SOLUNA VOLANS Portable Power Bank User Manual
- June 12, 2024
- SOLUNA
Table of Contents
User manual
Portable Power Bank
Nov.2022| Revision A.2
About this manual
This manual describes how to install and use the VOLANS. Read this manual before you attempt to use the product, and follow the instructions throughout the installation process. If you are uncertain about any of the requirements, recommendations, or safety procedures described in this manual, contact Soluna immediately for advice and clarification. The information included in this manual is accurate at the time of publication. however, with regards to the product design and technical specification updates, our company reserves the right to make changes at any time without prior notice. In addition, the illustrations in this manual are meant to help explain system configuration concepts and installation instructions. The illustrated items may differ from the actual items at the installation location.
Safety precautions
Warning
The following basic precautions must always be observed when using this
product.
- To read the instruction manual before using this product please.
- To reduce the risk of injury, close supervision is required when using this product near children.
- Do not put your fingers, palms or any part of your body into the product.
- Do not use damaged or modified battery packs or devices.
- Do not use the product with damaged wires, plugs or output wires.
- When the product needs maintenance or repair, do not disassemble the product by yourself. Please hand over the it to a qualified service provider. The wrong disassemble method can lead to fire or electric shock risk.
- In the event of a product failure, to reduce the risk of electric shock, remove the portable from the socket before performing any guided repair operation
- Charge the internal battery in a well-ventilated area. Do not obstruct air circulation
- Under extreme conditions, liquid may be ejected from the battery. Avoid contact with batteries and liquids. In case of accidental contact, rinse with clean water. If fluid comes into contact with your eyes, seek other medical help.
- Do not expose the product to fire or somewhere overheating.
- Only qualified maintenance personnel shall carry out maintenance.
Product Introduction
VOLANS is a portable power supply, battery capacity 1.28kwh (50Ah), built-in 120VAC output, continuous AC output power 1200W, peak up to 2400W, support PV charging and grid quick charging, support UPS function, Built-in car charging port 12V, USB output, Type-c output and night light. It perfectly work with ventilator, mobile temperature door, disinfection machine, electric drill, small household appliances, uav photography equipment; It is suitable for long-distance self-drive, emergency rescue, geological survey, car power supply, indoor and outdoor scenes.
2.1 Features
- Support AC fast charge, full charge in 1 hours.
- Support wireless parallel function, save customers cumbersome wiring, double output power, to meet customers’ high power load requirements.
- Support UPS function, switching time 10ms.
- With wireless Bluetooth function, you can check the operation states online.
- AC instantaneous output power up to 2400W, without fear of various impact loads.
2.2. Application scenarios
- lighting
- Small appliances
- Mobile charging devices
- On-board recharging
- Car battery recharge 6) Power tools
2.3 Outline Dimensions
| Width | 380 | mm |
|---|---|---|
| Depth | 215 | mm |
| Height | 210 | mm |
| Weight | 14 | kg |
2.4 Appearance
|
---|---
Number| Name| Remark
---|---|---
1| LED lighting button|
2| LED light|
3| AC output button|
4| AC output port|
5| Screen|
6| Type-C & USB output button|
7| Type-C port|
8| USB port|
9| VOLANS Power on/off button|
10| Car charger output button|
11| Car charger port|
12| AC input|
13| PV input|
14| Parallel Switch|
2.5 Technical data
PV input
Max. recommended DC power (W )| 400
Vdc input range {Vdc)| 10-65
Max.input current (A )| 10
Number of MPPT trackers| 1
Strings per MPPT tracker| 1
AC Input
Normal Voltage (VAC)| 120,Single phase(L/N/PE)
Frequency (Hz)| 60
Max. AC input current (A)| 12
PF| 0.99@100%Load
THDi| ≤8%@100%Load
AC Output
AC output waveform| Pure sine wave
Normal Voltage (VAC)| 120,Single phase(L/N/PE)
Frequency (Hz)| 60
Rated current (A)| 10.9
Rated power (W)| 1200
Overload| 106110% Rated power @3min
111-130% Rated power @1min
131-149% Rated power @1S 150-200% Rated power @100mS
Power factor range| -0.8-+0.8
Battery
Battery type| Lithium(LFP)
NominalStorage capacity (kWh)| 1.28
Usable Storage Capacity (kWh)| 1.02
Battery capacity (Ah)| 50
Normal voltage (V)| 25.6
Voltage range (V)| 20-28.4
DOD| 80%
Cycle life| 6000
DC output
Car charger output2| 12V/10A
uss2| 5V/2.1A
Type-c*4| 5-12VDC
Max output current 3A Max output power 45W
LED lighting
Max power| 3W
Gear| 2Gears (2W, 3W)
Parallel
Parallel qty| 2 units
Max output power| 2400W
Regular parameters
Operating temperature range (°C)| -10-+40
Relative humidity (%RH)| 5%-95%
Altitude (m)| <2000
Cooling methods| Forced airflow
Ingress protection| IP20
Warranty
Please refer to SOLUNA WARRANTY CONDITIONS
2.6 Screen display
| Number | Name | Remark |
|---|---|---|
| 1 | Input status | |
| 2 | Charging power | |
| 3 | Charging time | |
| 4 | Charging status | |
| 5 | SOC | |
| 6 | Parallel status | |
| 7 | Discharging status | |
| 8 | Discharging time | |
| 9 | Discharging power | |
| 10 | Output status | |
| 11 | AC voltage | |
| 12 | AC frequency | |
| 13 | Fault icon |
2.7 Accessory list
Users can find the following accessories in the accessory box,please find the follow table for details.
| Item | Name | Qty (pcs) | Remark |
|---|---|---|---|
| 1 | AC input cable | 1 | |
| 2 | Parallel cable | 1 | |
| 3 | PV connection cable | 1 |
How to use VOLANS
The Soluna will be in Standby when the user press the button of Power ON/OFF, Then, the user can press the corresponding button as neededPlease find the following picture for the position of button.
| Number | Name | Remark |
|---|---|---|
| 1 | Power on/off button | |
| 2 | Car charger output button | |
| 3 | Type-C & USB output button | |
| 4 | AC output button | |
| 5 | LED lighting button | |
| 6 | Screen button |
VOLANS parallel connection
4.1 Connection
When put 2 units VOLANS in parallel, the cable should be connected form 1st
VOLANS’s AC output port to the 2nd VOLANS’s AC input port. The cable comes
together in the accessory box, details please see below picture.
4.2 setting
The 2nd VOLANS’s output power will be 2 times rated output power of VOLANS after connected in parallel.(MAX output power can up to 2400W)
Wireless Bluetooth
The user will can check the Volans data via APP after download “Volans” APP.
5.1 Download APP
iPhone:Search “Volans” in Apple Store.
Android: Search “Volans” in Google play Store.
Remark: Please see below picture for Volans Icon.
5.2 Bluetooth S/N
User can find the Bluetooth S/N on the Volans, Please find the following
picture for Bluetooth S/N for details.
Contact us
We hope that this manual has clearly demonstrated the product. If you still have any doubts or something not clear about it in the specifications, feel free contact to us please. we will do our best to support you!
SOLUNA
Add: No.3492 Jinqian Road, Shanghai, China 201406
Tel: +86-21-57475835
Email: [email protected]
Web: www.solunabattery.com