TOOLPORT CONTOP Container Shelter Instruction Manual
- June 16, 2024
- TOOLPORT
Table of Contents
CONTOP 8mx12m
Assembly instructions Container Shelter
CONTOP Container Shelter
https://manuals.toolport.eu/MAN_CON_B8L12.pdf
Safety Instructions
Introduction
Congratulations on the purchase of your new container top shelter. Please
get in touch with our customer service team or one of our authorised trade
partners if you have any questions or need any tips concerning the use of this
product. Please also take note of the following information.
Important
Please read these installation instructions carefully before installing and
using the container top shelter and keep them for later use.
Warning
Please make sure to leave sufficient space between the shelter and any hoses
or gas and power lines. To prevent damaging such lines, please contact your
local authority for more information. When using heaters inside the shelter
(please ask a specialist retailer for information on appropriate heaters);
they have to be set up at a minimum distance of 1.2 metres from the tarpaulin.
Never light an open fire or use heaters with open flames under the container
top shelter. The installer is responsible for making sure that the shelter is
appropriately anchored and hence for the container top shelter’s safety. The
anchors have to be regularly checked in order to make sure that the shelter is
safe, to prevent damage and to protect any third parties. Properly anchoring
the shelter will extend the individual components’ and the container top
shelter’s service life as a whole. Always wear a helmet, gloves and sturdy
shoes when installing the shelter. The shelter’s metal components can have
sharp edges and may have greasy patches where they have been protected against
rust. In the event of snow, the tarpaulin must be regularly and promptly
cleared of snow. The same also applies in the event of heavy rain fall or
other substances or materials that could put a strain on the shelter. The
shelter’s spare parts must be stored out of the reach of children.
Caution!
Make sure that the ground over which the shelter is being erected is
suitable for its intended use. The containers or relevant supporting
structures must be set up on level ground. Do not use any components other
than those supplied with the shelter. Do not touch and/or work on the
tarpaulin with sharp objects. The elastic straps are wear parts and must be
replaced when the material becomes fatigued. If the shelter is installed in
the winter and at subzero temperatures, the tarpaulin should be stored at a
temperature of at least 10°C for a sufficiently long period of time and
unfolded at this or a higher temperature. Failure to do so can cause the
material in the folds to tear.
Every country has regulations governing the erection of moveable (tents) and
immovable structures. Please contact your local authority to check whether you
need a permit for this shelter and/or its intended use. In some countries,
permits are only required for temporary structures (tents) of a certain size.
On receipt of your shelter
Unpack the boxes and make sure that you have received all of the required
parts by checking them against the packing list. The metal parts will be
slightly greasy, which is normal and a way to protect them. However, some of
those parts might be too greasy. In that case, please use a cloth to remove
the excess grease.
The equipment needed to install the container top shelter (lifting platform,
forklift, and similar) should be transported to the site before starting the
installation work. The frame can be assembled using commercially available
tools.
Cleaning and storage
The tarpaulins must be cleaned with alkaline water only — do not use any
aggressive cleaning agents. Never fold or pack the tarpaulin for storage when
wet after dismantling the shelter. Do not modify the metal frame — whether
that’s by attaching and/or welding other structures or materials to it, by
indenting it and/or deforming the materials. Always treat the shelter’s
components with great care. When dismantling the shelter, use the packing list
to check the whether all of the components are present to ensure that there
won’t be any problems when setting it up again. When storing the shelter for a
long period of time, make sure that no other objects are put on top of it.
For outdoor use only. To be stored outdoors only.
Enviroment
Please help us protect the environment by taking the following steps: Please
dispose of the tarpaulin and frame by disposing of them at an official
recycling point or contact the manufacturer or authorised dealer.
Guarantee and customer services
For more information or replacement parts and accessoires, please write an
emailor contact us by telephone. Our customer service will be happy to help
you. For further questions please provide the article number. The product was
manufactured with utmost care and under constant control. If you have any
complaints, please contact the service hotline or contact us by e-mail. Our
service staff will coordinate with you as soon as possible. Please keep the
proof of purchase (receipt).
Contents
| Item no. | ID | 12 m | |
|---|---|---|---|
| 36194 | Ll | 40 x 80 x 2240 mm | 1 |
| 36195 | L2 | 40 x 80 x 2240 mm | 1 |
| 36196 | L3 | 40 x 80 x 2240 mm | 1 |
| 36197 | L4 | 40 x 80 x 1820 mm | 1 |
| 36198 | LS | 40 x 80 x 1820 mm | 1 |
| 36199 | L6 | 40 x 80 x 1820 mm | 1 |
| 36200 | R1 | 40 x 80 x 2240 mm | 1 |
| 36201 | R2 | 40 x 80 x 2240 mm | 1 |
| 36202 | R3 | 40 x 80 x 2240 mm | 1 |
| 36203 | R4 | 40 x 80 x 1820 mm | 1 |
| 36204 | R5 | 40 x 80 x 1820 mm | 1 |
| 36205 | R6 | 40 x 80 x 1820 mm | 1 |
| 33299 | 1 | 060 mm | 9 |
| 33300 | 2 | 060mm | 18 |
| 33301 | 3 | 060mm | 18 |
| 33302 | 4 | 0 40 mm | 40 |
| 33303 | 5 | 0 40 mm | 8 |
| 33304 | 6 | 24 | |
| --- | --- | --- | --- |
| 33305 | 7 | 12 | |
| 33306 | 7A | 40 | |
| 33307 | 7B | 20 | |
| 33308 | 8 | 18 | |
| 31267 | 9 | 18 | |
| 33309 | 10A | 10 | |
| 33310 | 108 | 2 | |
| 33311 | 11 | 110 | |
| 33312 | 12 |  | 45 | ||
| 33313 | 13 | ! (used at concrete wall) | 4 |
| 33314 | 14 | 4 | |
| 33315 | 15 | 4 | |
| 16 | 1 | ||
| 33317 | 17 | 1 bundle | |
| 33318 | 18 | ! (used at concrete wall) | 20 |
| 33319 | 19 | ! (used at concrete wall) **** | 32 |
| 33320 | 20 | 16 | |
| 33321 | 21 | 4 |
Assembly instructions
https://manuals.toolport.eu/CONTACT_FORM.pdf
Do you have any questions?
Contact us, we are happy to help!
TOOLPORT GmbH
Gutenbergring 1—5
22848 Norderstedt
GERMANY
Telefon +49 (0)40 / 60 87 27 17
Fax +49 (0)40 / 60 87 27 37
www.toolport.de
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>