DOMETIC D21 SBC Cooker Outdoor Instruction Manual

DOMETIC D21 SBC Cooker Outdoor

WARNING
Cancer and Reproductive Harm www.P65Warnings.ca.gov

WARNING: If the information in this manual is not followed exactly, a fire or explosion may result, causing property damage, personal injury, or death.

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
• WHAT TO DO IF YOU SMELL GAS
  • Do not try to light any appliance.
  • Do not touch any electrical switch.
  • Do not use any phone in your vehicle.
  • Clear the vehicle of all occupants.
  • Turn off the gas supply tank valve(s) or main gas supply.
  • Immediately call your gas supplier for instructions.
  • If you cannot reach your gas supplier, call the fire department.
• Have the gas system checked and leakage source corrected by a qualified installer, service agency, manufacturer or dealer, or the gas supplier.

Copyright
2023 Dometic Group. The visual appearance of the contents of this manual is protected by copyright and design law. The underlying technical design and the products contained herein may be protected by design, patent or be patent pending. The trademarks mentioned in this manual belong to Dometic Sweden AB. All rights are reserved.

Service Center & Dealer Locations

Visit: www.dometic.com

Please read these instructions carefully and follow all instructions, guidelines, and warnings included in this product manual to ensure that you install, use, and maintain the product properly at all times. These instructions MUST stay with this product. By using the product, you hereby confirm that you have read all instructions, guidelines, and warnings carefully and that you understand and agree to abide by the terms and conditions as set forth herein. You agree to use this product only for the intended purpose and application and under the instructions, guidelines, and warnings as outlined in this product manual as well as under all applicable laws and regulations. A failure to read and follow the instructions and warnings set forth herein may result in an injury to yourself and others, damage to your product, or damage to other property in the vicinity. This product manual, including the instructions, guidelines, warnings, and related documentation, may be subject to changes and updates. For up-to-date product information, please visit www.dometic.com.

Explanation of symbols and safety instructions

This manual has safety information and instructions to help you eliminate or reduce the risk of accidents and injuries.

Recognize safety information
This is the safety alert symbol. It is used to alert you to potential physical injury hazards. Obey allsafety messages that follow this symbol to avoid possible injury or death.

Understand signal words
A signal word will identify safety messages and property damage messages and also will indicate the degree or level of hazard seriousness.

WARNING
Indicates a hazardous situation that, if not avoided, could result in death or serious injury.

NOTICE: Used to address practices not related to physical injury.

• Indicates additional information that is not related to physical injury.

Supplemental directives
To reduce the risk of accidents and injuries, please observe the following directives before proceeding to install and operate this appliance:

• Read and follow all safety information and instructions.
• Read and understand these instructions before installing and operating this product.
• The installation must comply with all applicable local or national codes, including the latest edition of the following standards:

U.S.A.

• ANSI Z21.89-2017, Outdoor Cooking Specialty Gas Appliances
• ANSI/NFPA1192, Recreational Vehicles Code

Canada

• CSA 1.18-2017, Outdoor Cooking Specialty Gas Appliances
• CSA Z240 RV Series, Recreational Vehicles

General safety messages

WARNING: Burn, fire, explosion, and/or carbon monoxide hazard. Failure to obey the following warnings could result in death or serious injury:

• This appliance is not intended for commercial use.
• This appliance is not intended to be installed in or on a boat.
• This appliance is for outdoor installation and use only.
• This appliance must use liquid propane (LP) gas only from a 20 lb (9 kg) LP gas supply cylinder. The LP gas supply cylinder must be constructed and marked in accordance with the specifications for LP gas supply cylinders, U.S. Department of Transportation (DOT) or the Standard for Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods, CAN/CSA-B339.
• This appliance must be installed by a qualified service technician. Improper installation, adjustment, service, or maintenance can cause injury, property damage, or death. Refer to this manual. For assistance or additional information, consult a qualified installer, service agency, manufacturer, or gas supplier.
• Do not modify this appliance in any way. Modification can be extremely hazardous.
• Do not install adjacent to another cooking appliance.
• Do not store or use gasoline or other flammable vapours and liquids in the vicinity of this or any other appliance.
• Shut off all the gas appliances and pilot lights when refuelling gasoline or LP gas supply cylinders.
• Gas flames consume oxygen, which must be replaced to ensure proper combustion. Failure to provide fresh air during combustion can lead to carbon monoxide poisoning.
• When this appliance is in use, the lid must be fully open and in the upright position.
• Do not use this appliance in a garage, building, breezeway, any other enclosed area.
• Do not use this appliance under extended awnings.
• Do not use this appliance under an overhead unprotected combustible construction.
• Do not use this appliance if the appliance’s back or sides are within 24 in. (609.6 mm) of combustible materials.
• Follow all gas leak checking procedures in this manual prior to operation.
• Do not attempt to disconnect the LP gas or any LP gas fitting while this appliance is in operation.
• Do not move the grill when operating or while the grill is hot. Wait for the grill to cool before closing the lid or sink cover.
• LP gas supply cylinders must be stored outdoors, out of the reach of children, and must not be stored in any building, garage, or other enclosed structure.
• Never allow children to operate this appliance.
• Do not lean over the appliance, or place hands or fingers on the top of the appliance.
• Use heat-resistant mitts or gloves when operating this appliance.
• Do not use the cover as a griddle or cooking surface.
• Should a grease fire occur, turn off all burners, and stay away from the appliance until the fire is out.
• Do not use charcoal briquettes, lava rocks, or lighter fluid in this appliance.
• While this appliance is not in use, place it under a cover to protect it from the weather or other adverse elements.
• While this appliance is not in use, the LP gas must be turned off at the LP gas supply, and the LP gas supply cylinder removed from the appliance.
• Storage of this appliance indoors is permissible only if the LP gas supply cylinder is disconnected and removed from the appliance. Never move the appliance with the LP gas supply cylinder installed.
• The use of alcohol, prescription, or non-prescription drugs may impair the ability to properly assemble or safely operate the appliance.
• Use only Dometic replacement parts and components that are specifically approved for use.

NOTICE: The appliance cover must be closed when the vehicle is in motion.

Intended use

The D21 SBC Cooker Outdoor (hereinafter referred to as “cooktop”) is designed and intended for installation and use outside of a recreational vehicle (RV). This cooktop is only suitable for the intended purpose and application in accordance with these instructions. This manual provides information that is necessary for proper installation and operation of the cooktop. Poor installation and/or improper operating or maintenance will result in unsatisfactory performance and a possible failure. The manufacturer accepts no liability for any injury or damage to the product resulting from:

• Incorrect assembly or connection, including excess voltage
• Incorrect maintenance or use of spare parts other than original spare parts provided by the manufacturer
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in this manual Dometic reserves the right to change product appearance and product specifications.

General information

This section describes the installation materials.

• The images used in this document are for reference purposes only. Components and component locations may vary according to specific product models. Measurements may vary ±0.38 in. (10 mm).

Scope of delivery
Dometic recommends that the following tools and materials be used while installing the cooktop.

Preinstallation

This section describes the installation location requirements.

Determining the location

• The minimum distance between the cooktop and the ground must be the height of the hob box or metallic installation stand, plus an additional 11.8 in. (300 mm).
• Position the cooktop so that no combustible material can be placed next to the cooktop sides.

Installation

WARNING: Fire and/or explosion hazard. Failure to obey the following warnings could result in death or serious injury:

• Do not use matches, candles, or other sources of ignition to test fittings and LP gas lines for leaks.
• The LP gas line material between the cooktop and the bottom shield must be rated for a minimum of 300 °F (149 °C) exposure.

Assembling the cooktop

1. Assembling the cooktop
   • Screw
   • Nylon washer
   • Seal gasket
   • Cooktop
   • Hob box
   1. Insert the seal gasket into the edges of the cooktop.
   2. Place the cooktop into the hob box opening so that it rests on top of the seal gasket.
   3. Insert the screws and nylon washers to connect the cooktop to the hob box.
   4. Verify the cooktop is level from side to side and front to rear.
   5. Tighten the screws to secure the cooktop to the hob box using a #2 screwdriver. Do not over tighten.

Connecting the LP gas supply cylinder

Connecting the LP gas

• Cooktop rear view
• LP gas-certified hose
• Quick-connect
• LP gas connector

1. Run the LP gas-certified hose from a 20 lb (9 kg) LP gas supply cylinder to the LP gas connector on the cooktop.
2. Pull back the quick-connect attached to the end of the LP gas-certified hose.
3. Position and release the quick-connect onto the LP gas connector, ensuring the connection is secure.
4. Open the LP gas supply to the cooktop by turning the LP gas shutoff valve on the LP gas supply cylinder counterclockwise.
5. Check for leaks using a non-corrosive leak detection fluid. Leak test pressures in excess of 13.9 in. w.c. (1/2 psi) of air pressure will invalidate the warranty.
6. After confirming there are no leaks, turn off the LP gas supply to the cooktop by turning the LP gas shut-off valve on the LP gas supply cylinder clockwise.

Operation

WARNING: Burn, fire, explosion, and/or carbon monoxide hazard. Failure to obey the following warnings could result in death or serious injury:

• Do not operate the cooktop in excessively windy conditions as this may cause a negative or positive draft. A negative draft caused by air moving across the cooktop may blow out the burner flame or move the flame into the cooktop, and/or cause carbon monoxide buildup.
• Do not use the cooktop for space heating. Doing so may cause the cooktop to overheat.
• Do not heat unopened containers on the cooktop. Doing so may cause the hot contents to explode.
• Do not store flammable materials on, in, or near the cooktop.
• Do not operate the cooktop if it is damaged or not working properly.
• Verify there is a sufficient LP gas supply before attempting to light any burner. Air in the LP gas supply line will significantly delay burner ignition, and a burner may light unexpectedly as the air in the line clears out and is replaced by LP gas. Air may be introduced into the supply line when the vehicle gas bottle is replaced, during servicing of other gas appliances, etc.
• If any burner should extinguish (after initially lighting or due to an accidental blowout), turn all the control knobs clockwise to the Off position and wait 5 minutes before attempting to re-ignite the burner.
• Do not touch the burners, burner grates, or areas near the burners during and after use. Do not let clothing or other flammable materials contact the burners or areas near burners until these areas have had sufficient time to cool.
• Use large enough cooking containers to cover the burner area and contain the cooked food. Doing so will reduce or eliminate heavy splattering or spills that can ignite.
• Be sure that glass cooking utensils are safe for use on the cooktop. Only certain kinds of glass utensils are suitable for surface or burner use without breaking due to sudden changes in temperature.
• Never leave the burners unattended when in use, as pan contents may boil over, resulting in smoke or a grease spill that may ignite.
• Turn the pan handles inward, but not over the other top burners.
• Because grease is flammable, never allow grease to collect around the top burners or on the cooktop surface. Wipe up any grease spills immediately.
• Never use water on grease fires, and never pick up a flaming pan. Smother a flaming pan with a tight-fitting lid or cookie sheet. Extinguish flaming grease outside of the pan with baking soda or a multipurpose dry chemical or foam-type fire extinguisher.
• Use care when lighting a burner by hand as the burner could ignite unexpectedly.
• Do not allow the burner flame to extend beyond the edge of the cooking container.
• The control knobs must be turned to the Off position when not cooking.

This section describes the activities required to operate the cooktop.

Opening the cooktop cover

• Sink shelf cover (RDK1355 only)

• Lid cover (RDK1045 and RDK1355)

1. Lift the sink shelf cover (RDK1355 only).
2. Lift the lid cover.
3. Lift the sides from the circular cuts in each side and rotate the sides out until they can drop down into the pads on the hob box.
4. On both sides, slide the sides out until the tab in each bottom edge drops into the slot in the pads.
5. To lock the lid in place, rotate the latch on the left-hand side clockwise and pull the right-hand side in.

Closing the cooktop cover

1. Rotate the latch on the left-hand side counterclockwise.
2. Push the right-hand side out.
3. From the circular cuts in each side, lift both sides until the sides clear the slots in the pads and the bottom of the lid.
4. Rotate the sides inward. The bottom edge of the sides can rest on the bottom edge of the lid.
5. Swing the sides toward the lid until the sides drop into place behind the fold at the bottom of the lid.
6. Close the lid.
7. Close the sink shelf cover (RDK1355 only).

Preparing the cooktop for use

• Preparing the cooktop for use

1. Rear view of cooktop
2. LP gas shutoff valve
3. LP gas connection
4. Open the cooktop cover.
5. Turn the LP gas shut-off valve counterclockwise to the open position.

Igniting the burner

Igniting the burner

• Burner
• Control knob
• Electronic ignition button

1.  Turn the control knob(s) counterclockwise to the On position to start the flow of LP gas to the cooktop.
2. Immediately press and hold the electronic ignition button until the burner ignites.

Extinguishing the burner

Extinguishing the burner

1. Control knob

Turn the control knob(s) clockwise to the Off position to stop the flow of LP gas to the cooktop.

Maintenance

WARNING: Burn, fire, explosion, and/or carbon monoxide hazard. Failure to obey the following warnings could result in death or serious injury:

• Always ensure the control knobs are in the Off position, the LP gas shutoff valve is closed, and the cooktop is disconnected from the LP gas source before cleaning and/or servicing the cooktop. Maintenance must be performed by a qualified service person only.
• Keep the cooktop area clear of combustible cleaning materials, gasoline, and other flammable vapours and liquids.
• All cooktop surfaces, burner grates, and burners must be cool before cleaning or disassembling the cooktop.

NOTICE: Failure to obey the following instructions could result in damage to the cooktop.

• Clean all the surfaces quickly after spills.
• Use warm soapy water only to clean the grill, hob box, painted surfaces, porcelain surfaces, stainless steel surfaces, and plastic items on the cooktop.
• Do not use gritty or acid-type cleaners. Do not use steel wool or abrasive cleaners, as they will damage the cooktop. Use only non-abrasive plastic scrubbing pads.
• Do not allow foods containing acids (such as lemon juice, tomato juice, or vinegar) to remain on the porcelain or painted surfaces. Acids may remove the glossy finish. Pitting and discolouration will result if spills are allowed to remain for any length of time on stainless steel.
• Do not allow spills to remain on the burner caps as the burner caps could be permanently stained if spills are not cleaned up promptly.

Proper installation and care will help keep the cooktop looking and operating like new. Most cleaning can be performed using normal household items. The maintenance and cleaning instructions provided in this section should be performed as needed, depending on the use of the appliance. Failure to properly maintain the cooktop may void the warranty and could result in unsafe operation. Preventive maintenance is not covered under the warranty.

Changing the ignition switch battery

Changing the ignition switch battery

1. Ignition switch cover
2. AAA battery
3. Ensure the control knobs are in the Off position, the LP gas shutoff valve is closed, and the cooktop is disconnected from the LP gas source.
4. Turning counterclockwise, unscrew the ignition switch cover and set aside.
5. Remove and replace the AAA battery.
6. Dispose of the old battery properly.
7. Reinstall the ignition switch cover.

Cleaning the cooktop

Cleaning the cooktop

• Grill
• Oil
• Hob box

1. Remove the grill from the cooktop.
2. Dry all the surfaces and the hob box.
3. Spray the surfaces with vegetable oil or a similar product to help prevent the surface from rusting during storage.

• Before reinstalling and operating the cooktop, clean the oil off of the surface of the cooktop.

Storing the cooktop

Storing the cooktop

1. LP gas-certified hose
2. Ensure the control knobs are in the Off position and the LP gas shutoff valve is closed.
3. Disconnect the LP gas-certified hose from the cooktop and the LP gas source.
4. Remove the screws securing the cooktop to the hob box.
5. Lift the cooktop out of the hob box.
6. Pack the cooktop in its original packaging or other suitable materials to protect it from damage.

Disposal

Place the packaging material in the appropriate recycling waste bins, whenever possible. Consult a local recycling centre or specialist dealer for details about how to dispose of the product by all applicable national and local regulations.

LIMITED TWO-YEAR WARRANTY

LIMITED TWO-WARRANTY AVAILABLE ATDOMETIC.COM/EN-US/TERMS-AND- CONDITIONSCONSUMER/ WARRANTY. IF YOU HAVE QUESTIONS, OR TO OBTAIN A COPY OF THE LIMITED WARRANTY FREE OF CHARGE, CONTACT: DOMETIC CORPORATION CUSTOMER SUPPORT CENTER AT 5155 VERDANT DRIVE ELKHART, INDIANA 46516 1-800-544-4881

• dometic.com

YOUR LOCAL DEALER

• dometic.com/dealer

YOUR LOCAL SUPPORT

• dometic.com/contact

YOUR LOCAL SALES OFFICE

• dometic.com/sales-offices

References

• Dometic | Dometic Australia
• P65Warnings.ca.gov

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>