Mugen MTC2R 1/10 EP Touring Car Kit Instruction Manual

MTC2R 1/10 EP Touring Car Kit

Product Information

The Kit Bag-A2 is a high-performance radio control model car. It
comes with a transmitter, ESC (Electronic Speed Controller), and
motor. This model car is designed for high-speed racing and
requires careful handling to avoid accidents and personal injury.
The product is not suitable for operation in crowded places.

Product Usage Instructions

Before Operating:

1. Read the instruction manual thoroughly.

2. Read the instruction manuals provided with the transmitter,
   ESC, and motor.

3. Prepare other necessary equipment and convenient tools for
   assembly in advance.

4. Ensure the batteries of the transmitter and model are fully
   charged.

5. Turn on the transmitter and then the ESC to check if the
   steering servo and ESC work properly.

During Operations:

• Operate the model car only on designated areas, race tracks,
  and other spacious areas.

• Do not put fingers or any objects inside rotating and moving
  parts (Tire, Shaft, Gear).

• If the model car behaves strangely or makes unusual sounds,
  stop it immediately and check for any problems.

After Operating:

• Ensure all screws, nuts, and parts are securely tightened.
• Check if all moveable parts work smoothly.
• Stop the model car immediately if the electric wave is
  interrupted and it is not possible to control.

Troubleshooting:

If you encounter any problems with the model car, refer to the
troubleshooting section in the instruction manual. Some common
problems and their solutions are listed below:

circuited.
Motor failure. ESC failure. Assembly mistake in rotation part.| Charge it correctly. Insulate and repair the wiring. Repair or
exchange the motor. Repair or exchange the ESC. Reassemble it
according to the instruction manual.
Model is hard to control| Weak transmitter and/or receiver batteries. Low reception from
radio antennas. Servo linkage is not adjusted properly. Assembly
mistake in rotation part, wrong adjustment.| Recharge or replace batteries. Fully extend transmitter and
receiver antennas. Reassemble it according to the instruction
manual.

Important Safety Precautions:

• Read and adhere to all safety instructions provided in the
  manual.

• Do not operate the model car in a crowded place.

• Handle all tools with care to avoid injury.

• Painting must be done only in a well-ventilated area.

• Keep the product out of the reach of children.

If you have any questions or need further assistance, please
feel free to contact us.

Kit Bag-A2 2

3

4

FRONT

REAR

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

Before / After Operating
It is very dangerous if you make a mistake in the order of on/off switch on transmitter and model.
Loss of control will result due to the interference of frequency. Install the charged batteries on the model and connect the battery connectors. Extend transmitter antenna and turn the power on. Then, turn on the switch of the model (ESC). Raise the tires off the ground and check if the model is functioning properly. Make sure the motor is not rotated at the neutral posltion of throttle. Check if the steering operates the front tires correctly. Start operation after checking each part of the model moves properly in accordance with the operation of transmitter. Always turn off the model (ESC) first, and turn off the transmitter after running. Always disconntect/remove the batteries when the model is not in use.

Trouble Shooting

PROBLEM

CAUSE

SOLUTION

Model doesn’t move

Battery on model is not charged. The wiring is short-circuited. Motor failure. ESC failure. Assembly mistake in rotation part.

Chearge it correctly. Insulating and repair the wiring. Repair or exchange the motor. Repair or exchange the ESC. Reassemble it according to the instruction manual.

Model is hard to control Weak transmitter and/or receiver Recharge or replace batteries.

batteries.

Fully extend transmitter and receiver

Low reception from radio antennas. antennas.

Servo linkage is not adjusted properly. Reassemble it according to the

Assembly mistake in rotation part, instruction manual.

wrong adjustment.

Reassemble it according to the

instruction manual.

ON/OFF ON ON OFF OFF

Trouble Shooting

25

SAFETY PRECAUTIONSPlease read carefully before assembling and operating your model.
This product is high performance radio control model car. Follow the rules and enjoy your drive. To enjoy this model to its fullest, prepare other necessary equipments and convenient tools for assembly in advance. Improper usage of batteries for radio control model car may not only damage the electronics of the car and/or radio, but can cause excess heat and possibly fire, resulting in serious accidents. Be sure to operate the battery safely.
In order to avoid accidents and personal injury, adhere to following instructions:

Handling of radio control car
This model car can exceed very high speed, and cannot be stopped quickly. Opearate your model only on designated areas, race tracks, and other spacious areas. Also, be sure to operate the model car safely to avoid serious personal injury, property damage, and unforeseen accidents.
Before assembling
Before you begin, read the instruction manual thoroughly. Read the instruction manual supplied with transmitter, ESC, or motor, and understand how to
use beforehand. Keep out of the reach of children. All tools require careful handling to avoid injury. Painting must be done only in well-ventilated area. Feel free to contact us if you have any guestions.
Check before operations
Be sure to tight screws, nuts etc. securely and install all parts. Make sure whether the moveable part works smoothly. Fully charge the batteries of the transmitter and model. Turn on the transmitter and then ESC to check if the steering servo and ESC work properly.
With weak batteries, transmission and reception of the radio fall off. Models may become out of control under such condition, which may cause serious accidents. Stop the model car immediately when the electric wave is interrupted and it is not possible to control.

Cautions during operations
Always fun your car with the body shell mounted. Do not put fingers or any objects inside rotating and moving parts (Tire, Shaft, Gear). Stop the model car and check the problem immediately when it behaves strangely or it sounds
strangely. Do NOT operate in……… 1. Crowded place
2. Near Children 3. Near residential districts, schools,and hospitals 4. Near roads and railroads 5. Indoors and in limited space 6. Nighttime and early morning 7. Place where running of radio control model car is prohibited
Cautions after operations
Always switch off the speed controller and then transmitter. The car might be loss of control when it makes a mistake in order. Do not touch the moter, ESC, battery because it might be very hot after use. Always disconnect/remove the batteries when the model is not in use. Failure to do so may cause damage to the batteries from excessive discharge and leaking. Do care after running to maintain performance, to notice the damage and the wear, to avoid
further trouble. Do not store the model car in hot or humid conditions, or in direct sunlight.
Handling of battery
Be careful of handling of the battery. Properly connect plugs firmly. Never reverse connection nor disassemble batteries. When using rechargeable batteries, carefully read and follow the instructions supplied with the
battery and charger unit.

26

/ /

/
/

………
/

OFFOFF

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>