SimpliFire SF-OD43-DP 43-Inch Outdoor Electric Fireplace Installation Guide

SimpliFire SF-OD43-DP 43-Inch Outdoor Electric Fireplace

Product Information

The Forum Drain Pan SF-OD43-DP, SF-OD55-DP is designed to channel moisture to the front of the enclosure. It is recommended to ensure a 1/4 slope per foot in the enclosure to ensure proper water drainage. The drain pan can be shimmed under the aluminum feet of the Forum (SF-OD43/SF-OD55) appliance to align it with the enclosure’s framing. The drain pan can be modified for effective moisture shedding from the enclosure.

Product Usage Instructions

1. Prior to installing the drain pan, flash the rough opening platform to prevent water penetration into moisture-sensitive construction materials, following regional practices and local
   codes.

2. Apply silicone to the rear corners of the drain pan and adhere it to the bottom of the rough appliance opening.

3. Position the drain pan lip on the front of the enclosure so that water drains to the front. The membrane or flashing should be under the drain pan.

4. Ensure that the enclosure is at an angle of at least 1/4 per foot slope for proper drainage.

5. Fasten the drain pan sides to the framing using construction screws through the appropriate mounting hole based on the depth of the sheathing/finishing material.

6. Clear all debris from the open area at weep holes or drainage slots.

Please refer to Figure 1 for attaching the drain pan to the appliance and Figure 2 for installing the drain pan under the appliance. For specific dimensions, refer to Figure 3. For more information or assistance, please contact your SimpliFire dealer. To find the nearest SimpliFire dealer, visit www.hearthnhome.com.

Leave this manual with party responsible for use and operation.

• CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses during instal-lation. Sheet metal edges are sharp.
• CAUTION! Do not install damaged components.

INTRODUCTION
The drain pan is designed to channel moisture to the front of the enclosure. Care must be taken to ensure there is a 1/4” slope per foot in the enclosure to make sure water is drained away from appliance. The Forum (SF- OD43/SF-OD55) appliance may be shimmed under the aluminum feet to remain plum with the enclosure’s framing.

TOOLS & SUPPLIES NEEDED

• Construction Screws and Driver
• Flashing / Waterproof Membrane as needed.
• Silicone suitable for outdoor use.

BEFORE YOU BEGIN

When installing, the drain pan must be attached to the framed opening of the appliance enclosure. Silicone should be applied to the back corners of the drain pan to completely seal pan. The bottom of the drain pan can be installed and adhered with silicone directly on top of enclosure or waterproof membrane. This pan can be modifed to allow the most effective means of shedding moisture from the enclosure.

INSTALLATION INSTRUCTIONS

1. Prior to installing the drain pan, flash the rough opening platform in a manner consistent with regional practices and local codes to prevent water penetration into moisture sensitive construction materials.

2. Silicone rear corners of drain pan, apply silicone to the underside of the drain pan to adhere it to the bot- tom of the rough appliance opening. See Figure 1.
   Figure 1 Attach Drain Pan to Appliance

3. Position drain pan lip on front of enclosure so water drains to front of enclosure. The membrane or flashing will be under drain pan. See Figure 2.

4. The enclosure is to be at an angle at least 1/4” per foot slope to ensure proper drainage.

5. Fasten drain pan sides to framing using construction screws through the appropriate mounting hole, deter- mined by sheathing/finishing material depth. See  Figure 2.

6. Make sure open area t weep holes or drainage slots are clear of all debris

Figure 2 Drain Pan Installed Under Appliance

Figure 3 Drain Pan Dimension

• SimpliFire, a brand of Hearth & Home Technologies 7571 215th Street West, Lakeville, MN 55044 www.hearthnhome.com
• Please contact your SimpliFire dealer
• For the location of your nearest SimpliFire dealer, please visit www.hearthnhome.com.

SimpliFire • SF-OD43-DP, SF-OD55-DP Installation Instructions • 2047-970 Rev A • 12/22

References

• Hearth & Home Technologies

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>