Flexineb C2 Small Animal Nebuliser Instruction Manual
- June 12, 2024
- Flexineb
Table of Contents
C2 Small Animal Nebuliser
Instruction Manual
The Complete Nebuliser System for Small Animals
INSTRUCTIONS FOR USE
Intended Use
For Veterinary Use Only. The FlexinebC2 Small Animal Nebuliser is intended to aerosolize veterinarian prescribed liquid solutions into a fine mist for inhalation into the airways of small animals. The end user is liable for the safe operation of the FlexinebC2 as outlined in the Instructions for Use. Medications must be prescribed by a veterinarian and end users must always follow the advice of their veterinarian.
Safety Information
When using the FlexinebC2 Small Animal Nebuliser for the first time remember it is the first time for your pet too, so caution is advised. Ensure the air vents in the medication cup are never sealed off. Position the FlexinebC2 close to the nose and mouth ensuring your pet can breathe normally. If your pet resists the device be patient and let them look at it and smell it before attempting to try again. Use the FlexinebC2 Nebuliser in a ventilated area when nebulizing drugs. To protect yourself it is advisable to wear a facemask to avoid passive inhalation of medicated aerosols that may escape during use.
Instructions for Use
- Assemble the FlexinebC2 as shown in Figures 1 or 2 depending on the application
- Place medication or normal saline 0.9% into the cup following the advice of your veterinarian
- Switch on the Controller, select power level one for handheld use and level two for Cage Use. Level two provides more power to help fill a cage or for nebulizing high viscosity medications.
- Nebulization will begin after a few seconds and a fine mist will be visible
- If handheld, hold the Nebuliser close to your pets’ nostrils so they can inhale the fine aerosol mist
- If attached to a cage, cover the cage openings to prevent aerosol escaping during use
- The Controller will auto turn off after 35 minutes if left on or turn it off manually by pressing the button.
- Clean the device after use, refer to the instructions in the Maintenance and Cleaning section.
Technical Information:
Flow Rate:
Typically ~0.3 ml/min with 0.9% NaCl solution. The flow rate is very dependent
on the drug used.
Aerosol Droplet Size:
The FlexinebC2 produces a high volume of aerosol droplets in the
respirable range <5microns.
The aerosol droplet size is dependent on the drug used.
Medication Cup Volume:
The medication cup will hold 10ml of liquid but is expandable to 30ml using a
plug-in extension cup accessory. The controller has a 35-minute timer function
to accommodate longer treatment times when used with the extension cup and
attached to a cage door for example.
Battery Power:
Battery Type: 3.7V Li-polymer rechargeable battery.
Use the Norte supplied battery only.
Use of another type of battery may present a risk of fire or explosion.
Operating Time: >3 hours from fully charged.
Battery Charging:
Power supply 5Vdc/1A and USB Cable with USB-A to Micro USB-B connection.
A fully discharged battery can take up to 2 hours to reach full charge.
Environmental Conditions:
Operating: 5°C to 45°C and up to 95% RH
Storage and Transportation: -20°C to +45°C and 15% to 95% RH
Controller Functions:
Figure 3: C2 Controller
Maintenance and Cleaning
Medication Cup – CAUTION:
To avoid damaging your medication cup please note the following cautions
before cleaning;
- Do not immerse the Medication Cup in water, cleaning, or disinfectant solutions.
- Do not steam autoclave or boil the Medication Cup.
- Do not nebulize or put chemical cleaning solutions inside the Medication Cup.
- Do not touch or press on the metallic mesh in the Medication Cup.
The Medication Cup is a replaceable part therefore for continuity of
treatment, it is highly recommended to carry spare Medication Cups.
Cleaning:
It is very important to wash out any drug residues after each use to prevent
cross contamination and prolong the life of the vibrating mesh in the
Medication Cup. Protect the electrical connector from getting wet when
cleaning by using the protective cap provided. Open the Blue Cap and place
1-2 drops of mild hand dishwashing liquid (do not use dishwasher detergent)
into the Medication Cup and fill with clean warm tap water. Close the Blue Cap
and shake the Cup vigorously for about 15 seconds and squeeze the Blue Cap to
push water through the mesh whilst shaking. Open the Blue Cap and rinse out
from both sides with clean water. Shake off excess water and dry off before
re-use.
Disinfection:
Use a disinfectant spray or disinfectant wipes according to the manufacturer’s
instructions. Shake off and allow dry on a clean surface before re-use.
Masks and Adaptors Cleaning:
Accessories such as Masks and Adaptors can be washed using clean warm tap
water with some dish washing up liquid. Rinse off with warm clean tap water
and dry off before re-use.
Disinfection:
To disinfect use a disinfectant spray or disinfectant wipes according to the
manufacturer’s instructions. Shake off and allow dry on a clean surface before
re-use.
Controller Cleaning:
To maintain the function of the controller it must be used and stored in dry
conditions. To maintain the battery function, it must be charged when the
battery charge runs low. Clean the controller surfaces using a clean damp
cloth, disinfect by wiping down with anti-bacterial wipes.
Warranty
Controller (excluding battery), Cables, Charger: 24 months. Battery: 6 months.
The Medication Cup is a wearing part, and its’ life is dependent on drugs
nebulized and how well it is maintained therefore it is not covered by
warranty. Damage caused by improper handling or misuse is not covered by
warranty.
Compliance
FlexinebC2 Small Animal Nebuliser complies with the essential
requirements of all relevant European Directives and Harmonized Standards.
Product Support
Check out www.flexineb.com website for product information up( Email technicalsupport@nortev.com for product support.
CE CA S d N o rtev, Galway, Ireland
MS-347 Rev.01
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>