FRESH-AIRE UV AHU Series 1 Blue-Tube UV Germicidal UV Light Instruction Manual
- June 4, 2024
- FRESH-AIRE UV
Table of Contents
AHU Series 1 Blue-Tube UV Germicidal UV Light
Instruction Manual
AHU Series 1 Blue-Tube UV Germicidal UV Light
The germicidal UV light is installed inside the air handling system to reduce biological contamination for reduced system maintenance and improved indoor air quality.
| US patent #7,704,463|
---|---|---
IMPORTANT!
- Only qualified technicians should install this product*
- Install in accordance with relevant building codes
- Read instructions carefully including safety warnings
WARNING!
PROTECT EYES FROM UV LIGHT TURN OFF THE UNIT OR DISCONNECT BEFORE SERVICING
PARTS*
*Parts included with your
kit will vary depending on the model.
STEP 1: UV Lamp Installation
Surface Mount
- Determine the optimal position for placement of the UV lamp.
- Use a utility knife to cut a slit in the insulation on the interior surface.
- Place the magnetic “Z” bracket directly on the metal surface or remove the magnet and hard-mount the bracket using the self-tapping screws provided. Use foil tape to close the cut in the insulation.
- Use plastic quick-nuts to attach the UV lamp to the “Z” bracket as shown.
Important: some materials inside the air system (including filter media, flex duct, wiring, etc.) may not be UV light resistant. Use the optional UV shield (part #TUVSHIELD-LPC) or cover the materials with reflective tape.
Coil A-Plate or Duct Mount
- Snap the “Z” bracket apart by bending.
- Drill a 1” hole in the “A”-plate or duct then attach the smaller piece of the bracket using the self-tapping screws.
- Insert the UV lamp into the hole then use the plastic quick-nuts to attach the UV lamp to the “Z” bracket as shown.
STEP 2: Power Supply Installation
IMPORTANT! Check which power supply is included with your germicidal UV light before connecting to power. Turn off main power source before installation.
- Find a suitable location for the power supply inside the control panel of the air handler. Install using the self-tapping screws.
- Use the wiring diagrams to connect to power.
The low-voltage power supply connects to the air system’s 24 VAC transformer (or add a 24 VAC transformer as needed).
Line-voltage power supplies connect directly to 120-277 VAC power.
Some line-voltage power supplies can support more than one UV lamp. They will come with two or more blue cables.
IMPORTANT! Must be wired to constant power – do not connect to blower
relay.
IMPORTANT!
Systems with high 24 VAC loads may require the installation of a separate 24
VAC transformer to power the UV light.
Always use a separate 24 VAC transformer with “communicating” air systems.
Draws 16 VA, may need to do load calculation: Volts under load X Amps under
load.
STEP 3: Lamp Connection
Connect lamp: make sure the flanges are aligned and then push the connectors
firmly together. A tight connection ensures a proper water-resistant seal.
STEP 4: UV Warning Sticker & Safety Sight Glass
- Find a suitable location on the outside of the duct-work near the UV Lamp installation and apply the Fresh-Aire UV® warning/lamp replacement sticker
- Drill a ½” hole through the orange circle on the sticker. Press the UV safety viewport into the hole.
- Turn on the power and use the sight glass to confirm that the UV Lamp is operating.
Lamp Replacement
Germicidal UV lamps need to be replaced periodically. Systems will include
one-year (TUVL-1xx), or two-year (TUVL-2xx) UVC lamps.
Note: UV lamps will continue to emit visible light but they lose
germicidal effectiveness over time. One-year and two-year lamps are
interchangeable, you can upgrade to a two-year lamp with your existing power
supply.
| PART:
TUVL-115P LIFE: 1 Year
FITS: Blue-Tube UV, AHU Series 1
---|---
PART: TUVL-215P LIFE: 2 Year
FITS: Blue-Tube UV, AHU Series 1
CAUTION!
UV lamps contain small amounts of mercury Dispose of lamps in accordance with
local environmental regulations.
For more information visit www.lamprecycle.org
Note: Use of replacement UV lamps other than Fresh-Aire UV® voids
warranty.
Manufacturer’s Warranty:
This warranty supersedes and replaces any warranty statements orally made by
the Sales Person, Distributor or Dealer or contained in the written
instructions or other Brochures or informational documents in relation to this
product. This warranty gives you specific legal rights, and you may also have
other rights which vary from State to State.
What Does This Warranty Cover? This lifetime limited manufacturer
warranty covers any defects or malfunctions in material and workmanship under
normal use and service when operated and maintained in strict accordance with
the manufacturer’s instructions for the Lifetime of the equipment.
How Long Does The Coverage Last? 1) Power Supply: For as long as you own
the real property where the product is installed. 2) TUVL-1XX Series
Ultraviolet Lamp is warranted for germicidal output for one year from the date
of installation. 3) TUVL-2XX Series Ultraviolet Lamp is warranted for
germicidal output for two (2) years from the date of installation. This
warranty is not transferable.
What Will Triatomic Environmental, Inc. Do? Triatomic Environmental, Inc.
will replace any defective or malfunctioning part at no charge. You must pay
any labor charges and shipping charges of a defective product to our warranty
department.
What Does This Warranty Not Cover? THIS PRODUCT IS NOT INTENDED TO BE
PURCHASED AND INSTALLED BY UNLICENSED HVAC OR ELECTRICAL CONTRACTORS. This
warranty does not cover products or parts purchased from any source other than
licensed HVAC or electrical contractors. This warranty does not cover parts
installed by unlicensed HVAC or electrical contractors. This warranty does not
cover parts damaged as a result of misuse, abuse, or any use other than its
intended use, accident, acts of god, neglect, or from improper operation,
maintenance, installation, modification, or adjustments. Triatomic
Environmental, Inc. shall have no responsibility for charges incurred by the
customer for the installation or removal of warranted items.
This warranty does not cover parts or equipment used with the Fresh-Aire UV
system that are not manufactured by Triatomic Environmental, Inc.
This warranty shall be void if UV lamps from manufacturers other than
Triatomic Environmental, Inc. are used with this equipment.
Consequential and incidental damages are not recoverable under this warranty.
The manufacturer assumes no liability for any harm, which may occur as a
result of the use of the equipment herein and shall not be liable for
consequential or any other damages whether or not caused by the manufacturer’s
negligence or resulting from any express or implied warranty or breach
thereof. Consequential damages for the purpose of this warranty shall include,
but not be limited to, loss of use, income or profit, or loss of or damages to
property or injury or death to persons or animals occasioned by or arising out
of operation, use, the operation, installation, repair or replacement of the
equipment or otherwise. Some states do not allow the exclusion or limitation
of incidental or consequential damages, so the above limitation or exclusion
may not apply to you.
There are no warranties that extend beyond the description of the face hereof.
How Do You Get Service?** In order to be eligible for service under this
warranty, you MUST return the warranty registration card or register online at
www.freshaireuv.com. If something is wrong with
your product, call your installing contractor to receive a Return Merchandise
Authorization (RMA) and instructions for returning the product to a licensed
distributor in your area or the manufacturer.
Once the product is returned, we will inspect your product and contact you
within 10 business days of our receipt of the product to give the results of
our inspection. If we determine that the product is covered under this
warranty, we will ship it to you at no additional cost as a replacement part.
Replacement parts may be refurbished. If we determine that the product is not
covered under this warranty, or that this warranty is void, the product will
be returned to your COD. There is no charge for inspection.
How Does State Law Apply? This warranty gives you specific legal rights, and
you may also have other rights which vary from state to state.
*Installation of this product by anyone other than licensed HVAC or electrical contractors voids warranty.
WWW.FRESHAIREUV.COM
© Fresh-Aire UV® LIT-FAUV-UV-RES-MAN 091621
SALES@FRESHAIREUV.COM
800.741.1195
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>