Qlima WDZ510 Wet and Dry Vacuum Cleaner User Manual

: June 5, 2024
: Qlima

Table of Contents

WDZ 510 – WDZ 520 – WDZ 530
Documents / Resources
- Read User Manual Online (PDF format)
- Download This Manual (PDF format)

WDZ 510 – WDZ 520 – WDZ 530

OPERATING MANUAL

The features described in this manual are published with reservation to modifications.

P 1: WDZ510

| P 2: WDZ 520 – WDZ 530

---|---

P3a WDZ510, WDZ520

| P3b WDZ530

| P4a

---|---|---
P4b

| P5a

| P5b

P5c

| P5d

Barrel
Wheels
Air inlet
Barrel lock
On/Off Switch
Handle
Top cover
Accessories storage
Auxiliary power socket (ASZ530 only)
Hose
Floor brush
Crevice nozzle
Round brush
Blower outlet
A Non Woven filter
B Hepa Filter
C Sponge filter
D Flexible hose

P6

| P7a

| P7b WDZ530

---|---|---
P7b WDZ510, WDZ520

| P7c WDZ510, WDZ520

| P7d WDZ510, WDZ520 & WDZ 530

P7e

| P8

| P9

P10

| P11

| P12

P13 WDZ503 P14 WDZ530 P15 WDZ530

P16 P17 P18

P19

1. DIRECTIONS FOR USE

Read this user manual carefully before using the appliance and keep it for future reference. Install this device only when it complies with local/ national legislation, ordinances and standards.
The device is designed for indoor use only. It is intended to be used as (1) a wet and dry vacuum cleaner and (2) as a blower for leaves and small dust Only to be used as described in normal household conditions. Never vacuum places where there is risk of vacuuming hot dust or residue hotter than 50 °C.
After unpacking, check the appliance for any damages. When in doubt, do not use the appliance, but contact customer service at your local dealer’s. Keep the packaging materials (plastic bags, etc.) away from children, as they may cause hazardous situations to children.
No modifications to the safety system are allowed.
This appliance is constructed in conformity with relevant texts in the EN 60335 standard wherever applicable.

WARNINGS

Read the Directions for Use before using the appliance. The safety of this appliance is guaranteed only by its correct usage in accordance with these instructions, therefore it is recommended that they are retained for future reference.
Only use the device for its intended purpose. Other usage may lead to short circuits, burns, electroshocks, lamp explosion, crash, etc.
Install the appliance only if it complies with local regulations, laws and standards;
NEVER point the hose, the tube or any other accessory at eyes or ears nor put it in a mouth when it is connected to the vacuum cleaner and the vacuum cleaner is switched on!
Make sure that the available voltage does not exceed the voltage stated in the specifications of this manual.
Check if the voltage indicated on the type plate corresponds to the local mains voltage before you connect the appliance.
The appliance is suitable for mains voltages ranging from ~230 V.
Always make sure that you actually see the appliance when you want to switch it on. Never use things like a timer, programmer or any other device (including Internet apps) that switches on the appliance automatically as this may cause fire!
Use the appliance according to the instructions as described in this manual.
This appliance is manufactured according to CE safety standards. Nevertheless, as with any other electrical device, care must be taken;
RISK OF FIRE Never use the appliance in places where inflammable and/or harmful Gases, prod-ucts or fumes may be present (e.g. exhaust Gases, paint fumes, curtains, paper, clothes)
Do not use any extension cords or multi-socket adapters.
For safety reasons take care when children or animals are in the proximity of the appliance, as with any other electrical device.
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
If the supply cord is damaged, it shall be replaced by the manufacturer, its service agent or similarly qualified persons in order to avoid a hazard.
Children should be supervised to ensure that they do not play with the appliance.
In order to avoid overheating, do not cover the device.
Do not insert objects into the openings of the device.
This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved.
Cleaning and user maintenance shall not be made by children without supervision.
Children of less than 3 years should be kept away unless continuously supervised.
Children aged from 3 years and less than 8 years shall only switch on/off the appliance provided that it has been placed or installed in its intended normal operating position and they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved.
Children aged from 3 years and less than 8 years shall not plug in, regulate and clean the appliance or perform user maintenance.

Disconnect from mains during installation, maintenance and cleaning and/or filter replacement.

Do not remove the plug from the socket by pulling the power cord.
Only have the appliance repaired by the manufacturer or its authorized service agent
Only use filters supplied by the manufacturer or its authorized service agent.
Do not vacuum soot or printer toner
Do not use the appliance to vacuum: inflammable and/or explosive materials, corrosive materials, hot and/or burning ash, matches, cigarettes.
Do not open the motor compartment of the appliance. DANGER ! Live electrical parts!
Empty and clean the appliance before vacuuming to avoid the collection of materials that could pose a fire hazard inside the vacuum cleaner.

If you fail to consult and/or follow up the rules, instructions and explanation, the warranty will no longer be valid, and the manufacturer will no longer deal with any damage to the appliance and/or your environment under the warranty.

2. INSTALLATION

See P1, P2 on page 1:

Take out the appliance and accessories from the packing box, check the accessories and whether the appliance enclosure is well-found or not. (picture 1 and 2).
Click the wheels in the dedicated holes (see P6)
Push the flexible hose in the air inlet opening (see P7a) and turn clock-wise to lock the hose.
Insert the other end (= the handle) of the flexible hose into the rigid tube see P7b.
Depending on required job: choose the correct accessory and connect the rigid tube and the accessory together.
• Crevice nozzle (Picture 4a): ideal for narrow spaces
• Round Brush (picture 4b) : ideal for cleaning furniture or counter top
• Floor brush (Picture 3a and 3b): ideal for cleaning the floor
Loosen the lock and take the top cover 7 from the container barrel 1.

FOR VACUUMING DRY DUST:

Attach the filter (WDZ510: item A / WDZ520 item A / WDZ530 item A+B)
P8: shows how to mount the non woven filter (A)
P9: shows the compartment where the HEPA filter (B) or Sponge filter (C) is to be mounted
P10: shows how the HEPA filter (B) is mounted

IMPORTANT:
ALWAYS mount the filters as per this instruction. NOT mounting the filters when suctioning (even for a very short period) will cause dust and other particles to enter the motor area of your vacuum cleaner. This will cause almost immediate loss of suction power, this damage is unrepairable damage which is NOT covered by the warranty!

Big amounts of dust sometimes can cause the filter to be blocked completely and all suction power will be lost. In this case:

Unmount the filters
Clean the filter (outdoors!) by tapping the rigid parts carefully to a rigid surface
Mount the filters again
If step 1 to 3 do not help: the filters need replacement — check for replacement parts at your local store.

FOR VACUUMING LIQUIDS:

Mount the sponge filter “C” to the compartment as shown in P9.
P9: shows the compartment where the HEPA filter (B) or Sponge filter (C) is to be mounted
Do NOT mount the non woven filter (A) nor the HEPA filter (B). Filters A and B should only be mounted when vacuuming dry dust!

ALL MODELS:

Mount the top cover 7.
Close the locks
Insert the power cord plug in the wall socket.

The Vacuum cleaner is now ready to use.

Press the on/off switch 5 to switch it on.

Blowing function:
Put hose end into the blower outlet connection 14. The air will now blow through the nozzle.

Take care when using blower function. Dust and other residue are blown away in an uncontrollable way!

3. USAGE

Turn the machine on or off with on/off switch 5

WDZ 530 ONLY:

WDZ530 has a special on/off I – 0 – II switch (see picture: P13)
Switch on the WDZ530: Press the on/off button to I or II.
• I = machine is ON, auxiliary electrical power socket is ON.
• 0 = vacuuming is OFF and power socket is ON
• II = Vacuuming is OFF and power socket is ON.
– Switch on the tool: vacuuming automatically will start in 1 second
– Switch off the tool: the vacuuming will automatically stop in 10 seconds
– Switch tool back on: vacuuming automatically will start in 1 second
– Switch off the tool again: the vacuuming will automatically stop in 10 seconds
– Etc etc

USAGE ALL MODELS:

When the container is full:
• Empty the container and clean it thoroughly
When it feels difficult to vacuum more dust, the filter needs to be taken out and cleaned. See P11.
Control suction power by opening-closing the sliding button on the tube handle.

FLOOR BRUSH:
WDZ510/520: are equipped with the standard floor nozzle suitable for wet and dry vacuuming

WDZ530: is equipped with the special QLIMA brush. See Picture 3b. The QLIMA brush can be adopted for hard floor or for soft-/carpet floor by pressing the button on top of the brush.

AUXILIARY POWER SOCKET WDZ530:
The WDZ530 is equipped with an auxiliary electrical power socket with a maximum electrical power of 1800 W.

If your tool is equipped with a special dust outlet connection then the vacuum cleaner hose can be connected to the dust outlet of your tool. In this way the dust will be captured in the most efficient way.
The electrical power for the tool can be taken from the auxiliary electrical power outlet see Picture 14.
Connect a tool (grinder, drill, etc) power cable to the WDZ530 auxiliary power socket.

Maximum power of the connected tool: <1800 Watt (!).

Switch on the WDZ530: Press the on/off button to I or II. See afore mentioned chapter 3. “Usage”.

DRAIN WDZ530:

WDZ530 is equipped with a drain. Picture P15
The drain prevents the heavy lifting of the WDZ530 for emptying.
Open the drain by turning the knob clock-wise. The water will now flow out!
When draining: ALWAYS make sure the water can float away to your preferred place! Preferably ALWAYS drain outdoors.

TIP
When suction power is reduced: carefully tap on the lid or carefully tap container to the floor to possibly remove the blockade.

4. AFTER USAGE

Press the switch 5 to turn off vacuum cleaner.
Pull out plug.
Roll up the power cable.
Disassemble the hose D from the appliance.
Take the top cover 7 from the appliance.
Empty the container body 1 and wash it.
Use rag to dry container body 1.
Take out the filter A, B and/or C, and clean and wash it carefully (see P11)
Dry filter in air before installed on vacuum cleaner.
Reinstall filter A, B and/or C (if applicable)
Replace the top cover 7 and fixate the locks
Carefully clean the used accessories with hand warm water. After cleaning: dry it by air.

TIP
WDZ530 and WDZ520 are equipped with cable bracket for easy storage of the power cable. See P16

All WDZ vacuum cleaners are equipped with special ‘easy accessory storage function’. For WDZ 520/530: see Picture 17, storage recess is just above the wheel. For WDZ510: provided with identical shaped storage function at the top lid

5. MAINTENANCE

The container barrel 1 and outer shell of top cover 7 need to be cleaned frequently.

Never use a detergent and/or cleaning agent as this might result in damages
The dirty container should wash with clear water only.
Wash the filter with clear water only.
If the appliance working unsatisfactory, it is usually resulted from a jam of hose ID or conjunction of pipes, filters or accessories. In that case, please clean the parts concerned.

6. CONSUMABLES AND SPARE PARTS

New filters (A / B) can be obtained through your dealer. Check www.qlima.com for more information.
Only use spare parts and/or consumables supplied by the manufacturer or its authorised service agent

7. TROUBLESHOOTING

Review these tips first and you may not need to call for service.

DEVICE WILL NOT START

Possible cause| What to do
Cord is not plugged into an electrical outlet.| Make sure plug is fully inserted into the wall outlet.
A fuse in your home may be blown or the circuit in your home may be breaker tripped.| Replace fuse or reset circuit breaker.
Not switched on.| Switch on
VACUUMING NOT AS STRONG AS NORMAL
Possible cause| What to do
Full barrel| Empty barrel
Full filter| Clean the filter (see relevant paragraph)
Exchange the filter (filter is a consumable)

TECHNICAL DATA AND PRODUCT FICHE

| QLIMA WDZ510| QLIMA WDZ520| QLIMA WDZ530
---|---|---|---
Power input (Watt)| 1000| 1200| 1500
Power supply| 220-240 V~ / 50 Hz / 1 Ph
IP Rating| IPX4 (splash water proof)
Sound pressure (dB(A)) (*)| 74| 78| 78
Tank volume (liter)| 10| 20| 30
Weight (kg)| 5,0| 5,5| 6,0
Vacuum (kPa)| 16| 20| 21

(*) for reference only

8. STORAGE INSTRUCTIONS

If children play with the appliance, make sure that dangerous parts are removed. Never dispose of non-biodegradable products in the environment, but dispose of them in accordance with current national legislation.

9. GUARANTEE CONDITIONS

The appliance is supplied with a 24-month guarantee, commencing on the date of purchase. All material and manufacturing defects will be repaired or replaced free of charge within this period. The following rules apply:

We expressly refuse all further damage claims, including claims for collateral and/or consequential damage. Repairs to or replacement of components within the guarantee period will not result in an extension of the guarantee.
The guarantee is invalidated if any modifications have been made, non-genuine parts are fitted or repairs are carried out by third parties.
Components subject to normal wear, such as filters, batteries, lamps and heating elements are not covered by the guarantee.
The guarantee is valid only when you present the original, dated purchase invoice and if no modifications have been made to it.
The guarantee is invalid for damage caused by neglect and/or by actions that deviate from those in this instruction booklet.
Transportation costs and the risks involved during the transportation of the appliance or components of the appliance shall always be for the account of the purchaser
Damage caused by not using suitable spare parts is not covered by the guarantee.

To prevent unnecessary expense, we recommend that you always first carefully consult the instructions for use. Take the appliance to your dealer for repairs if these instructions do not provide a solution. www.qlima.com.

10. ENVIRONMENTAL PROTECTION

Do not dispose of electrical appliances as unsorted municipal waste, use separate collection facilities.
Contact your local government for information regarding the collection systems available. If electrical appliances are disposed of in landfills or dumps, hazardous substances can leak into the groundwater and get into the food chain, damaging your health and well-being. When replacing old appliances with new once, the retailer is legally obligated to take back your old appliance for disposal at least for free of charge.

Distributed in Europe by PVG Holding B.V.

If you need information or if you have a problem, please visit the our website (www.qlima.com) or contact our sales support (T: +31 412 694 694).

PVG Holding BV — Kanaalstraat 12 C – 5347 KM Oss — the Netherlands
P.O. Box 96 — 5340 AB Oss — the Netherlands

Documents / Resources

| Qlima WDZ510 Wet and Dry Vacuum Cleaner [pdf] User Manual
WDZ510, WDZ520, WDZ530, Wet and Dry Vacuum Cleaner, WDZ510 Wet and Dry Vacuum Cleaner
---|---