POLAR GP291-A Countertop Food Display Fridge Instruction Manual

: August 21, 2024
: Polar

Table of Contents

POLAR GP291-A Countertop Food Display Fridge
Product Description
Installation
Operation
Troubleshooting
DECLARATION OF CONFORMITY
Documents / Resources

POLAR GP291-A Countertop Food Display Fridge

Safety Instructions
Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

Position on a flat, stable surface.
A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.
In Queensland, the service agent/qualified technician MUST hold a Gas Work Authorization or License for hydrocarbon refrigerants if the appliance gas system is being opened or charged.
Consult Local and National Standards to comply with the following:
- Health and Safety at Work Legislation
- BS EN Codes of Practice
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
DO NOT use jet/pressure washers to clean the appliance.
DO NOT use the appliance outside.
DO NOT use this appliance to store medical supplies.
DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
DO NOT store products on top of the appliance.
Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.
Always carry, store, and handle the appliance in a vertical position and move by holding the base of the appliance.
Always switch off and disconnect the power supply to the unit before cleaning.
Keep all packaging away from children. Dispose of the packaging by the regulations of local authorities.
Children should be supervised to ensure that they do not play with the appliance.
This appliance is not intended for use by persons (including children) with reduced physical, sensory, or mental capabilities, or lack of experience or knowledge unless they have been given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
POLAR recommends that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing.
Caution: Risk of Fire
Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of obstruction. The unit should not be boxed in without adequate ventilation.
To comply with AS/NZS 60079.10.1:2009: Ensure there are no sources of ignition in any area where refrigerant could gather in the event of a leak.
Electrical equipment should not be placed under the vent or where refrigerant could gather in the event of a leak.
Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
Warning: Do not damage the refrigerant circuit.
Warning: Do not use electrical appliances inside the food storage compartments of the appliance.

Product Description

GP292-A – POLAR Countertop Food display fridge Black – 120Ltr
GP291-A – POLAR Countertop Food display fridge Black – 160Ltr

Pack Contents

POLAR Counter-Top Food display fridge
Shelves x 2
Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Not for use in vans or trailers, food trucks, or similar vehicles. If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before the operation. If in doubt allow to stand.

Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top.

NEVER LOCATE NEXT TO A HEAT SOURCE.
Note: Before using the appliance for the first time, clean the shelves and interior with soapy water then dry well.

Operation

Control Panel
The control panel is located below the doors on the rear of the appliance.

Turn On

Close the doors of the appliance.
Connect the appliance to a mains power supply.
Press the button to turn the light On or Off as required.

Setting the Operating Temperature

Press the SET button. The display will flash.
Press the or buttons to display the required temperature.
Press the SET button to store the temperature.

Manual Defrost
Press and hold the button for 6 seconds to begin automatic defrost. The defrost light illuminates. The defrost cycle will end automatically.

Cleaning, Care & Maintenance

Switch off and disconnect from the power supply before cleaning.
The doors can be removed for ease of cleaning.
Clean the interior of the appliance as often as possible.
Do not use abrasive cleaning agents. These can leave harmful residues.
Clean the door seal with warm soapy water.
Always wipe dry after cleaning.

Condensation and ice will form with frequent and prolonged opening of the doors. Operating outside of the recommended temperature range and placing it next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth. Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components. Replacing the Interior Lamp Call your POLAR dealer or a qualified electrician, the Lamp Assembly is available to purchase as a spare part.

Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance. POLAR recommends that a POLAR agent or qualified technician clean the condenser.

Troubleshooting

A qualified technician must carry out repairs if required.

Fault	Probable Cause	Solution
The appliance is not working	The unit is not switched on	Check the unit is

plugged in correctly and switched on
Plug or lead are damaged| Replace plug or lead
Mains power supply fault| Check mains power supply
The appliance turns on, but the temperature is too high/ low| Too much ice on the condenser| Defrost the appliance
Condenser blocked with dust| Clean the condenser
Doors are not shut properly| Check doors are shut and seals are not damaged
Appliance is located near a heat source, in the direct sunlight or air flow to the condenser is being interrupted| Move the refrigerator to a more suitable location
Ambient temperature is too high| Increase ventilation or move appliance to a cooler position
Unsuitable foodstuffs are being stored in the appliance| Remove any excessive hot foodstuffs or blockages to fan
Appliance is overloaded| Reduce the amount of food stored in the appliance
The appliance is leaking water| The appliance is not properly levelled| Adjust the screw feet to level the appliance (if applicable)
The appliance is unusually loud| Loose screw/nut| Check and tighten all nuts and screws
The appliance has not been installed in a level or stable position| Check installation position and change if necessary
The display lamp does not illuminate| Lamp needs replacing| Replace the lamp
Light not turned on| Ensure Light button has been pressed properly
Door does not shut| Dirt/obstacle in runners| Clean runners
Error code EE4| • Restricted Airflow

• Blocked Condenser

| • Increase airflow

• Clean the condenser

Technical Specifications

Model

|

Voltage

Refrigerant

| Dimensions H x W x D mm| Weight (kg)
---|---|---|---|---|---|---|---|---
GP292- A| 220-240V~

50Hz

| 160| 1.4| 2°C to 12°C| 120| R600a| 686 x 696 x

568

| 57
GP291- A| 200| 1.4| 2°C to 12°C| 160| R600a| 686 x 874 x

568

| 66

Note: Due to our continuing program of research and development, the specifications herein may be subject to change without notice.

Note: For optimal product performance and efficiency, please ensure the net usable capacity (load limit) when filling.

Electrical Wiring
The plug is to be connected to a suitable main socket.

This appliance is wired as follows:

Live wire (colored brown) to the terminal marked L
Neutral wire (colored blue) to the terminal marked N
Earth wire (colored green/yellow) to the terminal marked E
The appliances must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required, they must be readily accessible.

Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area. POLAR parts have undergone strict product testing to comply with regulatory standards and specifications set by international, independent, and federal authorities.

POLAR products have been approved to carry the following symbol: All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserves the right to change specifications without notice.

DECLARATION OF CONFORMITY

Equipment Type • Uitrustingstype • Type d’équipement • Gerätetyp

• Tipo di apparecchiatura • Tipo de equipo

| Model • Modèle • Modell •

Modello

• Modelo

---|---
G-Series Energy Efficient Countertop Food Display Fridge Black – 160Ltr

G-Series Energy Efficient Countertop Food Display

Fridge Black 120Ltr

| GP291 (-E & -A)

GP292 (-E & -A)

Application of Territory Legislation & Council Directives(s)

| Machinery Directive 2006/42/EC

Supply of Machinery (Safety) Regulations 2008

EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019

+A14:2019 +A2:2019 +A15:2021 EN IEC 60335-2-89:2022 +A11:2022

IEC 60335-1:2010 +A1:2013 +A2:2016 IEC 60335-2-89:2019

EN 62233:2008

Electro-Magnetic Compatibility (EMC) Directive 2014/30/EU – recast of 2004/108/EC Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091)

EN IEC 61000-6-3: 2021

EN IEC 61000-6-1: 2019

Regulation (EU) 2019/2024 – Ecodesign direct sales refrigerators

ISO 23953-2:2015

Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU

Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment Regulations 2012 (S.I. 2012/3032)

| Electrical Safety
AS/NZS 60335-2-89:2020
AS/NZS 60335-1:2020 +A1:2021
Electromagnetic Compatibility
EN IEC 61000-6-3: 2021
EN IEC 61000-6-1: 2019
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers

• Nome del produttore • Nombre del fabricante

| Polar

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s), and Standard(s).

Date

Documents / Resources

| POLAR GP291-A Countertop Food Display Fridge [pdf] Instruction Manual
GP291-A, GP292-A, GP291-A Countertop Food Display Fridge, GP291-A, Countertop Food Display Fridge, Food Display Fridge, Display Fridge
---|---