SMITH BROWN SZCF Series Compressor Chromalux Instruction Manual

SMITH BROWN SZCF Series Compressor Chromalux

SAFETY

WARNING!
It is hazardous for anyone other than authorized service personnel to carry out servicing or repairs which involves the removal of covers. To avoid the risk of an electric shock do not attempt to repair this appliance yourself.

WARNING!
Risk of fire / flammable materials.

Safety Tips

• Do not use electrical appliances such as a hair dryer or heater to defrost your Freezer.
• Containers with flammable gases or liquids can leak at low temperatures.
• Do not store any containers with flammable materials, such as spray cans, fire extinguisher refill cartridges, etc. in the Freezer.
• Do not place carbonated or fizzy drinks in the Freezer compartment. Ice lollies can cause “Frost/Freeze burns”. If consumed straight from the Freezer.
• Do not remove items from the Freezer compartment if your hands are damp/wet, as this could cause skin abrasions or “Frost/Freezer burns”. Bottles and cans must not be placed in the Freezer compartment as they can burst when the contents freeze.
• The manufacturer’s recommended storage times should be adhered to. Refer to relevant instructions.
• Do not allow children to tamper with the controls or play with the Freezer. The Freezer is heavy. Care should be taken when moving it. It is dangerous to alter the specification or attempt to modify this product in any way.
• Do not store inflammable gases or liquids inside your Freezer.
• If the power cable is damaged, it must be replaced by the manufacturer, its service agent, or similarly qualified persons to avoid a hazard.
• This appliance can be used by children aged 8 years and above and persons with reduced physical, sensor,y or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning g use of the appliance safely and understand the hazards involved. Children shall not play with the appliance. Cleaning and maintenance shall not be done by children without supervision.
• This refrigerating appliance is not intended to be used as a built-in appliance.
• This appliance is intended to be used in household and similar applications such as
  • staff kitchen areas in shops, offices, and other working environments;
  • farmhouses and by clients in hotels, motels, and other residential-type environments;
  • bed and breakfast type environments;
  • catering and similar non-retail applications.
• Keep ventilation openings, in the appliance enclosure or the built-in structure, clear of obstruction.
• Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
• Do not damage the refrigerant circuit.
• Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.
• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory, or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instruction concerning the use of the appliance  by a person responsible for their safety. Children should be supervised to ensure that they do not play with the appliance.
  • WARNING: Keep ventilation openings, in the appliance enclosure or the built-in structure, clear of obstruction.
  • WARNING: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
  • WARNING: Do not damage the refrigerant circuit.
  • WARNING: Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.
  • WARNING: Refrigerating appliances – in particular, a refrigerator-freezer Type I – might not operate  consistently (possibility of defrosting of contents or temperature becoming too warm in the frozen food compartment) when  sited for an extended period below the cold end of the range of temperatures for which the refrigerating appliance is designed;
  • WARNING: The necessity, for doors or lids fitted with locks and keys, the keys be kept out of the reach of children and not in the vicinity of the refrigerating appliance, to prevent children from being locked inside.
  • WARNING: The refrigerant used in your appliance and insulation materials requires special disposal procedures.
  • WARNING: When positioning the appliance, ensure the supply cord is not trapped or damaged.
  • WARNING: Do not locate multiple portable socket outlets or portable power supplies at the rear of the appliance Children aged from 3 to 8 years are allowed to load and unload refrigerating appliances. To avoid contamination of food,  please respect the following instructions:
  • Opening the door for long periods can cause a significant increase in the temperature in the compartments of the appliance.
  • Clean regular surfaces that can come in contact with food and accessible drainage systems.
  • Clean water tanks if they have not been used for 48 hours; flush the water system connected to a water supply if water has not been drawn for 5 days.
  • Store raw meat and fish in suitable containers in the refrigerator, so that it is not in contact with or drip onto other food.
  • Two-star frozen-food compartments are suitable for storing pre-frozen food, storing or making ice cream, and making ice cubes.
  • One-, two- and three-star compartments are not suitable for the freezing of fresh food.
  • If the refrigerating appliance is left empty for long periods, switch it off, defrost, clean, dry, and leave the door open to prevent mold from developing within the appliance.

Climate Range
The information about the climate range of the appliance is provided on the rating plate. It indicates at which ambient temperature (that is, room temperature, in which the appliance is working) the operation of the appliance is optimal (proper).

Note： Given the limit values of the ambient temperature range for the climate classes for which the refrigerating appliance is designed and the fact that the internal temperatures could be affected by such factors as the location of the refrigerating appliance, ambient temperature, and the frequency of door opening, the setting of any temperature control device might have to be varied to allow for these factors, if appropriate. If the power cable is damaged, it must be replaced by the manufacturer, its service agent, or similarly qualified persons to avoid a hazard.

Note: When operating in an environment other than the specified climate type (i.e., beyond the rated ambient temperature range), the appliance may not be able to maintain the desirable compartment temperatures.

Grounding requirement
Your refrigerator must be grounded. Your refrigerator is equipped with a cord having a grounding wire with a grounding plug. The plug must be inserted into an outlet that is correctly installed and grounded.  Incorrect use of the grounding plug can result in a risk of electric shock. Consult a qualified electrician or service person if the grounding instructions are not completely understood, or if doubt exists as to whether your refrigerator is correctly grounded.

Locks
If your Refrigerator is fitted with a lock, keep the key out of reach and not in the vicinity of the appliance to prevent children from being entrapped. When disposing of an old Refrigerator, break off any old locks or latches as a safeguard.

Freon-free
The freon-free refrigerant (R600a) and the foaming insulation material (cyclopentane) that is environmentally friendly are usedfor the refrigerator, causing no damage to the ozone layer and having a very small impact on global warming. R600a is flammable, and sealed in a refrigeration system, without leakage during normal use. But, in case of refrigerant leakage due to the refrigerant circuit being damaged, be sure to keep the appliance away from open flames and open the windows for ventilation as quickly as possible.

NAMES OF THE PARTS

WARNING: Never touch the interior of the Freezer Chamber or frozen foods in the compartment with wet hands as this could result in frostbite.

TRANSPORTATION INSTRUCTIONS

The appliance should be transported only in a vertical upright position. The packing as supplied must be intact during train sportation. If during transport, the product has been transported horizontally, it must only be laid on its left-hand side (when facing the door front) and it must not be operated for at least 4 hours to allow the system to settle after the appliance is brought back to an upright position.

1. Failure to comply with the above instructions could result in damage to the appliance. The manufacturer will not be held responsible if these instructions are disregarded.
2. The appliance must be protected against rain, moisture, and other atmospheric influences.

• IMPORTANT: Care must be taken while cleaning/carrying the appliance to avoid touching the condenser metal wires at the back of the appliance, as you might injure your fingers and hands or damage your product.
• IMPORTANT: This appliance is not designed for stacking with any other appliance. Do not attempt to sit or stand on top of your appliance as it is not designed for such use. You could injure yourself or damage the appliance.
• IMPORTANT: Make sure that the mains cable is not caught under the appliance during and after carrying/moving the appliance,  to avoid the mains cable becoming cut or damaged.” When positioning your appliance take care not to damage your flooring, pipes, wall coverings, etc. Do not move the appliance by pulling the lid or handle. Do not allow children to play with the appliance or tamper with the controls. Our company declines to accept any liability should the instructions not be followed.

INSTALLATION INSTRUCTIONS

1. If possible, avoid placing the appliance near cookers, radiators, or in direct sunlight as this will cause the compressor to run for long periods. If installed next to a source of  heat or refrigerator, maintain the following minimum side clearances:

   • From Cookers 4″ (100 mm)
   • From Radiators 12″ (300 mm)
   • From Fridges 4″ (100 mm)

2. Make sure that sufficient room is provided around the appliance to ensure free air circulation. Ideally, A space of no less than 10cm must be left around the freezer, and ensure you allow gaps as shown in
   the below diagram.

3. 3. The appliance should be located on a smooth surface.
   4. It is forbidden to use the refrigerator outdoors.
   5. Protection from moisture. Do not locate the freezer in a moist space to avoid the metal parts rusty. Do not spray water
   on the freezer, otherwise, it will weaken the insulation and cause current leakage.
   6. Refer to the “Cleaning and Care” section to prepare your appliance for use.
   7. If the freezer is installed in unheated areas, garages, etc., in cold weather condensation may form on the outer surfaces.
   This is quite normal and is not a fault. Remove the condensation by wiping it with a dry cloth.

STARTING
Before you start to use the freezer,

1. Check that the interior is dry and air can circulate freely at the rear.
2. Clean the interior as recommended under “CLEANING AND CARE”.
3. Insert the plug into the wall socket and switch on the electricity supply， then the green light is on.
4. You will hear a noise as the compressor starts up. The liquid and gases sealed within the refrigeration system may also give rise to noise, whether the compressor is running or not which is quite normal.
5. If you going to store already frozen food, open the freezer lid and check that the freezer has reached the correct temperature. Then you can put in your already frozen food.
6. Do not load the appliance immediately after it is switched on. Wait until the correct storage temperature has been reached. We recommend that you check the temperature with an accurate thermometer.

Important Notes:

• In case of a power failure, do not open the lid. Frozen food will not be affected if the failure lasts for less than 20 hours. If the failure is longer, then the food should be checked and eaten immediately, or cooked and then refrozen.
• If the lid of the chest freezer is difficult to open just after being closed, don’t worry. This is due to the pressure difference, which will equalize after a few minutes, allowing the lid to be opened normally.

FREEZER OPERATION

The inside temperature of the freezer is regulated by the thermostat adjustment knob. “1,2,3,4,5,6,7” marks on the knob do not represent the exact temperature values. The smaller the number, the higher the temperature.

The figures are as follows:

• “1-3”: Temperature range(10℃~-2℃)
• “3-5”: Temperature range (-2℃~-12℃)
• “5-7”: Temperature range (-12℃~-26℃)
• “7 “: Temperature range (below-26℃)

There is a deviation of±3℃ for each temperature mode in different usage environments due to the mechanical control mode. Please make fine adjustments according to the actual use condition.

Deep freeze (below -24℃): When setting the knob to the Deep-freezing range, Maybe the compressor continuously operates without stopping, and the food can be quickly cooled down. Caution: Do not keep the knob at the Deep- freezing position after deep freezing.

Refrigeration mode conversion
When shifting from the refrigerator mode to other modes, be sure to take out the fresh storage food in time to avoid frost damage. When shifting from the freezer mode or soft freeze mode to the refrigerator mode, take the following steps set the thermostat knob to the refrigerator range, remove all the frozen food, leave the cabinet empty for about 1 hour, and then put it in the food for fresh storage.

• Due to individual factors of the refrigerator, the actual temperature in the box may have a certain error from the set temperature, which is a normal phenomenon and does not affect the normal use of the product.

STORING FROZEN FOOD
Prepackaged commercially frozen food should be stored according to the frozen food manufacturer’s instructions for the freezer compartment. To ensure high quality is achieved by the frozen food manufacturer and the food retailer, the following should be remembered:

1. Put packets in the freezer as quickly as possible after purchase.
2. Do not exceed the “Use By”, and “Best Before” dates on the packaging.

FREEZING FRESH FOOD
Place fresh food to be frozen near the side walls to ensure fast freezing and away from the frozen food, if possible. Never exceed this maximum capacity. Do not freeze too large a quantity at any one time.  The quality of the food is best preserved when it is frozen right through to the center as quickly as possible. Take special care not to mix frozen food and fresh food.

DEFROSTING
Defrost twice a year or when a frost layer of around 7 mm (1/4”) has been formed. Alternatively, you may switch off the freezer at the socket outlet and pull out the mains plug. Extract the water conduit and put it in a water container. 6 hours before the defrosting, please set the thermostat knob at the “7” position to make sure the food is at the lowest temperature when taken out. All food should be wrapped in several layers of newspaper and stored in a cool place (e.g., fridge or larder). Remove the freezer basket, and leave the lid open. Containers of warm water may be placed carefully in the freezer to speed up the defrosting. Never use hairdryers, electrical heaters, or other such electrical appliances for defrosting. When defrosting is finished, flow out the defrost water which is collected at the bottom of the freezer as the below diagram, and dry the interior thoroughly. Switch on the Fast Freeze and leave it on for about three hours.

1. A drain outlet is designed at the bottom of the freezer liner, and when defrosting, remove its rubber cover, then defrosting water flows out and is discharged from the drain pipe.
2. Extract the water conduit by 20-25mm until the water hole can be seen.
3. Twist the water conduit until the arrow points downward.
4. After defrosting is done, make sure there is no more water coming out before putting the water conduit in place and making the arrow point upward. How to use the ice-making box Place the ice-making box in the upper position of the freezer compartment, so that it ices up as soon as possible.

Important Notes

• Do not use pointed or sharp-edged objects such as knives or forks to remove the frost.
• Never use hairdryers, electrical heaters, or other such electrical appliances for defrosting.
• Normally, water beads or frosts appear on the freezer collar and door gaskets in wet weather, which will not affect normal use. In such case, please clean it with a dry cloth in time!

CLEANING AND CARE

• We recommend that you switch off the freezer at the socket outlet and pull out the main plug before cleaning.
• Never use any sharp abrasive instrument, soap, household cleaner, detergent, or wax polish for cleaning.
• Use lukewarm water to clean the cabinet of the freezer and wipe it dry.
• Use a damp cloth wrung out in a solution of one teaspoon of bicarbonate of soda to one pint of water to clean the interior and wipe it dry.
• Excess deposits of ice should be removed regularly using a plastic ice scraper available from your local store. A large accumulation of ice will impair the performance of the freezer.
• If the freezer is not going to be used for a long period switch it off, remove all food, clean it, and leave the lid ajar.
• Check lid seals regularly to ensure they are clean and free from food particles.

Important Notes:
Never use water to wash the compressor position, wipe it with a dry cloth thoroughly after cleaning to prevent rust.

DO’S AND DON’TS

• Do –Defrost food from the freezer thoroughly in a fridge or a microwave oven following defrosting and cooking instructions.
• Do – Ensure that the chest freezer lid is completely closed after each use.
• Do – Defrost frozen meat completely before cooking.
• Do – Close the lid gently.
• Do – Check the contents of the freezer at regular intervals.
• Do – Clean and defrost your freezer regularly (See “Defrosting”)
• Do – Keep food for as short a time as possible and adhere to “Best Before”, and “Use By” dates.
• Do – Store commercially frozen according tod by the instructions given on the packets that you buy.
• Do – Always choose high-quality fresh food and be sure it is thoroughly clean before you freeze it.
• Do – Prepare fresh food for freezing in small portions to ensure rapid freezing.
• Do – Wrap all foods in aluminum foil or freezer-quality plastic bags and make sure any air is excluded.
• Do – Wrap frozen food when you buy it and put it into the freezer as soon as possible.
• Do – Store small items in the basket provided.
• Do – Remove ice cream from the freezer 10-20 minutes before serving.
• Don’t – Leave the lid open for long periods as this will make the freezer more costly to run and cause excessive ice formation.
• Don’t – Use pointed sharp-edged objects such as knives, and forks to remove the ice.
• Don’t – Put hot food in the freezer. Let it cool down first.
• Don’t – Put liquid-filled bottles or sealed cans containing carbonated liquids into the freezer as they may burst.
• Don’t – Store poisonous or dangerous substances in the freezer. Your freezer has been designed for the storage of edible foodstuffs only.
• Don’t – Consume ice cream and water ice directly from the freezer. The low temperature may cause ‘freezer burns’ on the lips.
• Don’t – Freeze fizzy drinks.
• Don’t – Try to keep frozen food that has thawed, it should be eaten within 24 hours or cooked and refrozen.
• Don’t – Remove items from the freezer with wet hands.
• Don’t – Shut the lid with force. You will damage the appliance.
• This appliance is not intended for use by persons(including children) with reduced physical, sensory, or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instruction concerning uthe useof the appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play with the appliance.
• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
• This appliance is intended to be used in households and similar applications such as staff kitchen areas in shops, offices, and ther working environments in houses and by clients in hotels, motels, and other residential-type environments; bed and breakfast-type environments catering and similar non-retail applications.
• If the supply cord is damaged, it must be replaced by a manufacturer, its service agent, or a similarly qualified personstoo avoid a hazard.

Certifications
Electrical information
This electrical appliance must be grounded. This product is equipped with a plug, which is suitable for all houses equipped with sockets meeting the current specifications the fitted plug is not suitable for your socket outlets, it should be cut off and carefully disposed of. To avoid a possible shock hazard, do not insert the discarded plug into a socket.  This product complies with the EEC directives.

Correct Disposal of this product
This marking indicates that this product should not be disposed of with other household wastes throughout the EU. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmentally safe recycling.

Warnings for disposal

• Refrige rant and cyclopentane foaming material used for here frigeratorare flammable Therefore, when there frigerato risscrapped itshallbekeptawayfrom any fire source and can be recovered by the special recovering company with corresponding ding qualifications then be disposed of by combustion,soast oprevent damage to the environment or any other harm.
• When there frigera to riss crapped, disassemble the doors, and remove the gasket of the door and shelves; put the door and shelve in the proper place, to prevent trapping of any child.

Main technical parameters

Model

Parameter

| SZCF-102-WE3| SZCF-152-WE3| SZCF-202-WE3| SZCF-302-WE3
---|---|---|---|---
Climate| SN/N/ST/T| SN/N/ST/T| SN/N/ST/T| SN/N/ST/T
Total gross volume| 99L| 137L| 194L| 291L
Total storage volume| 99L| 137L| 194L| 291L
Rated voltage| 220-240V| 220-240V| 220-240V| 220-240V
Rated Frequency| 50Hz| 50Hz| 50Hz| 50Hz
Ratedcurrent| 0.4A| 0.5A| 0.8A| 1.0A
Refrigerant&Weight| R600a 50g| R600a 60g| R600a 65g| R600a 75g
Weight| 20kg| 23kg| 27kg| 34kg
Physical vesicant| CYCLOPENTANE| CYCLOPENTANE| CYCLOPENTANE| CYCLOPENTANE

References

• Strona główna - Smith Brown

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>