FLEXIHIRE Earthmoving & Landscaping Equipment Info Hub Instructions
- June 4, 2024
- FLEXIHIRE
Table of Contents
Safe Operating Procedure
PPE Required
Excavator
General Safety Instructions
- Complete pre-start checklist
- Read Manufacturers Operation Manual (www.flexihire.com.au)
- Report any faults or damage to Flexihire 1300FLEXIHIRE
- Do not wear loose clothing or jewelry
- Do not operate equipment near pedestrians or people
- Do not operate without the appropriate PPE as detailed
- Do not operate equipment under the influence of drugs or alcohol
General Engine Safety
- Refueling – Do not smoke, or introduce an ignition source, always turn engine off and allow the engine to cool first, relieve fuel pressure by loosening the cap slowly, and wipe clean any fuel spills prior to re-start, If fuel spilled on clothes change clothes, ensure cap is replaced & store fuel vessel away from the work area
- Do not breathe fuel vapor & replace the cap securely after fuelling
- Do not operate the engine without adequate ventilation
- Beware of hot surfaces on engine & other parts
Top 4 Safety Points
- Read and Understand Safe Operating Procedure
- Never operate machine unless seated
- Dial before you dig
- Look up and live – watch for power lines
Risk Assessment
- Assess the immediate work area for any hazards
- Control or eliminate all the risks associated with the hazards
- Hazards to check for that may require risk control-
❑Overhead power lines
❑Digging
❑Confined space
❑Traffic & moving machinery
❑Stored energy – air, hydraulic, electricity, pressure| ❑Working at height
❑Falling objects
❑High Voltage
❑Any stored energy
---|---
Operating Safety Instructions
Only competent operators are to operate this machine| Maintain proper tire
pressure – refer to manufacturer specifications
---|---
Always wear a seat belt| Do not operate the machine under the influence of
drugs or alcohol
Obey Danger, Warning, and Caution labels on the machine| Ensure adequate
clearance for the full swing of the machine
Report any damage to the cabin (ROPS) structure and cease use| Ensure all
mirrors are in place prior to operation
Ensure ground conditions will support the machine and load| Sound horn before
moving and when turning
Study the control levers and ensure you understand each control at low engine
speed prior to normal use| Avoid turning the engine off or applying a parking
brake when moving as the machine could stop abruptly causing the load to shift
or fall
Never operate machine near overhead power lines| Never carry additional
persons
Do not use the boom as a crane unless the machine is fitted with an approved
lifting point and associated SWL decals and charts and appropriate lifting
devices| Check for pipes and buried cables before you dig
Do not drive near ledges| Do not jump on or off the machine at any time
Do not allow persons with the excavator working range| Never operate the
excavator in the vicinity of children
Keep all parts of the body within the frame at all times| Always stop the
engine before removing or changing equipment or attachments & release
hydraulic pressure (see manual)
Always ensure the operator is seated with the seat belt fastened prior to
starting
Bring the machine to a stop before shifting controls| Never open the radiator
cap when the engine is running or hot
Always check clearances before driving under objects| Always park on flat
level ground and engage the parking brake
Ensure the excavator has been secured adequately when transporting| Ensure you
know where the emergency stop lever is before starting
If the swing frame has been turning 180 deg the travel directions will be in
reverse| Always contact local authorities prior to performing any digging to
identify underground services
After operation
-Park the excavator on the flat level and on firm ground
-Lower the attachments to the ground
-Stop the engine
-Release pressure trapped in the hydraulic system
-Lock all control levers & remove the key| Driving on slopes
-When driving downhill use low gear, low speed, and do not engage neutral
-Avoid excessively steep slopes and never drive across them
-Avoid turning on a steep slope
-Keep the bucket low to the ground
Ensure the lock lever is in the lock position when starting and during warm-
up| Do not service, attempt to repair, or modify machine unless competent and
without engine off and parked with keys removed
If loading or unloading on a trailer ensure the trailer is attached to a
vehicle. If loading or unloading on a truck ensure ramps are secured
adequately to the trailer or vehicle to ensure they do not become detached as
the excavator can suddenly roll over if the ramps drop| Always ensure the cab-
type machines have an emergency hammer/pick on board for breaking glass in
case of danger
Never operate or start the machine from outside the cab or seat as you could
move the controls the wrong way and cause serious injury. Also never operate
the machine with another person helping as they can be crushed| If the machine
tips – do not jump, brace yourself, stay in the cab, keep your seatbelt
fastened, hold on and lean away from point of contact
| Do not dig deeper than 1M without shoring
Beware of oxygen deficiencies and gas build-up in pits and holes
FMS10-5.1.3.9.6.4 SOP Excavator
Version #: FLX 3.3
Issue: October 2021
Review: October 2026
Documents / Resources
|
FLEXIHIRE Earthmoving & Landscaping Equipment Info
Hub
[pdf] Instructions
Earthmoving Landscaping Equipment Info Hub, Landscaping Equipment Info Hub,
Equipment Info Hub, Info Hub, Excavator
---|---