KENWOOD CH580 Quad Blade Chopper Instructions

: June 16, 2024
: KENWOOD

Table of Contents

CH580 Quad Blade Chopper
safety
to use your food chopper
care and cleaning
processing guide
service and customer care
Recipes
Documents / Resources

CH580 series
TYPE CH58
instructions

CH580 Quad Blade Chopper

KENWOOD CH580 Quad Blade Chopper - Figure 1

safety

Read these instructions carefully and retain for future reference.
Remove all packaging and any labels.
If the plug or cord is damaged it must, for safety reasons, be replaced by Kenwood or an authorised Kenwood repairer in order to avoid a hazard.
The blades are very sharp, handle with care.
Always hold by the finger grip © at the top, away from the cutting edge, both when handling and cleaning.
Switch off and unplug:
○ before fitting or removing parts
○ after use
○ before cleaning.
Always wait for the blades to completely stop before removing the power unit from the bowl.
Always remove the knife blade(s) before emptying or pouring contents from the bowl.
Never use a damaged appliance. Get It checked or repaired: see ‘service and customer care’.
Never let the power unit, cord or plug get wet.
Don’t let excess cord hang over the edge of a table or worktop or touch hot surfaces.
Never leave the appliance on unattended. e Misuse of your food chopper can result in injury.
Never use an unauthorised attachment.
Children should be supervised to ensure that they do not play with the appliance.
Appliances can be used by persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and if they understand the hazards involved.
This appliance shall not be used by children. Keep the appliance and its cord out of reach of children.
Only use the appliance for its intended domestic use. Kenwood will not accept any liability if the appliance is subject to improper use, or failure to comply with these instructions.

before plugging in

Make sure your electricity supply is the same as the one shown on the underside of the appliance.

Important – Plug and Fuse Information

The wires in the cord are coloured as follows:
Blue = Neutral
Brown = Live.
If the plug supplied with your appliance has a fuse fitted it is rated 3A. If the fuse fails it must be replaced with one of the same rating.

Note:

For non-rewireable plugs the fuse cover MUST be refitted when replacing the fuse. If the fuse cover is lost then the plug must not be used until a replacement can be obtained. The correct fuse cover is identified by colour and a replacement may be obtained from your Kenwood Authorised Repairer (see Service).
If a non-rewireable plug is cut off it must be DESTROYED IMMEDIATELY. An electric shock hazard may arise if an unwanted non-rewireable plug is inadvertently inserted into a 13A socket outlet.
This appliance conforms to EC Regulation 1935/2004 on materials and articles intended to come into contact with food.

before using for the first time

Remove all packaging and any labels including the plastic blade covers from the knife blade. Take care the blades are very sharp. These covers should be discarded as they are to protect the blade during manufacture and transit only.
Wash the parts: see ‘cleaning’.

key

speed selector
power unit
cord grip
cover
upper knife blade
finger grip
lower knife blade
bowl
locating pin
bowl base
mayonnaise dripper (if supplied)

to use your food chopper

The knife blade unit comes in 2 parts, a lower and an upper blade.

For coarser chopping use the lower blade on its own.
For finer chopping or pureeing use both blades together. This will also give a faster result. To use both blades fit the upper blade onto the lower blade and turn anti-clockwise to locate in place 1. Take care as the blades are sharp.

Note: After processing food, the upper blade may disengage from the lower blade. This is normal as the blade assembly is designed to be loose fitting to ease separation after use.

Put the bowl base on the bottom of the bowl. (This stops the bowl sliding on the work top).
Place the unit on a clean, flat surface.
Fit the desired knife blade assembly into the bowl over the locating pin 2.
Cut the food into suitably sized pieces and place in the bowl. Larger pieces of food should be cut into approximately 1 to 2 cm pieces.
Fit the cover and turn clockwise to lock into place 3.
Place the power unit onto the cover.
Connect to the power supply and press down on the speed selector to select the desired speed. When operating the power unit, hold it firmly on the cover and bowl.
● Press the speed selector lightly to obtain speed 1.
● Press the speed selector firmly to obtain speed 2.
● Alternatively the speed selector may be pressed down for short periods of time to produce a pulsing action. This can be used to avoid over processing food.
Operate the food chopper until the desired result is achieved.
Switch off and unplug after use.
Reverse the above procedure to dismantle the unit.

important

If preparing food for babies or young children, always check that the ingredients are thoroughly processed before feeding.
Do not run the food chopper continuously for longer than 10 seconds. Leave to cool for 1 minute in between each 10 second operation.
Do not operate the food chopper if the bowl is empty.
Never operate the food chopper with the bowl filled with liquid.
Always allow hot food to cool before processing.

hints

If the chopper labours, remove some of the mixture and continue processing in several batches, otherwise you may strain the motor.
Remember that chopping hard foods such as coffee beans, spices, chocolate or ice will wear the knife blades faster.
Beware of over processing some ingredients. Stop and check the consistency frequently.
Various spices such as cloves, dill and cumin seeds can have an adverse effect on the plastic of your food chopper.
To ensure even processing, stop and scrape down any food from the side of the bowl with a plastic spatula.
The best results are obtained by chopping small quantities at one time.
Cut larger pieces of food into 1-2cm pieces. A large load or large pieces may cause uneven results.
Before chopping nuts, herbs, breadcrumbs etc, ensure that both the food and the blade, bowl and cover are thoroughly dry.

to use the mayonnaise dripper

(if supplied)
Please refer to the mayonnaise recipe in the recipe section for information on how to assemble and use the mayonnaise dripper.

care and cleaning

Always switch off and unplug before cleaning.
Handle the blades with care – they are extremely sharp.
Some foods may discolour the plastic. This is perfectly normal and won’t harm the plastic or affect the flavour of your food. Rub with a cloth dipped in vegetable oil to remove the discolouration.

power unit

Wipe with a damp cloth, then dry.
Do not immerse the power unit in water.
Wrap excess cord around the power unit, securing the cord in the cord grip 3.

cover/bowl/bowl base/knife blade
Always separate the upper knife blade from the lower knife blade before cleaning. Take care the blades are very sharp.

Wash by hand, then dry.
Alternatively they can be washed on the top rack of your dishwasher.
The parts are unsuitable for use in a Steam Steriliser. Instead use a sterilising solution in accordance with the sterilising solutions manufacturer’s instructions.

processing guide

Do not operate your appliance for longer than the times specified below without a rest period. Processing continuously for longer periods can damage your appliance.

food	maximum capacity	preparation	maximum time/speed
Meat	150g	Remove bones, fat and gristle. Cut into 1-2 cm cubes.	5-10

service and customer care

If you need help with:

using your appliance or
servicing or repairs (in or out of guarantee)
**** call Kenwood customer care on 023 9239 2333 or visit www.kenwoodworld.com. Have your model number (e.g. CH580) and date code (5 digit code e.g. 13L35) ready. They are on the underside of your appliance.
spares and attachments
** call 0844 557 3653.
other countries**
If you experience any problems with the operation of your appliance, before requesting assistance visit www.kenwoodworld.com.
Please note that your product is covered by a warranty, which complies with all legal provisions concerning any existing warranty and consumer rights in the country where the product was purchased.
If your Kenwood product malfunctions or you find any defects, please send it or bring it to an authorised KENWOOD Service Centre. To find up to date details of your nearest authorised KENWOOD Service centre visit www.kenwoodworld.com or the website specific to your Country.
Made in China.

guarantee (UK only)
If your food chopper goes wrong within one year from the date you bought it, we will repair it (or replace it if necessary) free of charge provided:

you have not misused, neglected or damaged it;
it has not been modified (unless by Kenwood);
it is not second-hand;
it has not been used commercially;
you have not fitted a plug incorrectly; and
you supply your receipt to show when you bought it.

This guarantee does not affect your statutory rights.

IMPORTANT INFORMATION FOR CORRECT DISPOSAL OF THE PRODUCT IN ACCORDANCE WITH THE EUROPEAN DIRECTIVE ON WASTE ELECTRICAL AND ELECTRONIC EQUIPMENT (WEEE)

At the end of its working life, the product must not be disposed of as urban waste.
It must be taken to a special local authority differentiated waste collection centre or to a dealer providing this service.
Disposing of a household appliance separately avoids possible negative consequences for the environment and health deriving from inappropriate disposal and enables the constituent materials to be recovered to obtain significant savings in energy and resources. As a reminder of the need to dispose of household appliances separately, the product is marked with a crossed-out wheeled dustbin.

Recipes

Fit both blades to the bowl (unless stated otherwise) when carrying out the following recipes.

Guacomole

1⁄2 small onion
1 tomato, skinned and seeds removed
1 small green chilli, deseeded
1⁄2 garlic clove, crushed few parsley sprigs
1 ripe avocado
15ml lemon juice
salt and pepper

Cut the onion, tomato and chilli into pieces approximately 1-2 cm in size. Place in the bowl with the garlic and parsley and pulse on a high speed until finely chopped. Transfer to a serving bowl. Remove the skin and stone from the avocado and cut the flesh into 1-2cm cubes. Place into the bowl with the lemon juice and pulse on a high speed until a fairly fine puree is achieved. Combine the avocado puree with the tomato mix and season to taste.

Prune marinade

100g small soft prunes
200g runny honey
125ml water (at room temperature))
Fit both blades to the bowl and add the prunes to the bowl and then the runny honey.
Refrigerate the chopper bowl with ingredients for 24 hours at 3°C.
Add 125ml water (Room temperature). Process on Speed 2 for 5 seconds.

Tomato salsa

15g fresh coriander
1 small red onion
1 green chilli, deseeded
4 firm tomatoes, skinned and seeds removed
juice of 1 lime
salt and pepper
Place the coriander into the bowl and process until finely chopped.
Transfer to a serving bowl. Cut the onion and chilli into pieces approximately 1-2 cm in size then place in the bowl and pulse on a high speed until finely chopped.
Add to the coriander. Lastly cut the tomato into pieces approximately 2 cm in size then coarsely chop on a high speed. Add to the coriander mix and combine with the lime juice, salt and pepper.

Strawberry slushie

4-5 ice cubes
8 strawberries, hulls removed and cut in half
10ml caster sugar, approximate
Place the ice cubes and strawberries into the bowl and process on a high speed pulse until the ice is coarsely chopped. Add the sugar and continue pulsing until incorporated.
Transfer to a glass and serve immediately.

Mayonnaise (using the mayonnaise dripper when supplied)

125ml olive oil
1 whole egg
2 drops lemon juice
salt and pepper

Fit the lower knife blade into the bowl. Add the egg, lemon juice and seasoning. Fit the mayonnaise dripper 4 , then add the oil into its recess. Quickly fit the cover and power unit and process on speed 2 until most of the oil has been dispensed and the mayonnaise is thick. Use as required.

Note: Some oil will remain in the mayonnaise dripper after use, this is normal.

Kenwood Ltd
New Lane
Havant
Hampshire
PO9 2NH
kenwoodworld.com
© Copyright 2019 Kenwood Limited. All rights reserved
****40238/5