser
Periodic cleaning of the Condenser can extend the life of the appliance.
POLAR recommend that a POLAR agent or qualified technician clean the condenser.

Troubleshooting

A qualified technician must carry out repairs if required.

plugged in correctly and switched on
Plug or lead is damaged| Replace plug or lead
Fuse in the plug has blown| Replace the fuse
Mains power supply fault| Check mains power supply
The appliance is not cooling| Coolant Leak| Consult a qualified technician
Airflow to the condenser obstructed| Increase the gap between appliance and obstacles/heat source
Condenser is clogged| Consult a qualified technician
Appliance is overloaded| Reduce the amount of food stored in the appliance
The appliance is noisy| Appliance is not level| Adjust position to make it level
Appliance is too close to a wall or other object| Move to a more suitable location

Technical Specifications

Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice.

Model| Voltage| Power| Current| Capacity| Temp. range| Refrigerant| Dimensions H x W x D mm| Weight
---|---|---|---|---|---|---|---|---
GG755| 220-240V~ 50Hz| 105W| 0.7A| 40L| 2°C ~ 6°C| R600a| 357 x 676 x 575| 25kg

Note: For optimal product performance and efficiency, please ensure to mind the net usable capacity (load limit) when filling.
Impact of temperature settings on food waste:
In order to reduce food waste from decomposition or dehydration, this appliance should be operated in its designated operating range.
Optimum temperature for food storage: 4°C
To order spare parts please contact your Polar Stuckist: https://www.polar- refrigerator.com/stockist

Minimum period of spares parts to be available:
Door handles, door hinges, knobs, dials and buttons, door gaskets, peripheral trays, baskets and racks for storage, as appropriate to the appliance, will be made available to both end users and professional users for a minimum of eight years after the last unit of the model is placed on the market. A broader selection of parts will also be made available to Professional users for this period.
Model information can be found on the product database: https://eprel.ec.europa.eu/screen/product/refrigeratingappliancesdirectsalesfunction

Model information can be found on the product:
The Model Identifier can usually be found on the inside wall and on the reverse of the unit.
Note: Polar offers a 2 year minimum warranty, please contact the authorised representative for more details.

Electrical Wiring

POLAR appliances are supplied with a 3 pin BS1363 plug and lead.
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:

•  Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E

**** This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible.

Disposal

EU regulations require refrigeration product to be disposed of by specialist companies who remove or recycle all gasses, metal and plastic components.
Consult your local waste collection authority regarding disposal of your appliance. Local authorities are not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to dispose of the equipment locally.
Alternatively call the POLAR helpline for details of national disposal companies within the EU.
Compliance
**** The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to change specifications without notice.

DECLARATION OF CONFORMITY

Application of Territory Legislation
& Council Directives(s)| Low Voltage Directive (LVD) – 2014/35/EU
Electrical Equipment (Safety) Regulations 2016
(BS) EN 60335-1:2012 +A11:2014 +A13:2017
+A1:2019 +A14:2019 +A15:2021
(BS) EN 60335-2-89:2010 +A1:2016 +A2:2017
(BS) EN 62233:2008
Electro-Magnetic Compatibility (EMC) Directive
2014/30/EU – recast of 2004/108/EC
Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091)
(BS) EN IEC 61000-6-1:2019
(BS) EN 61000-6-3:2021
Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment Regulations 2012 (S.I. 2012/3032)| Electrical Safety
IEC 60335-1:2010 +A1:2013
+A2:2016
IEC 60335-2-89:2019
EN 62233:2008
Electromagnetic Compatibility
EN IEC 61000-6-1:2019
EN 61000-6-3:2021
Producer Name| Polar

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s).
Date …………………………………..
Signature …………………………………..
Signature …………………………………..
Full Name …………………………………..
Position …………………………………..
Producer Address ………………………..
produttore …………………………………..

13th January 2023

Ashley Hooper| Eoghan Donnellan| Brendan Denmead
Technical & Quality Manager| Commercial Manager/ Importer| Commercial Manager/ Responsible Supplier
Fourth Way, Avonmouth, Bristol, BS11 8TB United Kingdom| Unit 9003, Blarney Business Park, Blarney, Co. Cork Ireland| 15 Bag dally Road, Campbelltown NSW 2560

UK +44 (0)845 146 2887

http://www.polar-refrigerator.com/
GG755_ML_A5_v1_2023/03/16
GG755_ML_A5_v1_20230316.indb 40
2023/3/16 16:41

References

• Polar Refrigeration - Commercial Refrigeration
• Polar Refrigeration - Commercial Refrigeration

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>