DEFA 705200 1x12A Onboard MultiCharger User Guide
- June 6, 2024
- DEFA
Table of Contents
DEFA 705200 1x12A Onboard MultiCharger
ABOUT THE CHARGER3
DEFA Multi/Marine/RescueCharger 1x12A is based on modern switch-mode technology and galvanized divisions. These charges represent the latest technology within battery charging and will give the batteries optimum life. It is well suited to battery sizes up to approx. 150Ah and can maintenance charge the battery for an unlimited time. The charger can stand parallel charging up to 6A parallel consumption at the same time as it charges the batteries. The charging voltage is temperature compensated with an external sensor.
AVAILABLE ACCESSORIES
Item number 705463 – Schuko cable for charger
CHARGE PROCESS
- See Picture on page 3. The Picture shows the charge process in a graph with Voltage (V) and Current (I) over time (t)
- The LED on the front of the charger shows the charger status:
- Green pulse – Charging
- Solid green – Fully charged
- Red pulse – Error
INSTALLATION
Read the user manual carefully. The wrong installation can result in damage to
the equipment and possible injury. If there are any uncertainties, please
contact DEFA or a qualified person. Fix the charger properly where it is to be
installed. See the drill guide on page 3. Connect red wire to (+). Some
vehicles have a battery monitoring system. Connect ground according to the
vehicle manufacturer’s recommendation. The charger is intended for use with
lead/acid, AGM and GEL batteries, but the battery manufacturers
recommendations should always be taken into consideration. The temperature
sensor should be placed on the battery or close to the battery for optimal
functionality. The fuse on the charging cable is 15A. The charger has to be
installed with the connectors facing downwards to maintain IP rating 44.
NOTE: To make sure the correct charging voltages the charging cables must
not we shortened or made longer. Route the cables onto the contacts on the
battery charger (Page 2, picture 1) so that they are straight, in order to
prevent the PlugIn contacts from being bent or twisted (Page 2, picture 2).
SAFETY
- Please read the manual carefully before use.
- This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved.
- Do not attempt to charge no-rechargeable batteries.
- After use, disconnect the mains power before disconnecting from the battery.
- Only use the charger in well-vented area and on vented batteries.•
- This charger has to be repaired by professionals.
- The charge output is protected against short circuiting and wrong connections.
- The charger does not draw current from the battery when the main power is not connected.•
- Do not install the charger in a highly flammable environment.
- Do not charge a damaged battery.
- During charging, battery gas which is very explosive can be developed. Take care not to have sparks, open flames, cigarettes or similar in the vicinity of the battery.•
- The acid in the battery is corrosive and harmful. It damages clothes, metal and varnish. In case of spillage and contact with skin, wash and rinse thoroughly with water and consult a doctor.
- Lead and other chemicals that are used in batteries are toxic. Wash skin and hands thoroughly after working with batteries.
MAINTENANCE
The charger is maintenance free. All batteries should be inspected monthly as a minimum to achieve the best possible safety. The charging process is in such way that the batteries remain fully charged without further water consumption than normal evaporation.
WARRANTY
The guarantee applies to faults in production and materials for 2 years from date of purchase. The customer must deliver the product back to the place of purchase together with the receipt. The guarantee shall cease to apply if the charger is handled negligently, opened or repaired by someone other than DEFA or an authorized representative of DEFA. DEFA has no other guarantee than this and will not be responsible for other costs than those referred to, i.e. no possible additional costs. Neither is DEFA bound by any other guarantee.
TECHNICAL INFORMATION
- Temperature-compensated approx 5,0 mV/oC/cell. Ref. 25 oC.