UKIAH TK-1005-T Tailgater Fire Pit User Manual

UKIAH TK-1005-T Tailgater Fire Pit User Manual

TK-1005-T | 7 2802848231 7
TK-1045-TGRN | 7 2802848401 4
TK-1006-T2 | 7 2802848232 4
TK-1044-T2BLK | 7 2802850224 4

www.UKIAHCO.COM

DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to appliance.
Extinguish any open flame.
If odor continues, leave the area immediately.
After leaving the area, call your gas supplier or fire department.
Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

WARNING
Do not store or use gasoline, or other flammable vapors and liquids, in the vicinity of this or any other appliance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING: For Outdoor Use Only.
Installation and service must be performed by a qualified installer, service agency, or the gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.

CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a camper, tent, car or home.

WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury, or loss of life.

SAFETY INFORMATION

WARNING
Please read these setup and operating instructions carefully before setup, operation or service of this gas fire pit. Do not operate if you are uncertain as to the meaning of any instructions or warnings. Improper installation, adjustment, alteration, maintenance, service or use of this product may result in property damage, personal injury or the potential loss of life.

Save these instructions for future reference. If you are assembling this unit for another person, give this manual to the fire pit operator to read and save for future reference. If ownership of the product is transferred, this manual should be provided to the new owner.

This product is designed to use Liquid Propane fuel only. Do not attempt to use natural gas as a fuel. ONLY OUR HOSE AND REGULATOR SUPPLIED IN THE PACKAGING CAN BE USED WITH OUR FIRE PITS.

Failure to follow the DANGERS, WARNINGS, AND CAUTIONS in this owner’s manual may result in serious bodily injury, death, or may result in a fire or an explosion causing damage to property.

WARNING: This product is for outdoor use only.
WARNING: Do not use this product near vegetation or on, under, or near structures that could catch fire such as wooden decks, vinyl siding, or porches with overhangs.
WARNING: This product produces high temperatures that will create hot surfaces. Appropriate care should be used to avoid physical contact with these surfaces.
WARNING: Do not use this product during windy conditions.
WARNING: This product should be used on a flat and stable surface to avoid overturning.
WARNING: Do not leave unattended when in use or connected to a fuel supply.
WARNING: This product includes small components such as glass crystals that may pose a choking hazard or cause significant physical injury if swallowed. Appropriate care must be taken to prevent children from having unsupervised access to this product or any of its components.

WARNING: Maintenance or service on this product must be performed by a qualified installer or licensed service
professional.
WARNING: DO NOT move the unit for at least 60 minutes after use to allow for cooling.
WARNING: Allow the burner and glass crystals or lava rock to cool completely before touching.
WARNING: Glass crystals or Lava rock may be sharp. Before handling, make certain they have cooled completely and handle them wearing protective gloves to prevent injury.
WARNING: This device can produce carbon monoxide that has no odor. Never use in an enclosed space of any kind, including but not limited to the inside of a home, garage or building. Use in such an enclosed space can be potentially fatal.
WARNING: After a period of storage or non-use, check for leaks and burner obstructions.
WARNING: Do NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the fire pit is in use.

WARNING: Do NOT attempt to move fire pit when in use.
WARNING: Always keep children and pets away from fire pit.
WARNING: Never lean over the fire pit when lighting or in use.
WARNING: Do NOT attempt to repair or alter the pressure regulator for any assumed defect. Any modification to this assembly will void your warranty and create the risk of a gas leak and fire.
WARNING: This fire pit should be thoroughly cleaned and inspected on a regular basis.
WARNING: Do NOT use the fire pit unless it is COMPLETELY assembled, and all parts are securely fastened and tightened.
WARNING: Do NOT use in an explosive atmosphere.
WARNING: Do NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.
WARNING: Recheck all connections as described in the Operating lnstructions section of this manual, as shipping can loosen connections.

• Check for leaks even if your unit was assembled for you by someone else.
• Do NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion.
• You must follow all instructions in the “Checking for Leaksn section before operating.

WARNING: To prevent a fire or explosion hazard when testing for a leak:

• Always perform a leak test before lighting the fire pit and each time the cylinder is connected for use.
• No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
• Conduct the leak test outdoors in a well-ventilated area.
• Do NOT use matches, lighters, or a flame to check for leaks.
• The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
• Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and common sense when testing for leaks.
• Do NOT use fire pit until any and all leaks are corrected. If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

WARNING: Never keep an LP gas cylinder in a hot car or trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.
WARNING: Do NOT block holes in sides or bottom of fire pit.
WARNING: Apartment dwellers: Check with management to learn the requirements and fire codes for using a LP gas fire pits in your apartment complex.
WARNING: This fire pit is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause asphyxiation.
WARNING: ELECTRONICS INSIDE, MUST PUT COVER ON UNIT WHEN LEAVING OUT IN WET CONDITIONS.
DANGER: Do not use the product if any part has been submerged in water. Immediately call a qualified service technician to inspect the unit and to replace any part of the control system and any gas control that has been in water.

WARNING: Special care must be taken to keep children and pets away from hot surfaces.
WARNING: Deaths, serious injury or damage to property may occur if the above is not followed exactly.
DANGER – lf you smell gas fumes:

1. Shut off gas to the appliance by turning the fuel knob to “OFF” and turn LP tank off.
2. Extinguish any open flame. Do not touch or make contact with any electrical switches.
3. Do not ignite a match or lighter of any kind.
4. Do not use any phone, including cell phones, in the vicinity of the gas source.
5. If the smell of fumes persists, call the local fire department from a remote phone.

Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury, or death.

WARNING

• Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.
• An LP cylinder not connected for use should not be stored near this or any other appliance.
• If a fire should occur, keep away from the appliance and immediately call your fire department.

Failure to follow these instructions could result in fire, explosion or burn hazard, which could cause property damage, personal injury or death.

The LP gas tank is NOT included with the gas fire pit.

SAFE HANDLING FOR LP GAS TANK:

• Do not use a damaged, dented or rusty LP tank.
• Handle empty LP tanks with the same care as you handle full tanks. Even when the LP tank is empty of liquid, there may still be gas pressure inside the cylinder.
• LP gas tanks should never be dropped or handled roughly.
• Never store or transport the LP tank where temperatures can reach 125 °F (51.7 °C).
• LP tanks must be kept out of reach of children.

WARNING

• DO NOT block any ventilation openings.
• Install in accordance with the manufacturer’s instructions.
• DO NOT defeat the safety purpose of the polarized or grounding-type plug. A polarized plug has two blades with one wider than the other. A grounding type plug has two blades and a third grounding prong. The wider blade or the third prong are provided for your safety. If the provided plug does not fit into your outlet, consult an electrician for replacement of the obsolete outlet.
• PROTECT the power cord from being walked on or pinched particularly at plugs, convenience receptacles, and the point where they exit from the apparatus.
• ONLY USE attachments and accessories specified by the manufacturer.
• UNPLUG this apparatus during lightning storms or when unused for long periods of time.
• REFER all servicing to qualified service personnel. Servicing is required when the apparatus has been damaged in any way, such as power-supply cord or plug is damaged, liquid has been spilled or objects have fallen into the apparatus.
• DO NOT overload wall outlets or extension cords beyond their rated capacity as this can cause electric shock or fire.
• Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type.
• DO NOT ingest the battery.
• Keep new and used batteries away from children.

WARNING

• If the battery compartment does not close securely, stop using the product and keep it away from children.
• If you think batteries might have been swallowed or placed inside any part of the body, seek immediate medical attention.
• The battery (battery, batteries or battery pack) shall not be exposed to excessive heat such as sunshine, fire or the like.
• DO NOT handle leaking or damaged batteries.
• Only use the specified type of Batteries.
• Observe correct polarity.
• Remove batteries from products that are not in use for extended periods of time. Store batteries in a dry place.
• Do not recharge non-rechargeable batteries.
• Avoid exposure to extreme heat or cold.
• THIS PRODUCT CONTAINS A CELL BATIERY. IF MISUSED OR ABUSED THIS CAN RESULT IN:

-Smoke or gas hazard -Heat hazard -Fire hazard -Explosion hazard

WARNING
Keep out of reach of children. The content of this package includes small parts and cords that can cause choking or strangulation.

The appliance when installed, must be electrically grounded in accordance with local codes, or in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70; or the Canadian Electrical Code, CSA C22.1, if applicable.

To properly locate the gas hose, remove the coiled hose contained within interior of unit. Carefuly remove the zip-tie using caution to not damage the gas hose in any way. Uncoil and attach to LP-Gas tank illustrated on figure 4, page 14.

Locate hose out of pathways where people may trip over or in areas where the hose may be subject to accidental damage.

PROPOSITION 65 WARNING
Handling the brass material on this product exposes you to lead, a chemical known to the state of California to cause cancer, birth defects or other reproductive harm. WASH YOUR HANDS AFTER HANDLING THIS PRODUCT.

For more information go to www.P65Warnings.ca.gov.

TAILGATER

TAILGATER ΙΙ

WELCOME TO THE UKIAH Co. FAMILY
Based in the Pacific Northwest, Ukiah Co. was founded with a mission to offer the world products never before seen in the outdoor living market. Our goal is to offer affordable, top quality outdoor entertainment with unique and trend- setting styles that bring people together. Mankind has always been deeply connected to the outdoors, companionship and music; we develop products that embody these natural fundamentals of life. Wherever your adventures may find you, Ukiah Co. offers a diverse entertainment product line to enhance your outdoor experience at home or on the go. Our audio-capable products transform outdoor living spaces and enhance your favorite activities that will change the way you enjoy the outdoors.

CONGRATULATIONS ON YOUR TAILGATER”‘ PURCHASE
Take your outing to the next level with the most versatile portable fire pit on the market. The Tailgater comes equipped with a 2.0 audio system and an optional cast-iron cook-top accessory. Connect by Bluetooth® and enjoy the highest quality audio with fire ambiance anywhere you want to be. Upgrade to Ukiah Co.’s “Responsive Flame Technology” and a 2.1 audio system in the Tailgater II. This elite edition offers “Beat To Music mode” that allows the fire and your music to be harmonized for amplified entertainment.

By purchasing this unit, you agree to follow all startup and safety instructions. You also agree that this product will not be used for any other reason as it was intended. Any questions or comments about our product, please click the “Contact us” link at www.UkiahCo.com

GENERAL INFORMATION

• This device can produce carbon monoxide that has no odor. Never use in an enclosed space of any kind, including but not limited to the inside of a home, garage or building. Use in such an enclosed space can be potentially fatal.

• Make certain that the outdoor area in which the product is being used offers acceptable cross ventilation.

• Gas cylinders must be stored outdoors in a well-ventilated area, out of the reach of children. Disconnected cylinders must have threaded valve plugs tightly installed and must not be stored in a building, garage or other enclosed area.

• Check with your local fire safety authority if you have any questions about the use or operation of portable gas cylinders or this gas fire pit.

• Operator should inspect the product before each use. It should be inspected at least annually by a qualified service technician. More frequent cleaning may be required as necessary. It is imperative that the control compartment, burner and circulation air passageways of the unit are kept clean and free of debris.

• If it is evident that there is excessive abrasion or wear on any of the components, they must be replaced prior to the product being put into service. Contact us at www.UkiahCo.com.

• The operator of this gas fire pit should alert adults and children to the hazards of high surface temperatures and the danger of burns or clothing ignition. Adults and children should maintain a reasonable distance from the open flame and hot surfaces. Flammable materials should not be placed near the fire pit.

• Flame heights can change suddenly. Never pass objects over the unit. Never place objects on top of the fire pit. Never reach over fire pit assuming the flame will remain at its “LowH setting.

• Always turn unit off after use.

• Young children should be closely supervised when near the product. Do not leave this gas fire pit unattended, especially around children or pets.

• Solid fuels such as wood, paper, or trash should not be burned in this gas fire pit. This product is designed for decorative purposes only, and should not be used for heating, cooking, or drying.

• Do not attempt to assemble or operate this fire pit while under the influence of any type of alcohol or medication. Use this gas fire pit in accordance with all applicable local, state, and national codes.

• Any guard or protective device removed in order to service the device must be replaced prior to operating the fire pit.

• Inspect the fuel supply for evidence of leakage prior to each use of the fire pit. The pressure regulator and hose assembly supplied must always be used.

• The 20 lb. gas cylinder must be constructed and marked in accordance with the specifications for Liquid PropaneGas cylinders as required by the U.S. Department of Transportation (DOT) or the Canadian Transportation Commission
  (CTC).

• The 20 lb. gas cylinder used must include a collar to protect the cylinder valve.

• When the unit is not in use, the gas supply must be turned completely off using the valve on the cylinder tank.

LEAK TESTING

LEAK TESTING:
All factory-made connections have been thoroughly tested for gas leaks. However, shipping and handling may have loosened a gas fitting.

AS A SAFETY PRECAUTION:

• TEST ALL FITIINGS FOR LEAKS BEFORE USING YOUR GAS FIRE PIT.
• TEST THE CYLINDER VALVE FOR LEAKS EACH TIME THE CYLINDER IS FILLED.
• TEST FOR LEAKS EVERY TIMEYOU CONNECT AGAS FITIING.
• DO NOT SMOKE WHILE TESTING FOR LEAKS.
• NEVER TEST FOR LEAKS WITH A LIGHTED MATCH OR OPEN FLAME.
• TEST FOR LEAKS OUTDOORS.

DANGER: Do NOT use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, which could result in serious bodily injury or death and damage to property.
WARNING: To prevent a fire or explosion hazard when testing for a leak:

• Always perform a leak test before lighting the fire pit and each time the cylinder is connected for use.
• No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
• Conduct the leak test outdoors in a well-ventilated area.
• Do NOT use matches, lighters, or a flame to check for leaks.
• The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
• Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and common sense when testing for leaks.
• Do NOT use fire pit until any and all leaks are corrected. If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

TO TEST FOR LEAKS:

1. Extinguish any open flame or cigarettes in the area.
2. Check the cylinder valve and appliance valves are in the “OFF” position.
3. Connect LP gas cylinder.
4. Prepare a soap solution of one-part water, one-part liquid detergent.
5. With a full gas cylinder, open cylinder slowly.
6. Brush the soap solution on each connection and along the hose.
7. A leak is identified by a flow of bubbles from the area of the leak.
8. If a leak is detected, close the gas cylinder “shut-off” valve, tighten the connection and retest (Step 5)
9. lf the leak persists, do not attempt to operate appliance and contact Ukiah Co.

LIGHTING SAFETY

FOR YOUR SAFETY, READ BEFORE LIGHTING

• Make sure you are familiar with the owner’s manual and you understand all precautions noted.
• Before operating, smell around the appliance and next to the ground for gas odors because some gases are heavier than air and may settle on the ground.
• Use only your hand to turn the gas control valve. Never use tools. If the valve will not turn (that is, without the use of a tool), do not try to repair it. Call a qualified service technician.
• Do not use the appliance if any part has been submerged in water. Immediately call a qualified service technician to inspect the unit and to replace any part of the control system and any gas control that has been under water.
• Make sure the igniter batteries have been installed properly. The igniter will not operate otherwise.
• Inspect hoses to make sure there are no kinks in them and check for leaks.
• After connecting the gas line and checking for leaks, the unit is ready to be lit. Upon the initial use, a small amount of air will be in the lines. When first lighting the burner, it will take a few seconds for the lines to purge themselves of this air.
• Once purging is complete, the burner will light and operate as indicated in the instruction manual. Subsequent lighting of the unit will not require purging unless the gas supply has been disconnected.

  WARNING: Read and follow the safety and lighting instructions in this manual and on the labels on the appliance.
IMPROPER SETUP OR USE COULD RESULT IN A FIRE OR EXPLOSION RESULTING IN PROPERTY DAMAGE, INJURY OR LOSS OF LIFE.

OPERATIONAL NOTES

1. DO NOT move the unit for at least 60 minutes after use to allow for cooling.

2. Allow the burner and glass crystals or lava rock to cool completely before touching.

3. Glass crystals or lava rock may be sharp. Before handling, make certain they have cooled
   completely and handle them wearing protective gloves to prevent injury.

4. INLET PRESSURE: 0.5 PSI Minimum, 11 Inches Water Column, 13.5 Inch Water Column. BTM MODE: 5 PSI Minimum, 5 PSI Maximum.

Read More About This Manual & Download PDF:

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>