NSLIGHTDEALER XPR-5562 Depends Light Instruction Manual
- June 14, 2024
- NSLIGHTDEALER
Table of Contents
Instruction Manual
DICATA® XPR-5562GX
US PATENT 9,713,217
XPR-5562 Depends Light
THE XPR-5562 IS APPROVED FOR USE
Bayco Products, Inc. XPR-5562GX 640 S. Sanden Blvd., Wylie, TX 75098
Exira FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS UL listed for use with Bayco
Li-ion Battery Pack 5562-BATT
E 467756
ID 4003544
INTRINSICALLY SAFE
SECURITE INTRINSEQUE| CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV 1 GRPS E-G T135ºC
CLASS I ZONE 0 AEx ia op is IIC T4 Ga
II 1 G Ex ia op is IIC T4 Ga| Ex ia op is IIC T4 Ga
DEMKO 20 ATEX 2267
UL22UKEX2430
IECEx UL 20.0036
-20ºC ≤ Tamb ≤ +40ºC
3.7V/Cell 5562-BATT
Um 4.2V
---|---|---
WARNING: Do not charge battery in a hazardous location
WARNING: Do not replace battery when an explosive atmosphere is present
WARNINGS – INTRINSICALLY SAFE
- Warning: To prevent ignition of a hazardous atmosphere, the XPR-5562 must only be charged in an area known to be non-hazardous.
- Warning: Use only the approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack.
- Warning: The approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack must be replaced by a qualified technician only.
- Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment or attempt to exchange the battery pack while in the hazardous environment. This task must ONLY be performed in an area known to be non-hazardous.
- Warning: Open the battery compartment on the XPR-5562 and replace the approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack in fresh air only.
- Warning: Substitution of components may impair intrinsic safety.
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
For personal safety, always confirm the rating of any known hazardous or potentially hazardous location where the light is to be used.
INSTALL THE BATTERY
- Loosen the locking screw on the underside of the battery compartment before removing the tail cap.
- Reinstall the locking screw after placing the battery to maintain the intrinsic safety certification.
CHARGING THE LIGHT
CHARGER INPUT: 5 VDC Max
WARNING: TO PREVENT IGNITION OF A HAZARDOUS ATMOSPHERE, DO NOT ATTEMPT TO
CHARGE THIS PRODUCT IN THE HAZARDOUS ENVIRONMENT. THIS TASK MUST ONLY BE
PERFORMED IN AN AREA KNOWN TO BE NON-HAZARDOUS
Use only the supplied Nightstick rechargeable battery and Magmata™ cable.
Fully charge the light before the first use, or if the battery is new or has
been unused for several months. For best performance, charge the light when
the flashlight beam starts to dim.
- Connect the Magmata cable to a power source with a USB connector. Attach the magnetic end to the charging port located on the light.
- The USB end of the cable includes an LED charge status indicator. The LED indicator remains red until the battery is fully charged. At full charge, the LED indicator turns green.
- The total time to fully charge the light varies depending on the remaining charge in the battery.
OPERATION
Two switches on the front of the headlamp control all functions.
SPOTLIGHT SWITCH
- First Press = spotlight high-brightness
- Second Press = spotlight low-brightness
- Third Press = off
FLOODLIGHT SWITCH
- First Press = floodlight high-brightness
- Second Press = floodlight low-brightness
- Third Press = off
DUAL-LIGHT MODE
- Press each switch one time to turn on both lights in high-brightness mode.
- To shut down Dual-Light mode, press each switch two more times until each light turns off.
WARRANTY
LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in
workmanship and materials for the original purchaser’s lifetime. The Limited
Lifetime Warranty includes the LEDs, housing and lenses. Rechargeable
batteries, chargers, switches, electronics and included accessories are
warranted for a period of two years with proof of purchase. Normal wear and
failures which are caused by accidents, misuse, abuse, faulty installation and
lightning damage are excluded.
We will repair or replace this product should we determine it to be defective.
This is the only warranty, expressed or implied, including any warranty of
merchantability or fitness for a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/bayco-
productsupport/warranties. Retain your receipt for proof of purchase.
EU / UK Declaration of Conformity
| Model(s): | XPR-5562GX | Declaration | : 20200527-D |
|---|---|---|---|
| Product Type: | Headlight | ||
| Company Name: | Bayco Products Inc. | ||
| --- | --- | ||
| Address: | 640 S. Sanden Blvd. | ||
| City, State, Postcode: | Wylie, Texas 75098 USA | ||
| Phone / Website: | 001-469-326-9400 / |
We hereby declare that the product identified above meets the requirements of
the Directives listed below. Therefore, they qualify for free movement within
markets comprising the European Union (EU), the European Economic Area (EEA)
and the United Kingdom (UK). This declaration is issued under the sole
responsibility of the manufacturer.
The following EU harmonized, UK designated standards and technical
specifications have been applied and evaluated by:
Directives:| ATEX Directive 2014/34/EU| UKSI 2016 No. 1107| Article 34 of the
Industrial Safety and Health Act and Article 58-4, Paragraph 4 of the
Enforcement Rule of the same Act.
---|---|---|---
Notified Body:| UL International Demo A/S| UL International (UK) LTD| Korea
Occupational Safety and Health Agency
Notified Body Number:| 539| 843| N/A
Certificate Number:| DEMK020ATEX2267| UL22UKEX2430| 22-AV4B0-0219X
Standards:| EN 60079-0:2018
EN 60079-11:2012
EN 60079-28:2015
Type Approval:|
These Products are fully compliant and do not contain the restricted
substances above levels noted in EU and UK RoHS.
Name: Mark Situ
Title: Quality Director
Date: 9th August 2022
Bayco Products, Inc.
• 640 South Sanden Blvd.
• Wylie, TX 75098 • USA
• 1-800-233-2155
• 1-469-326-9400
• www.nightstick.com
INS-XPR-5562-DL-22