KEMPER 104987N Smart Stove Instruction Manual

INSTRUCTIONS FOR THE ASSEMBY,
THE USE AND THE MAINTENANCE
ART. 104987N
SMART

104987N Smart Stove

Technical information

104987N

Power| 1,90 kW
Consommation| 138 g/h
Categorie| Pression Directe
Gas| Butane
Usable Cartridges| KEMPER – PLEIN AIR 577
Decathlon 4050185

TRANSLATION FROM ORIGINAL INSTRUCTIONS
INSTRUCTIONS FOR ASSEMBLING, USE AND MAINTENANCE
Important: read carefully the following instructions in order to familiarize with the appliance before the connection to the gas bottle.
Keep these instructions for further consultation.
Attention: the use of this appliance produces carbon dioxide emission and its accumulation may be dangerous. This product must be used only in adequately ventilated places in order to allow air-stoking combustion and to avoid unburnt gas mixtures. To be used ONLY with KEMPER art. 577/Decathlon 4050185 butane cartridge. It can be dangerous to try to use any other type cartridges.
THE USE IS PROHIBITED IN DWELLINGS. This appliance is not intended to be used for commercial activity.

SAFETY INFORMATION

1. Use the appliance only in well-ventilated rooms at a safety distance from any heat source, flame or sparks and far from dirt (accumulation) and inflammable material.

2. Place the hot plate on the ground or on the floor always horizontally. Never put the hot plate on wood or plastic surfaces or on inflammable materials.

3. Never put inflammable objects at less than 1 m from the top or beside the hot plate.

4. Do not move the appliance during use.

5. Never modify your hot plate and absolutely never disassemble the appliance and its components.
   Modification on the appliance must be made only by qualified personnel.

6. Check that the appliance is not damaged. Never use a damaged appliance.

7. During use, always close the cartridge holder lid (F).

8. Don’t let domestic animals near the hot plate.

9. Never leave the hot plate going and unguarded.

10. ATTENTION: very high temperature parts are easily accessible. Keep the appliance away from children.

11. The pot shall not cover the cartridge cover when using the appliance.

12. Put the hot plate on a stable and horizontal surface. Do not alongside two or more burners.

13. Never use pots with a diameter bigger than 18 cm. Never heat an empty pan.

14. Do not use the appliance to cook food by putting a big pot between two appliances.

15. This appliance is equipped with a cartridge disconnection device in case of overpressure: if the gas pressure in the cartridge exceeds the security level, the device disconnects the cartridge and its connecting lever returns to position “UNLOCK”. In this case, remove the cartridge and let it cool (for example under water) before using it again or using a new cartridge by following instructions mentioned on “Replacing the cartridge” section.

16. In case the pressure sensitive safety device triggers it means that a critical pressure level is reached in the cartridge so the appliance must not be used before it has completely cool down. Do not bypass the pressure sensitive safety device.

17. DO NOT force restarting without cooling or replacing the cartridge.

INFORMATION ON THE USE OF CARTRIDGES

1. Use exclusively KEMPER butane cartridges art. 577/Decathlon 4050185. It may be dangerous to adapt other gas containers.
2. All operations of assembly and change of cartridges must be done in a well-ventilated place and far from flames and inflammable materials.
3. Never smoke while handling cartridges.
4. Read carefully the instructions on the wrapping of the cartridge before using.
5. Remove the cartridge after each use in order to avoid overheating the appliance.
6. Never expose cartridges at temperatures over 50°C.
7. Always keep the appliance away from children
8. Never try to refill a disposable cartridge.
9. Never breathe in the gas coming from the cartridge or the smoke produced while using the appliance.
10. When the appliance is not used, the cartridge must be disengaged by positioning the cartridge connection lever (D) on “UNLOCK”.

IN CASE OF LEAKAGE (SMELL OF GAS) BRING YOUR APPLIANCE IMMEDIATELY OUTDOORS, IN A VENTILATED PLACE WITH NO INFLAMABLE SOURCES, AND THEN YOU CAN LOOK FOR LEAK AND STOP IT. IF YOU WANT TO CHECK THE SEAL OF YOUR APPLIANCE, DO IT OUTDOORS AND NEVER LOOK FOR A LEAKAGE WITH A FLAME BUT USE SOAPSUDS.

LEAKAGE TEST
BEFORE USING CHECK THAT THERE ARE NO LEAKS.Check the leakage of your device only outside. Do not seek the leakage with a match but use water and soap or a gas detector (our article Revelgas cod. 1726).
Apply solution of soap and water or gas detector in the interspaces of the unit. If bubbles appear, it means that there is a leak and it must be repaired before use. If you detect a leak and you cannot repair it, don’t try to fix it another way, but contact the customer service. Do not use a device that leakage, deteriorated or malfunctioning.

STARTING THE APPLIANCE

1. Don’t use the hot plate other purposes than cooking.

2. Put the hot plate far from inflammables substances or things that can be damaged by heat.

3. Before inserting the cartridge, open the cartridge compartment and place the oscillating rod (M) in a vertical position.

4. Make sure that in the hot plate, the lever connecting the cartridge is in “UNLOCK” position and the gas valve knob is in “OFF” position.

5. Make sure that the seals are in a good state before connecting the gas cartridge.

6. Never use the appliance with damaged or worn seals.

7. Never use the appliance if it leaks, is deteriorated or malfunctioning.

8. Put the cartridge in its slot, placing the cut on its neck in correspondence to the safety stop.

9. Place the lever connecting the cartridge on the “LOCK” position.
   WARNING: the appliance is now ready for use. The positioning of the lever on “LOCK” presupposes the immediate ignition of the stove as the gas circuit is ready for gas supply. Do not leave the appliance unattended and without flame with the lever positioned on “LOCK”.
   WARNING: the openings at the base of the burner provide air for combustion, they should never be obstructed.
   WARNING: Closed the cartridge cover before lighting. Not closing the cover can cause the cartridge to overheat.

10. Turn anticlockwise all the way the cock until it is positioned on “IGNITION” where the piezo ignition will ignite the flame.

11. If the stove dose not light, turn the control knob back to “OFF” position and repeat.

12. If after three failed attempts, the stove dose not light, turn the control knob to the “OFF position and move the cartridge lever to the “UNLOCK” position.

13. Open the cartridge cover and remove the cartridge, Shake the cartridge to see if it is empty. If empty, replace the cartridge and repeat from point 9.

14. Regulate the flame according to your needs.

15. Warning: the device is not equipped with a safety system for the automatic closing gas (thermocouple).

SHUTTING DOWN THE APPLIANCE

1. To turn off the appliance, rotate clockwise the cock to the “OFF” position and wait until the flame is fully extinguished before performing the next step.
2. Position the cartridge-connecting lever on the “UNLOCK” position and remove the gas cartridge from the compartment.
3. Wait for the plate to cool before storing it.
4. When the appliance is not in use, it is mandatory to remove cartridge out of the appliance.
5. This unit can be kept inside only if the cartridge has been disconnected and removed from the appliance. If you expect that the barbeque remains unused for a certain period of time, store it in its original packaging and in an environment free from dust.

CHANGING THE CARTRIDGE

1. Check that burners are extinguished before disconnecting the gas cartridge. Be careful the gas cartridge could be hot.
2. Ensure that the cartridge is empty before replacing it (shake it in order to hear the sound produced by the liquid).
3. Replace the cartridge outside and away from other people.
4. Make sure that the cock of the hot plate is CLOSED: cock on “OFF” position (clockwise rotation).
5. Check that the cartridge connection lever is on the “UNLOCK” position.
6. Open the cartridge holder lid and take out the cartridge.
7. Check that the seals are in a good state of maintenance.
8. Put the cartridge in its housing placing the cut on the cartridge’s neck in correspondence to the safety stop.
9. Position the connecting lever on the “LOCK” position.

CLEANING AND MAINTENANCE

Clean your equipment after EVERY USE. Do not use abrasive or flammable detergents, which may damage the components of the unit and may cause a fire. Clean with a solution of warm water and soap.
NEVER USE THE PRODUCTS FOR OVEN CLEANING. CAUTION: All cleaning and maintenance operations, should be made when the unit is cold and after removing the cartridge.

MAINTENANCE – REPAIR
All questions of the departments services must be formulated to: KEMPER – Via Prampolini 1/Q – Lemignano di Collecchio (PR) – Italy – Tel. +39 0521 957111 – Fax +39 0521 957195 – www.kempergroup.it – info@kempergroup.it

RESIDUAL RISKS
There are some residual risks after the installation of the appliance that have to be considered:
Residual risks according to Regulation (EU) 2016/426 (annex 1, point 1.2):

• Although the appliance is designed with all the possible safety requirements, in case of external fire there is the possibility that the internal pressure and temperature of the appliance and of the cylinder will increase in a dangerous and uncontrollable way; in that case use the extinguishing tools suitable for that conditions and get away safely.
• The use of incorrect cartridges and / or cartridges filled with gas other than the one indicated can produce high values of carbon monoxide, dangerous for health. It is recommended to use the appliance only with Kemper butane gas cartridges art. 577/ Decathlon 4050185.
• This appliance can produce carbon monoxide that has no odor. Inhalation of carbon monoxide, odourless and clear gas, can cause flu-like symptoms, sickness illness and possibly death if produced inside aforesaid areas through use of the product without proper ventilation.
• The use of two or more burners in series or located near flammable substances may cause a risk of fire. Therefore, it’s recommended to not put beside the burners and keep them away from flammable substances or from any objects be affected by heat
• At the end of use, always unlock the cartridge and don’t leave the hot pan on the stove. A hot pan can overheat the cartridge. RISK OF EXPLOSION.
• The appliance does not have a flame supervision device. Do not leave the appliance unattended during use. RISK OF FIRE.

The producer will not answer for damages to things or persons coming from the not correct use or not correspondent to these instructions. The guarantee is of two years from the date of purchase of the goods and only in the case in which the product has not been tampered, has not been damaged and has not fallen. Buying receipt with the date must accompany the product. In case of damages due to an incorrect use of the product, the warranty will not be valid.

Imported by:
KEMPER s.r.l.
Via Prampolini 1/Q – 43044 Lemignano di Collecchio – PARMA -ITALY
Tel +39 0521 957111 – Fax: +39 0521 957195
info@kempergroup.it
www.kempergroup.it

References

• Kemper Group
• Kemper Group

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>