EVOLV Corsa Electric Scooter User Manual

: June 5, 2024
: EVOLV

Table of Contents

EVOLV CORSA
How to Fold
How to Unfold
How to Change Pin Code
Dashboard Instructions
Battery Safety
How to Charge
Safety & Cleaning Tips
Product Specification
Limited Warranty
Documents / Resources

Corsa Electric Scooter
User Manual
Charge Up Your Journey

EVOLV CORSA

EVOLV Corsa Electric Scooter - figure 1

How to Fold

EVOLV Corsa Electric Scooter - figure 2

Turn off the power.
Open the column lock buckle and slide the column lock upward.
Push the steering column down and connect the folding clasp to the deck hook near the kick plate.

How to Unfold

EVOLV Corsa Electric Scooter - figure 3

Unhook the folding clasp from the deck. Unfold the steering column and straighten it out.
The slide column locks down the steering post and closes the buckle to lock it in place.
Ensure the column lock is secured and you’ve closed the buckle to lock it in place, before riding.

How to Change Pin Code

EVOLV Corsa Electric Scooter - figure 4

Customize Pin Code Dial
Open your deck with a three-digit pin code. Set your password to any three- digit combination!

To customize your pin code, while unlocked push a 1 mm Allen key or similar sized tool, into the pin code dial hole. Whilst engaged, spin the number dial to set a new custom pin code.
Pull the Allen key out of the dial hole to lock your new pin code in.
Note: Save your pin code somewhere safe. A new code cannot be set without The current password.

Dashboard Instructions

EVOLV Corsa Electric Scooter - figure 5

Dashboard Instructions

Power Switch
Turn the key to unlock and turn on the LCD screen. The electric vehicle will automatically turn off after 2 minutes, if not in operation.
Speed Control
The speed mode can be changed by switching through 1, 2, and 3-speed levels.
L1 – Low Speed
L2 – Medium Speed
L3 – High Speed
Lights Control
Toggle the ON / OFF switch to turn on or off the headlights and tail lights.
The taillights will lash automatically when braking.
Push the LEFT / RIGHT switch to signal left or right turn signal lights.
Power Indication
The number of bars estimates the remaining power of the lithium battery.
Note: Recharge when there is only one bar because emptying the scooter of power (zero bars) is damaging to the battery over time.
Dual Motors
Press the SINGLE / DUAL button to engage the second motor in the front wheel.
Note: It’s good practice to press the SINGLE / DUAL button when riding and in motion.
Avoid starting in dual motor mode from a standstill.
Please find throttle settings at evolvrides.com

Battery Safety

Only use the original charger that was supplied with your product to charge the lithium-ion battery. The use of a third-party charger could cause serious damage to the battery and can cause a fire.
To prevent overcharging, unplug the charger once the charger light indicates the battery is fully charged. Do not charge the scooter overnight. Instead, resume charging when you are available to unplug the charger once the battery is fully charged.
Do not leave the lithium-ion battery exposed to direct sunlight or high temperatures. Do not store it in wet places. Always store it in dry places.
Charge lithium-ion batteries in dry, open, and well-ventilated places. Do not charge the battery near flammable goods.
In the winter, keep the scooter stored inside, away from extreme temperatures.
Do not let the battery run late. The scooter must have at least a 20% charge on it at all times. Please see page 11 of the user manual for storage instructions.
If the battery protection circuit is damaged, the battery may emit an unusual smell. Contact your authorized service center immediately for technical support.
Do not reverse the polarity on a battery and short-circuit. Exposing the battery to excessive shock can result in an explosion of the battery.
Do not attempt stunts or jumps on the product. Exposing a battery pack to excessive shock can result in a battery ire. If in an accident contact your service center to ensure that the battery is not compromised.
Connecting the charger when the product is waterlogged will run the risk of an electric shock and possible ire. Do not charge the battery, and contact your service center.
Do not disassemble or incinerate the lithium-ion battery. To safely dispose of the lithium-ion battery, label it as industrial waste and be careful of a short-circuit occurring in terminals.
If the battery requires replacement after long-term use, always replace it with one that is purchased from an authorized dealer.
Do not use the battery if it leaks or gives off an odor. Avoid charging the battery without proper care.
Depending on the model, riding conditions, and rider’s weight, the range will vary on a full charge. Please note that batteries operate optimally at around 25 degrees Celsius. In colder weather, it is normal for your scooter to experience a shorter than normal range on a full charge.
When the scooter needs to be stored for a long period of time, make sure the scooter has at least a 20% charge at all times.
If a product with a lithium-ion battery overheats and there is smoke or ignition, you should stop charging or using it immediately. Move the product outdoors and use fire extinguisher to diffuse it. Do not spray or immerse the product in water to diffuse the ire.

How to Charge

EVOLV Corsa Electric Scooter - figure 6

Battery Pack inside Electric Vehicle

Always plug the charger into a household outlet before connecting to the scooter, to safely start charging. Sparks may occur due to the voltage difference when connecting the connector to the charging port, but this is normal.
The charging port is located on the left side of the deck. Open the charging port cover to connect the charger to the scooter.
LED charging status indicator on the power brick.
Red: Charging
Green: Fully charged

CAUTION:

We recommend that you always use the original charger. Performance and safety may be compromised when using a different charger.
Charger failure may cause fiire while charging.
Do not leave your scooter charging unattended.
After unplugging the charger, charging connectors may be hot.

EVOLV Corsa Electric Scooter - figure 7

Battery Pack removed from Electric Vehicle

Unlock the deck cover with your pin code. Turn the pin code dial and lift the deck cover.
Lift the deck up to reveal two charging ports. The charger can be plugged into the battery pack as is.
Unplug the main power cord from the battery pack and lift the pack out. Set aside the battery pack to be charged.
Set battery pack back into electric vehicle when finished charging. Plug the main power cord back into the battery pack. Close the deck and turn the pin code dial to lock it.

Safety & Cleaning Tips

To prevent injury, wear safety gear such as comfortable shoes, helmets, and knee, and elbow padding.
The scooter is not waterproof. Never use it in the rain or snow. Do not use it if the road is wet or icy. Water damage is not covered by the warranty.
When turning left and right, make sure that there are no obstacles and then turn slowly, keeping a wide turning radius.
Before riding at night, check the position of the headlights and the state of the taillights by depressing the brake lever.
Operating age of 16 years old and over is strongly recommended.
When turning, slow down to prevent the rear tire from slipping.

Cleaning
To clean the scooter, wipe or scrub with a damp cloth. Do not use a hose to spray it with water.
Note: Make sure the electric scooter is powered off and the cover of the charging port is closed when cleaning. Ensure there is no water penetration by using a damp cloth to clean instead of spraying with water.

Storage
During the winter months store scooter indoors in a cool, dry place, and away from extreme temperatures. Do not let the battery run lat. The scooter must have at least 20% charge on it at all times.

Product Specification

Product Name	EVOLV Corsa
Dual Motors	Dual 60V 1,200Watt Nominal per Motor
Max Speed	70 km/h / 44 mph
Range	55 – 60 km / 34 – 37 mi. (Under Ideal Conditions)

Limited Warranty

BY USING YOUR EVOLV Rides ELECTRIC SCOOTER YOU AGREE TO THIS LIMITED WARRANTY. PLEASE READ THIS LIMITED WARRANTY CAREFULLY. IF YOU DO NOT ACCEPT THE TERMS OF THIS LIMITED WARRANTY, DO NOT USE YOUR EVOLV Rides ELECTRIC SCOOTER. RETURN IT UNUSED FOR A REFUND.
To benefit from the limited warranty, the customer is advised to read EVOLV Rides (“EVOLV”) Limited Warranty terms together with the “important” and “care and maintenance” sections provided in the user manual. This limited warranty applies to the extent permitted by law and unless restricted or prohibited by law.

Limited Warranty Details

EVOLV warrants that EVOLV scooter products (“Products” or “Product”) are free from defects in materials and workmanship, according to the following terms and conditions:
This Limited Warranty extends to the original purchaser (name listed on the shipping address) of the Product only, during the first twelve (12) months or first 3000 km, whichever comes first, beginning on the date the purchaser received the Product (“Warranty Period”). An original purchase receipt is required to proceed with warranty repairs.
This Limited Warranty covers the following component parts (“Components”) of the Product only, during the Warranty Period:
• Hub motor;
• Battery packs;
• Controller;
• Throttle and battery indicator unit;
• Charger unit;
• Scooter frame;
• Scooter stem;
• LED lights; and
• Electrical wiring and components.
The following components are covered only if defects are reported within the irst 30 days or 10 KM of use (whichever comes irst):
• Rims;
• Brake calipers;
• Brake discs;
• Kickstands; and
• Forks
During the Warranty Period, EVOLV or its authorized service centers will repair or replace, at EVOLV’s SOLE DISCRETION, any defective Components with new or factory rebuilt replacement items, and return the Products to the customer in working condition, provided that the terms and conditions of this Limited Warranty are met. All defective Products or Components that have been replaced shall become the properties of EVOLV.
Products and/or components that have been repaired or replaced pursuant to the paragraph above will be covered by this Limited Warranty for the balance of the Warranty Period.
This Limited Warranty will only be effective when presented together, to either EVOLV or its authorized centers, with proof of date and place of purchase of Products such as the purchase receipt.

What this Limited Warranty does not cover:

Normal wear and tear of any covered component.
Products used for commercial purpose(s) including but not limited to leasing/hiring, use in competitions, etc
Any logistical costs of returning the Product to EVOLV or its authorized service centers for servicing or the cost of returning the Product to the customer after servicing.
Defects or damages resulting from the use of the Product(s) other than its normal and customary manner as stated in the user manuals accompanying the Products.
Battery failures resulting from water damage (including exposure to moisture or dampness), improper charging, power surges, aftermarket chargers, lack of proper winter storage, seals of the battery enclosure or cells being broken or tampered with, and/or the battery was used in equipment other than its intended use;
Defects or damages from improper storage, exposure to moisture or dampness, modifications, connections, misuse (including but not limited to exceeding the manufacturer’s published weight limit), neglect, abuse, accident, alteration, improper installation, or other acts which are not the fault of EVOLV, including damage caused by dropping, blown fuses, spills of food or liquid.
Loss of screws or stripped screws due to over forcing.
Unauthorized service center repairs.
Product rusting, blemishes, and/or loss of color due to sun exposure and usage.
Defects or malfunctions of the product not notified by the customer during the Warranty Period.
Any orders that have received a chargeback.
Products that have had their serial numbers removed or tampered with.

Disclaimer:
The customer understands the risk of serious injury or death in the operation of such products and shall agree to take the necessary precautions and exercise good judgment to avoid hazards and dangerous situations which may result in serious injury or death.

The customer shall agree to indemnify and hold harmless EVOLV from all injuries or death arising from the operation of the product.
The use of safety and protective gear such as bicycle helmets is strongly encouraged. And so is the use of Good Judgement.
The customer is advised to take the following precautions:
• Do not ride on wet ground or in heavy rain;
• Take corners slowly and look out for pedestrians;
• Avoid potholes, curbs, and debris on the ground;
• Keep tires pumped to the specific pressure;
• Dismount in places with heavy human traffic and push the scooter manually;
• Service the product every 3 months on regular usage, 6 months for nonfrequent usage;
• Do not use products on public roads and respect local road regulations.

How to request service under this limited warranty:
To obtain performance of EVOLV to repair and/or replace the Product or its Components under this Limited Warranty, the customer must, during the Warranty Period:

Bring proof of purchase and the Product to EVOLV or its authorized centers.
Submit a service ticket to EVOLV or its authorized centers, along with a photo or video showing the claimed defect.
The average repair time will depend on the service center. This warranty does not cover the shipping costs associated with the transportation of the scooter to and from a service center and does not cover costs associated with return shipping or pick-up and delivery service.

EVOLV Rides
www.evolvrides.com