i-bin hygiene15 Ladies Sanitary Container User Manual

i-bin hygiene 15 Ladies Sanitary Container

Preface

Thank you for purchasing the i-bin hygiene’S. Please read the important safety information and user instructions in this manual carefully before using the bin for the first time. This manual contains important information. Please keep it for future reference.

Purpose of the service manual

The purpose of the user manual is to provide the user with information in such a way that during its life, the i-bin hygiene is used correctly, efficiently, and safely, even in the event of reasonably foreseeable misuse, as described in section 1.2 of this manual.
The user manual contains instructions regarding:

• Personal operator safety
• Intended and non-intended use of the i-bin hygiene;
• Instructions for daily use
• Maintenance instructions
• Storage conditions
• Disposal of the i-bin hygiene

These instructions must be considered to avoid risks that could lead to physical and/or material damage.
Target audience
This user manual is intended for users of the i-bin hygiene15, as well as partners and importers.

Operators of the i-bin hygiene

The i-bin hygienes may only be operated by a person who has correctly read and understood the instructions in this manual or is trained by an experienced operator who has read and understood the instructions in this manual.

Reading guide
The following symbols and terms are used throughout this manual to alert the reader to safety issues and important information:

Introduction

The i-bin hygiene’S is a safe, user-friendly machine. This manual helps you to get started and explains the operation and maintenance procedure. You will be pleasantly surprised by the fast and effective use of the battery operated i-bin hygiene’5, This manual is intended for those use the -bin hygiene15 and/or perform daily maintenance. The manual must be read fully before the first actions. The manual describes the correct method of use, safety measures, maintenance and transport. The manufacturer continuously improves all their products based on user experience and feedback. Any deviations between the texts and/or images from the manual and your i-bin hygiene15 can therefore arise from the difference in model or from possible changes due to continuous developments and innovations.

Intended use of the product
The i-bin hygiene15 is a specialized machine for storing your hygienic waste.

Non-intended use of the product
WARNING
Non-intended use can have consequences for the safety of operators and bystanders and will void the warranty on the product.

• DO NOT immerse the product in water or other liquids and do not rinse under a tap.
• DO NOT place hands or other items in the product during automatic packaging.
• DO NOT put flammable or explosives in the product.
• DO NOT attempt to repair the product yourself or disassemble the battery. Doing so will void your warranty.
• This product is not a toy and should not be used as such.
• DO NOT disassemble or destroy the battery.

Lifespan

• Used in normal circumstances, the battery of the i-bin Hygiene 5 should last at least 14 days.

CAUTION

• To ensure proper and safe operation throughout the life of the i-bin hygiene, the product must be checked by an authorized i-team partner every 3 months

Modifications

• It is not permitted to make modifications to the design of the i-bin hygiene without consultation and permission from the manufacturer. This affects the warranty, see section 1.6 of this manual.

Specifications

• Product identification: IHBN.FCT.002xx (Basic)
• Product name: i-bin hygiene15
• Model: Basic version
• Product size: 20 x 23.5 × 65.5 cm
• Weight (including batteries): 4 kg
• Capacity 15 L
• Li-ion battery: DC (11.1 V, 4400 mAh, 353 Wh)
• Battery capacity: 1 battery
• Charging current: 1 A
• Input 12 V (DC), 1 A
• Charging time 5 h
• of cycles: >750

Warranty
The i-bin hygiene15 should be used as intended and described in this manual. Using the i-bin hygiene15 outdoors will void the warranty on the product.
Identification
The serial number and production date can be found on a sticker on the back of the i-bin.

Description

The compact i-bin hygiene15 consists of three main parts:

• The upper part contains the foil lid, the working status light, and the Indicator light.
• The stand contains the IR sensors, the Reset button, the Main switch, the Locking mechanism, and the Detachable base.
• The bottom part, the bin, see Figure 3.

The i-bin Hygiene 15 consists of:

Safety

Safety comes first. Therefore, please take your time to read and understand these safety instructions. kindly follow the instructions correctly to avoid potential danger or injury. Improper use can cause harm or void the manufacturer’s warranty.

General safety instructions

Indoor use
This product is intended for indoor use only.
Users
Guardian. People with physical or mental disabilities should use the product only under the guidance of a The product should only be used by people who are properly trained and have experience with its usage.
Battery
When charging the battery, always use the cable provided by the manufacturer. Refraining from doing so might result in fire, an electric shock, or personal injury.

ATTENTION

Instead of using a cable when charging, also a special charger unit can be used to charge multiple batteries. This charger unit is not included and should be ordered separately.
CAUTION
During normal operation, the 11.1 V battery causes no safety hazard on its own. Please adhere to the following safety instructions regarding the battery:

• Do not crush, pierce, or damage in any way.
• Do not heat or incinerate.
• Do not short-circuit.
• Do not dismantle.
• Keep dry.
• Only charge between 5 °C~40 °C / 41 °F~ 104 °F.
• Only use between 5 °C~45 °C / 41 °F~ 113 °F.

Risks during operation
The i-bin hygiene15 is designed to close and seal bio-friendly storage bags. The sealed bags will be dropped and collected in a container at the bottom part of the machine.
CAUTION
The sealing mechanism of the i-bin hygiene15 can get very hot. Avoid touching it.

WARNING

• The chemicals in the battery are located inside a sealed container
• They pose a chemical hazard only if the battery is not used properly or damaged.
• Avoid contact with the electrolytes.
• Contact with a damaged or leaking battery can result in chemical burns.
• If exposure to any battery chemicals happens, act as follows:

Contact to the eyes:

• flush the eyes with plenty of water for a minimum of 15 minutes, lift the upper- and lower eyelid occasionally;
• seek medical attention.

Inhalation:

• vacate from the exposure environment and move to an environment with fresh air immediately;
• seek medical attention.

Ingestion:

• give at least two glasses of milk or water. Induce vomiting unless the person is unconscious;
• seek medical attention.

Risks after operation

Remove battery
Remove the battery from the i-bin hygiene15 when it will not be used for 4 days or more.
Careful when storing
Do not store the i-bin hygiene15 on ramps or slopes. Always store the i-bin hygiene15 on a level, hard surface.

Transport and storage

General CAUTION
Always store the i-bin hygiene15 in a dry environment.

Assembly and installation

The i-bin hygiene15 does not require much assembly.
Unboxing
The i-bin hygiene15 is packed in a single box. Ensure that no items are missing and compare contents with the list in Figure 4. If one of the items listed is missing, contact your i-bin hygiene!5 dealer.
ATTENTION
Some of the items shown below are stored inside the bin itself.

Assembly

Battery
Connect the charger to the battery. For first use, charge the battery for approximately 5 hours.

Install the battery

• Press the metal handle on either side of the i-bin hygiene15 down. The locking mechanism will now release the bin.
• Slide the bin out from the stand.
• Open the battery compartment with the key and insert the battery in the slot.
• Press the ON/OFF switch to turn on the machine.
• Close the battery compartment and lock it with the key. Click the bin back into the stand. The magnet, fitted in the middle of the stand, will hold the bin in place.

CAUTION
Please be aware of the integrated magnet fitted on the stand of the i-bin hygiene 15.
In the case of wall mount CAUTION
Assure the is no electric wiring in the wall where the holes will be drilled. Use the provided plugs and screws for mounting the i-bin hygiene’S to the wall, Figure 11

ATTENTION
To mark the holes to be drilled in the wall, use the included template.
CAUTION
Assure no electricity cables or water pipes are located at that location where the i-bin hygiene 15 will be installed

• Check if the wall where the i-bin hygiene is to be placed is smooth. Place the template (pos 2, Figure 12) with the bottom part on the floor. Check with a water level (pos 1, Figure 12) if the template is exactly horizontal,
• Mark the four holes (Pos 1, Figure 13) on the template with a hammer and a nail on the wall. Drill the holes with a drill bit 06 mm(1/4). Depth 40 mm (1 3/8). Push the plugs inside the holes and ensure they are flush with the wall.

ATTENTION
In order to fix the i-bin hygiene15 to the wall, the bin needs to be removed. Switch off the machine, see Figure 17. Then follow the steps as indicated at Figure 6 and Figure 7. Mount the i-bin hygienes with 4 screws on the wall (A).

In the case of wall mount with stickers
In case drilling in the wall is not possible, the i-bin hygiene!5 can also be attached to the wall using the provided 3M stickers.

ATTENTION

Prior to fixing the i-bin to the wall, mark with a thin pencil and a spirit level a vertical line on the wall. Stick the 3M adhesive sticker onto the backside of the machine as shown in Figure 15.

Press the machine tightly to the wall, see Figure 16

Operation

Check if the i-bin hygiene is assembled and installed properly, see paragraphs 5.2 and 5.3 or 5.4.
Install the cassette

• Switch off the machine and remove the bin as described in paragraph 5.2.2.

• Lift the top foil lid and remove the empty cassette (if present).

• Place a new foil cassette

• Pull about 30 cm (12″) of the foil up and push it back into the opening of the machine.

• Two sets of splined wheels are fitted diagonally on either side of the opening. Place the foil between the wheels and press down with the provided Foil loading tool.

• Switch on the i-bin. The two wheels will automatically pull down the foil. The cassette is now installed. Replace the top foil lid and then the bin.

  • ATTENTION
    Make sure when placing back the bin, the foil is in the bin and not stuck behind it.

  • ATTENTION
    Before the i-bin hygiene’5 can be put into operation, it needs to be reset.

  • ATTENTION
    When the Foil low indicator is solid red and there is a sanitary napkin of tampon in the bin, first press the reset button. The -bin hygiene’5 will make a final bag.

• The backside of the foil loading tool includes a small knob.

• Press this knob into the small hole on the left side of the stand. Hold it for about 3 s.

• After 3s the red indication light will switch off and a small beep can be heard. The i-bin is now reset and ready for operation.

• ATTENTION: **** In the case, the foil has not been pulled down, return to the instruction Figure 21 and repeat the indicated next steps.

When to empty the bin?
When the bin is full, the Bin full indicator will start flashing, see Chapter 2. Also, the Main light bar will turn solid red, see Figure 23. In this case, the bin needs to be emptied.

Remove the bin as shown in Figure 6 and Figure 7. The bin can now be emptied.

CAUTION
Always empty the bin when it is removed from the machine. As soon as the bin is removed, the ‘bags-counter’ will be reset to zero. Refraining from emptying the bin will lead to miscounting. This can lead to overfilling of the bin.

Install the drawstring bag
ATTENTION
Optionally a plastic bag can be fitted inside the container of the i-bin hygiene 15, Waste sealed by the -bin hygiene’ will now be contained inside this bag Take a drawstring bag and tear it off the roll. Open the bag.

Place the bag inside the container and fit it over the four hitch points at each corner of the i-bin.

Push the bag down inside the container.

(Re)placing an i-scent cup!

• To (re)place a new i-scent cup:
• Use a pointed object and remove the cupholder.
• Remove the old i-scent cup from the cupholder (if applicable).
• Pull off the plastic foil from the new i-scent cup.
• Place this cup in the cupholder.
• Press the upholder back into the stand.

Maintenance

CAUTION

• Remove the battery before executing any cleaning or maintenance task.

Cleaning

• To clean the i-bin hygiene, wipe the plastic bin with a damp cloth.

CAUTION

• Don’t use chemicals for cleaning the i-bin hygiene.

Replacing the cassette

• For replacing the cassette follow the steps as described in paragraph 6.1.

Replacing the battery

• For replacing the battery follow the steps as described in paragraph 5.2.2.
• Push the battery with your thumb, till it slides out the battery compartment.

Troubleshooting

Decommissioning and disposal

The packaging material of the i-bin hygiene’5 is recyclable. Please dispose it off according tolocal laws and regulations regarding recycling of paper and cardboard materials.

ATTENTION

• It is the responsibility of the i-bin® hygiene owner to dispose of the product responsibly.
• After decommissioning. the i-bin’5 hygiene’5 still contains valuable resources and needs to be disposed of according to your local laws and regulations regarding recycling of electrical equipment.

Before disposing please:

1. Remove the battery for separate disposal, see paragraph 7.3.
   • WARNING: Never dispose of batteries with regular waste. When disposing of batteries with regular waste they can short circuit and cause fire.
2. Remove all loose components like the foil cassette.
3. Dispose of all items according to your local laws and regulations.

Attachments

CE Certificate

CONTACT

• Phone: 1800 861 030
• Email: hello@i-teamanz.com.
• Website: www.i-teamanz.com.
• i-team Professional
• Hoppenkuil 27 B
• 5626 DD I Eindhoven
• NL IT ÷31 (0640 266 24 50 Kv 17:70863
• VAT no. NLA13934023801 Rabobank
• Swil RABONL2U
• Eur na. 1069.72.984
• IBAN N.048A800108972984
• USD no. 1069.72.984
• IBAN N.D4AABO01089729B4

References

• Enterprise content management experts | TEAM IM
• i-team ANZ | Industrial & Commercial Cleaning Equipment

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>