NICOR DLR4v5 4-inch White Recessed LED Downlight System Instruction Manual
- June 3, 2024
- NICOR
Table of Contents
NICOR DLR4v5 4-inch White Recessed LED Downlight System
THIS PRODUCT MUST BE INSTALLED IN ACCORDANCE WITH THE APPLICABLE INSTALLATION
CODE BY A PERSON FAMILIAR WITH THE CONSTRUCTION AND OPERATION OF THE PRODUCT
AND THE HAZARDS INVOLVED
ATTENTION: Turn power off before inspection, installation, or removal.
Use only on 120VAC, 60Hz circuits. NOTE: For use with NICOR DLR4v5 retrofit
downlight ONLY
NOTE: For use with NICOR DLR4v5 retrofit downlight ONLY
What’s In The Box
Tools Needed
The DLR4 Recessed Frame requires very few tools for installation. A drill or
screwdriver, a pair of wire cutters, and a hammer will help with installation.
Make sure all power is turned off before beginning installation
Installing the DLR4v5 Frame
① Careful unpack the frame from its packaging. Inspect product for defects due to shipping.
② If necessary, adjust hangar bar length by separating bars, snapping to
length at score marks, and reassembling.
③ Position frame between joists, ensuring hangar bars are in the correct
position. Bottom edge of hangar bars should be level with the bottom of the
joists. – Starting with the swivel foot end of the hangar bar, Secure the
hangar bars to the joists with the captive nails provided.
| ④ Lift and secure opposite side of frame to ceiling joist. Position
frame in desired place on hangar bars and tighten set screw to lock frame in
place.
⑤ Connect building power to the frame junction box. Connect black to
black and white to white using the provided quick connectors. Connect the bare
copper wire to the ground wire of the power source.
Make sure all power is turned off before beginning installation
Installing the DLR4v5 Down light into the DLR4v5 Frame
① Carefully unpack the downlight from its packaging. Inspect product for defects due to shipping.
② If using optional colored trim, align trim onto down light and secure
by bending over tabs.
③ Join the DLR’s female quick connector to the Frame’s male quick
connector.
| ④ Align the tabs
of the frame cap to the depressions on the DLR and snap the cap in place,
making sure no wiring is pinched
⑤ Align downlight to frame opening ..
| ⑥ Carefully
push the down light upwards making sure it is flush to the ceiling surface.
View of properly installed downlight system
EXPRESS LIMITED WARRANTY
Subject to the exclusions below, each NICOR LED product, including the LED
electronics and components of a property installed NICOR LED product, will be
free from defect in materials and workmanship for a period of ve (5) years
from the original date of purchase. The product shall be considered defective
only if 10% or more of the product’s LED components fail. NICOR LED product
warranty covers the following performance criteria: LED Light Output will be
maintained above 70% of initial output; LED color temperature will not shift
more than 200K in CCT; LED driver will operate within NICOR specifications;
and the xturenish, excluding natural aluminum or brass products, will not
exhibit cracking, peeling, excessive fading, or corrosion during the warranty
period. Exceptions apply as dened in NICOR’s product specification sheets,
which are incorporated by reference herein.
This limited warranty is provided to you, the purchaser of the product ideated
on Seller’s invoice, as your exclusive remedy and applies only to NICOR
products that have been purchased from an authorized NICOR Distributor; the
product was new and in an unopened NICOR package at the time of installation;
and the NICOR product was installed by a licensed electrician or under the
supervision of a licensed electrician and used by consumers in the United
States or Canada when accompanied with this warranty. This warranty extends
only to the rst consumer purchaser and is not transferable. A consumer wishing
to invoke the terms of this limited warranty must rst obtain a RGA number
within 30 days of discovery of the defect, and return the product to NICOR for
inspection. Once veried to be covered by this limited warranty, NICOR will, at
its sole discretion, repair, replace, or refund the purchase price of any
product that does not conform to this limited warranty. If NICOR, at its sole
discretion, determines that the product should be repaired or replaced, this
warranty is limited to the reasonable, customary, and necessary costs and
expenses associated with the repair/replacement. This warranty requires that
all repair/replacement estimates and costs, including but not limited to
equipment rental (if any), and any other cost or expense to be incurred in the
repair/replacement of the product, be approved in advance and in writing by
NICOR. FAILURE TO OBTAIN NICO R’S ADVANCE WRITTEN APPROVAL OF ALL
REPAIR/REPLACEMENT COSTS AND EXPENSES IN WRITING SHALL VOID THIS LIMITED
WARRANTY. THIS LIMITED WARRANTY DOES NOT COVER THE FOLLOWING:
- Defects or damages resulting from improper installation, operation, storage, misuse or abuse, accident, or neglect;
- Defects or damages resulting from improper service, testing, adjustment, installation, maintenance, alteration, connection to out-of-speciation electrical service, corrosive or damp environments, or connection to incompatible equipment or devices (e.g., connecting non-dimmable lighting products to dimmers);
- Damage which occurs in transit;
- Power surges or overheating due to external conditions
- Acts of nature including but not limited to lightning strikes
ANY IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION, THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE SHALL BE LIMITED TO THE DURATION OF THIS LIMITED WARRANTY, OTHERWISE THE REPAIR, REPLACEMENT, OR REFUND AS PROVIDED UNDER THIS EXPRESS LIMITED WARRANTY IS THE EXCLUSIVE REMEDY OF THE CONSUMER, AND IS PROVIDED IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED. IN NO EVENT SHALL NICOR BE LIABLE, WHETHER IN CONTRACTOR IN TORT (INCLUDING NEGLIGENCE) FOR DAMAGES IN EXCESS OF THE PURCHASE PRICE OF THE PRODUCT, OR FOR ANY INDIRECT, INCIDENTAL, SPECIAL OR CONSEQUENTIAL DAMAGES OF ANY KIND, OR LOSS OF REVENUE OR PROFITS, LOSS OF BUSINESS OR OTHER FINANCIAL LOSS ARISING OUT OF OR IN CONNECTION WITH THE ABILITY OR INABILITY TO USE THE PRODUCT TO THE FULL EXTENT THESE DAMAGES MAY BE DISCLAIMED BY LAW.
SHARE YOUR EXPERIENCE WITH US
SCAN the QR or visit
www.nicorlighting.com/support/survey
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>