Ameriwood HOME 3640013COM CosmoLiving Westerleigh 4-Drawer Dresser Instruction Manual

Ameriwood HOME 3640013COM CosmoLiving Westerleigh 4-Drawer Dresser

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP IT FOR FUTURE REFERENCE.

WARNING

• The unit can tip over causing severe injury or death.
• Anchor unit to stud in the wall (if instructed to)
• Do not allow children to climb on unit
• Put heavy items on lower shelves or drawers

Contact Us

Do NOT return this product

• Contact our friendly customer service team first for help

Call us!

• 1-800-489-3351
• Monday-Friday
• 9am – 5pm CST
• Visit: ameriwoodhome.com
• Assembly Tips: ON YOUTUBE

Helpful Hints

• PEOPLE NEEDED FOR ASSEMBLY: 1-2

• ESTIMATED ASSEMBLY TIME: 1 HOUR

• Open your item in the area you plan to keep it for less heavy lifting

• Identify, sort and count the parts before attempting assembly

• Compression dowels are tapped in with a hammer

• Slides are labeled with a R (right) and L (left) for proper placement

• Make sure to always face the point on the top of the Cam Lock towards the outer edge

• Use all the nails provided for the back panel and spread them out equally

• Back Panel must be used to make sure your unit is sturdy

• Do NOT use harsh chemicals or abrasive cleaners on this item

• Never push, pull, or drag your furniture

Before You Start

• Read through each step carefully and follow the proper order
• Separate and count all your parts and hardware
• Give yourself enough room for the assembly process
• Have the following tools: Flat Head Screwdriver, #2 Phillips Head
• Screwdriver and Hammer
• Caution: If using a power drill or power screwdriver for screwing, please be aware to slow down and stop when screw is tight. Failure to do so may result in stripping the screw.

Cam Lock Fastening System

This Cam Lock Fastening System will be used throughout the assembly process.

Board Identification

Not actual size

• x1
  • T3640013010PK
  • TOP PANEL
• x1
  • T3640013020PK
  • LEFT SIDE PANEL
• x1
  • T3640013030PK
  • RIGHT SIDE PANEL

• x1
  • T3640013040PK
  • BOTTOM PANEL
• x2
  • T3640013050PK
  • MOLDING
• x4
  • T3640013060PK
  • RIGHT DRAWER SIDE

• x4
  • T3640013070PK
  • LEFT DRAWER SIDE
• x4
  • T3640013080PK
  • DRAWER FRONT
• x4
  • T3640013090PK
  • DRAWER BACK

• x4

  • T3640013100PK
  • DRAWER BOTTOM

• x4

  • T3640013110PK
  • LEG

• x4

  • T3640013120PK
  • DRAWER SUPPORT

• x1

  • T3640013130PK
  • BACK PANEL

Part List

Actual Size

Not Actual Size

INSTALLATION INSTRUCTIONS

Step 1

Step 2

Step 3

Step 4

Step 5

Step 6

Step 7

IMPORTANT:  THE BACK PANEL IS A STRUCTURAL PART OF THIS UNIT AND MUST BE INSTALLED PROPERLY.

• Attached back panel as shown nailing straight into the raw edges.
• Ensure that the unit is square.
• Distance from corner to corner must be equal as shown.

Step 8

Step 9

Step 10

Step 11

Step 12

Step 13

For Masonry, Concrete, or other wall materials: Consult your local hardware store for appropriate anchors to securely attach the safety bracket.

IMPORTANT: THIS UNIT MUST BE SECURE TO THE WALL TO HELP PREVENT TIPOVER. FOLLOW THESE INSTRUCTIONS TO INSTALL THE ANTI-TIPPING SAFETY BRACKET PROVIDED WITH THIS PRODUCT.

WARNING

Serious or fatal crushing injuries can occur from furniture tip over.

To prevent tip over

• Install tipover restraint provided
• place heaviest items in the lowest drawers
• Unless specifically designed to accommodate, do not set TVs or other heavy objects on the top of this product
• Never allow children to climb or hang on drawers, door, or shelves
• Never open more than one drawer at a time

The use of tip over restraints may only reduce, but not eliminate the risk of tip over.

Attachment into a wall stud (preferred method)

• Using a stud finder, locate a stud in the wall. Place your unit against the wall, with the safety bracket aligned in this location.
• To make driving the screw easier, you can drill a 1/8” diameter pilot hole (3mm) through the safety bracket into the stud.
• Drive the screw through the safety bracket into the wall stud. Tighten the screw that was not fully tighened.

Attachment into drywall

• Locate your unit where desired against a wall and mark the wall through the safety bracket, then move your unit aside.
• Drill a 3/16” diameter hole (5mm) into the wallboard. Tap the wall anchor into the hole until it is flush.
• Move your unit into location and fasten the wall bracket to the wall anchor with the screw.
• Tighten the screw that was not fully tightened.

Step 14

Maximum Loads

This unit has been designed to support the maximum loads shown. Exceeding these load limits could cause sagging, instability, product collapse, and/or serious injury.

Warning: Risk of serious injury to person – do not place a television on this furniture. This furniture is not approved for use with a television.

Certificate of Conformity

1. This certificate applies to Dorel Home Furnishings, Inc. product identified by this instruction manual.
2. This certificate applies to compliance of this product with the CPSC Ban on Lead-Containing Paint ( 16 CFR 1303).
3. This product is distributed by
   • Dorel Home Furnishings, Inc.
   • 410 East First Street South, Wright City, MO 63390
   • 636-745-3351
4. Site of Manufacturer: Muar, Malaysia.
5. See front page of instruction manual for date of manufacturer.

Register your product to receive the following

• New trend details -sneak peek on what’s new
• Surveys -have a voice within our community
• Exclusive deals and discount codes
• Quick and easy replacement part service

To register your product, visit: Ameriwoodhome.com

5 Star Rating

Visit your local retailer’s website, rate your purchased product and leave us some feedback!

We would like to extend a big “Thank You” to all of our customers for taking the time to assemble this Ameriwood Home product and to give us your valuable feedback.

ameriwoodhome.com

CONTACT

• Do Not Return This Product!
• Contact our customer service team for help first
• Call: 1-800-489-3351 (toll free)
• Monday-Friday 9am – 5pm CST
• Visit: www.ameriwoodhome.com

References

• Ameriwood Furniture | Living Room Furniture | Entertainment Centers
• Ameriwood Furniture | Living Room Furniture | Entertainment Centers

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>