EXPERT GRILL 720-0864T Outdoor Gas Grill User Guide

EXPERT GRILL 720-0864T Outdoor Gas Grill

Specifications

• Model Number: 720-0864T
• Manufacturer: Expert Grill
• Product Type: Outdoor Gas Grill
• VSN: XG1136207123008

Product Information

The Expert Grill 720-0864T is a high-quality outdoor gas grill designed for grilling enthusiasts. With its sturdy construction and efficient design, this grill offers a reliable cooking experience for all your outdoor gatherings.

Safety Instructions:

It is crucial to follow all safety instructions provided in the manual to ensure safe operation of the grill. Failure to comply with safety guidelines could result in serious injury or property damage.

Danger:

Do not operate the grill unattended. Keep the grill at a safe distance from structures, combustible materials, and other gas cylinders. Do not overfill the cooking vessel. Heated liquids can
cause severe burns. Do not attempt to extinguish an oil or grease
fire with water.

Warning:

Avoid storing or using flammable liquids near the grill. Do not
store unconnected LP cylinders near the appliance. Do not lean over
the cooking area while the grill is in operation. Do not touch hot
surfaces until the grill has cooled down.

California Residents Warning:

California residents should be aware of potential exposure to chemicals that can cause cancer and reproductive harm. Refer to www.P65Warnings.ca.gov for more information.

Caution:

Be cautious of flashback incidents due to gas flow obstructions caused by spiders or insects nesting in burner tubes. Regular cleaning is essential to prevent such occurrences.

Product Usage Instructions

Lighting Instructions:

Before lighting the grill, carefully read the lighting instructions provided in the manual to ensure safe ignition.

Purging Procedure:

To eliminate excessive humming noise or gas flow issues, purge air from the gas line or reset the regulator when connecting a new LP gas tank.

Burner Tube Cleaning:

Clean the burner tubes before assembling the grill and perform monthly cleanings, especially in late summer or early fall when spiders are active. If the grill has not been used for an extended period, clean the tubes to prevent fire hazards.

Frequently Asked Questions

• Q: How often should I clean the burner tubes?
  • A: It is recommended to clean the burner tubes before assembling the grill and perform monthly cleanings, especially during spider activity seasons.
• Q: What should I do in case of excessive humming noise from the gas line?
  • A: You may need to purge air from the gas line or reset the regulator when connecting a new LP gas tank to resolve excessive humming noise issues.

Safety Instruction

DANGER
If you smell gas: · Shut off gas to the appliance. · Extinguish any open flame. · Open lid. · If odor continues, keep away from the
appliance and immediately call your gas supplier or your fire department.

WARNING
1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

DANGER
1. Never operate this appliance unattended. 2. Never operate this appliance within 3.05 m / 10 ft. of any structure, combustible material or
other gas cylinder. 3. Never operate this appliance within 7.62 m / 25 ft. of any flammable liquid. 4. Do not fill cooking vessel beyond maximum fill line. 5. Heated liquids remain at scalding temperatures long after the cooking process. Never
touch cooking appliance until liquids have cooled to 45ºC / 115ºF or less. 6. This appliance is not intended for and should never be used as a heater. 7. If a fire should occur, keep away from the appliance and immediately call your fire
department. Do not attempt to extinguish an oil or grease fire with water.
Failure to comply with these instructions could result in a fire or explosion that could cause serious bodily injury, death, or property damage.
Your grill will be very hot. Never lean over the cooking area while using your grill. Do not touch cooking surfaces, grill housing, lid or any other grill parts while the grill is in operation, or until the gas grill has cooled down after use.
CALIFORNIA RESIDENTS ONLY – WARNING: This product and the fuels used to operate this product (liquid propane), and the products of combustion of such fuels, can expose you to chemicals including benzene, which is known to the State of California to cause cancer and reproductive harm. For more information go to: www.P65Warnings.ca.gov.
In the State of Massachusetts, the following installation instructions apply: · Installations and repairs must be performed by a qualified or licensed contractor, plumber,
or gasfitter qualified or licensed by the State of Massachusetts. · If using a ball valve, it shall be a T-handle type. · A flexible gas connector, when used, must not exceed 3 feet.

3

WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual.
TESTED IN ACCORDANCE WITH ANSI Z21.58-2018 · CSA 1.6-2018 STANDARD FOR OUTDOOR COOKING GAS APPLIANCE. THIS GRILL IS FOR OUTDOOR USE ONLY.
Grill Installation Codes Check your local building codes for the proper method of installation. in the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI /NFPA B149.2 or CSA B149.1 Natural Gas and Propane Installation Code, and the National Electrical Code, ANSI/NFPA 70. Correct LP Gas Tank Use LP gas grill models are designed for use with a standard 20 lb. Liquid Propane Gas tank, not included with grill. Never connect your gas grill to an LP gas tank that exceeds this capacity.
NOTE: The normal flow of gas through the regulator and hose assembly can create a humming noise. A low volume of noise is perfectly normal and will not interfere with operation of the grill. If humming noise is loud and excessive you may need to purge air from the gas line or reset the regulator excess gas flow device. This purging procedure should be done every time a new LP gas tank is connected to your grill.

CAUTION: Beware of Flashback
CAUTION: Spiders and small insects occasionally spin webs or make nests in the grill burner tubes during transit and warehousing. These webs can lead to gas flow obstruction, which could result in a fire in and around burner tubes. This type of fire is known as “FLASH-BACK” and can cause serious damage to your grill and create an unsafe operating condition for the user.
Although an obstructed burner tube is not the only cause of “FLASH-BACK”, it is the most common cause.
To reduce the chance of “FLASH-BACK”, you must clean the burner tubes before assembling your grill, and at least once a month in late summer or early fall when spiders are most active. Also perform this burner tube cleaning procedure if your grill has not been used for an extended period of time. A clogged tube can be lead to a fire beneath the grill.

Visually check the burner flames prior to each use. The flames should look like this picture. If they do not, refer to the burner main tenancy part of this manual.

4

LP-Gas Supply System

· If the information is not followed

exactly, a fire resulting in death or serious injury could occur.

304.8 mm / 12 in.

· A 20lb tank of approximately 304.8 mm

/ 12 in diameter by 469.9 mm / 18.5 in

high is the maximum size LP gas tank to use.

· The LP gas supply cylinder to be used must be

constructed and marked in accordance with the

specifications for LP ­Gas cylinder of the U.S.

Department of Transportation (DOT) or the National

Standard of Canada ,CAN/CSA ­B339, Cylinders,

Spheres and Tubes for Transportation of Dangerous

Goods and Commission .

· The LP gas tank must have a shutoff valve terminating

in an LP valve outlet that is compatible with a Type 1. LP

gas supply cylinder must have a shut off valve

terminating in a valve outlet specified for connection type

QCC1 in the standard for compressed gas cylinder valve

outlet and inlet connection ANSI/CGA-V-1 as applicable.

LP gas supply cylinder must be fitted with an Overfill

Protection Device (O.P.D) The LP gas tank must also

have a safety relief device that has a direct connection

with the vapor space of the tank. This safety feature

prevents the tank from being overfilled, which can cause

malfunction of the LP gas tank, regulator and/or grill.

· The tank supply system must be arranged for vapor

withdrawal.

· The LP gas tank used must have a collar to protect the

tank valve.

· Place dust cap on cylinder valve outlet whenever the

cylinder is not in use. Only install the type of dust cap on

the cylinder valve outlet that is provided with the

cylinder valve. Other types of cap or plugs may result in

leakage of propane.

· Never connect an unregulated LP gas tank to your gas

grill.

· This outdoor cooking gas appliance is equipped with a

high capacity hose/regulator assembly for connection to

a standard 20 lb Liquid propane cylinder.

· Have your LP gas tank filled by a reputable propane gas

dealer and visually inspected and re-qualified at each

filling.

· Do not store a spare LP gas cylinder under or near this

appliance.

· Never fill the cylinder beyond 80 percent full.

· Always keep LP gas tanks in an upright position.

· Do not store or use gasoline or other flammable vapors

and liquids in the vicinity of this or any other appliance.

· Storage of an outdoor cooking gas appliance indoors is

permissible only if the cylinder is disconnected and

removed from the outdoor cooking gas appliance.

· When your gas grill is not in use the gas must be turned

off at LP gas tank.

Proper Placement And Clearance Of Grill

· Never use your gas grill in a garage, porch, shed, breezeway or any other enclosed area. Your gas grill is to be used outdoors only. Do Not install this unit into combustible enclosures. Minimum clearance from sides and back of unit to combustible construction, 91 cm / 36 in. from sides and 91 cm / 36 in. from back.

469.9 mm / 18.5 in.

· DO NOT use this appliance under overhead combustible surfaces. This outdoors cooking gas appliance is not intend to be installed in or on recreational vehicles and/or boats.
· LP gas tank must be stored outdoors in a well-ventilated area and out of reach of children. Disconnected LP gas tanks must not be stored in a building, garage or any other enclosed area.
· Do Not obstruct the flow of ventilation air around the gas grill housing. Only use the regulator and the hose assembly supplied with your gas grill. Replacement regulators and hose assemblies must be those specified in this manual.
· The regulator and hose assembly must be inspected before each use of the grill. If there is excessive abrasion or wear or if the hose is cut, it must be replaced prior to the grill being put into operation. The replacement hose assembly shall be that specified by the manufacturer.
· Pressure regulator and hose assembly supplied with the outdoor cooking gas appliance must be used. Never substitute other types of regulator. Contact customer service for manufacturer specified replacement parts.
· This outdoor cooking gas appliance is equipped with a pressure regulator comply with the standard for Pressure Regulating Valves for LP Gas ANSI/ UL 144.
· Do not use briquettes of any kind in the grill. · The grill is designed for optimum performance without
the use of briquettes. Do not place briquettes on the radiant as this will block off the area for the grill burners to vent. Adding briquettes can damage ignition components and knobs, and void the warranty. · Keep the back and side cart free and clear from debris. Keep any electrical supply cord, or the rotisserie motor cord away from the heated areas of the grill. · Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.) a windbreak will be required. Always adhere to the specified clearance. · Never use a dented or rusty propane tank. · Keep any electrical supply cord and the fuel supply hose away from any heated surface. · While lighting, keep your face and hands as far away from the grill as possible. · Burner adjustment should only be performed after the burner have cooled.
WARNING Your grill will get very hot. Never lean over the cooking area while using your grill. Do not touch cooking surfaces, grill housing, lid or any other grill parts while the grill is in operation, or until the gas grill has cooled down after use.
Failure to comply with these instructions may result in serious bodily injury.

5

WARNING Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use.
WARNING This outdoor cooking gas appliance is not intended to be installed in or on boats. And other recreational vehicles.
DO NOT USE ALUMINUM FOIL TO LINE THE GRILL RACKS OR GRILL BOTTOM. This can severely upset combustion airflow or trap excessive heat in the control area.

When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place or potholders. Do not allow potholders to touch hot portions of the grill rack.
Grease is flammable. Let hot grease cool before attempting to handle it. Do not allow grease deposits to collect in the grease tray at the bottom of the grill’s firebox. Clean the grease tray often
Do not use aluminum foil to line the grill racks or grill bottom. This can severely upset combustion air flow or trap excessive heat in the control area.

SAFETY PRACTICES TO AVOID PERSONAL INJURY
When properly cared for your grill will provide safe, reliable service for many years. However, extreme care must be used as the grill produces intense heat that can increase accident potential. When using this appliance basic safety practices must be followed, including the following: Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician. This grill is not intended to be installed in or on recreational vehicles or boats.
Children should not be left alone or unattended in an area where the grill is being used. Do not allow them to sit, stand or play in or around the grill at any time. Do not store items of interest to children around or below the grill.
Do not permit clothing, pot holders or other flammable materials to come in contact with or too close to any grate, burner or hot surface until it has cooled. The fabric could ignite and cause personal injury.
For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.
Only certain types of glass, heat-proof glass ceramic, earthenware, or other glazed utensils are suitable for grill use. These materials may break with sudden temperature changes. Use only on low or medium heat settings in accordance with the manufacturer’s guidelines.
Do not heat unopened food containers. A build-up of pressure may cause the containers to burst.
Use a covered hand when opening the grill lid. Never lean over an open grill.
When lighting a burner, pay close attention to what you are doing. Make certain you are aware of which burner you are lighting, so your body and clothing remain clear of open flames.

For proper lighting and performance of the burners keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation.

Clean the grill with caution. To avoid steam burns, do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce toxic fumes or can ignite if applied to a hot surface.

Turn off grill controls and make certain the grill is cool before using any type of aerosol cleaner on or around the grill. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode.

Do not use the grill to cook excessively fatty meats or other products which promote flare-ups.

Do not operate the grill under unprotected combustible constructions. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas.

Keep the area surrounding the grill free from combustible materials including, fluids, trash, and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air.

NEVER CONNECT AN UNREGULATED GAS SUPPLY LINE TO THE APPLIANCE. USE THE REGULATOR/HOSE ASSEMBLY SUPPLIED.

This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill has been reconfigured for natural gas use.

Total gas consumption (per hour) of this stainless steel gas grill with all burners on “HIGH”:

Main burner Total

2 x 14,000 Btu/hr (each) 28,000 Btu/hr

6

Gas Hook-Up

L.P. TANK REQUIREMENT
A dented or rusty L.P. tank may be hazardous and should be checked by your L.P. supplier. Never use a cylinder with a damaged valve. The L.P. gas cylinder must be constructed and marked in accordance with the specifications for L.P. gas cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission, as applicable. Overfilling prevention device (OPD) shall be provided on cylinder & QCCI connection on the cylinder valve, ANSI/CGA-V-1. The cylinder supply system must be arranged for vapor withdrawal. The cylinder must include a collar to protect the cylinder valve. The cylinder must be provided with a shut off valve terminal in an L.P. gas supply cylinder valve outlet specified, as applicable, for connection type QCC1 in the standard for compressed gas cylinder valve outlet and inlet connection ANSI/CGA-V-1. Manifold pressure: 11″ water column (W.C.).
L.P. GAS HOOK-UP
Ensure that the black plastic grommets on the LP cylinder valve are in place and that the hose does not come into contact with the grease tray or the grill head.
CONNECTION
Your stainless steel grill is equipped with gas supply orifices for use only with liquid propane gas. It is also equipped with a high capacity hose/regulator assembly for connection to a standard 20lb. L.P. cylinder 469.9 mm / 18-1/4 in. high, 304.8 mm / 12-1/4 in. diameter). To connect the L.P. gas supply cylinder, please follow the steps below:
1. Make sure tank valve is in its full off position (turn clockwise to stop)
2. Check tank valve to assure it has proper external male threads (type 1 connection per ANSIZ21.81)

3. Make sure all burner valves are in their off position. 4. Inspect valve connections, port, and regulator assembly.
Look for any damage or debris. Remove any debris. Inspect hose for damage. Never attempt to use damaged or obstructed equipment. See your local L.P. gas dealer for repair. 5. When connecting regulator assembly to the valve, hand tighten the quick coupling nut clockwise to a complete stop. Do not use a wrench to tighten. Use of a wrench may damage the quick coupling nut and result in a hazardous condition. 6. Open the tank valve fully (counterclockwise). Apply the soap solution with a clean brush to all gas connections. See below. If growing bubbles appear in the solution the connections are not properly sealed. Check each fitting and tighten or repair as necessary. 7. If you have a gas connection leak you cannot repair, turn gas OFF at supply tank, disconnect fuel line from your grill and call 1-800-913-8999 in USA or your gas supplier for repair assistance. 8. Also apply soapy solution to the tank seams. See below. If growing bubbles appear, shut tank OFF and do not use or move it! Contact an LP gas supplier or your fire department for assistance.
To disconnect L.P. gas cylinder: 1. Turn the burner valves off. 2. Turn the tank valve off fully (turn clockwise to stop). 3. Detach the regulator assembly from the tank valve by
turning the quick coupling nut counterclockwise.

Installer Final Check List

Minimum clearance from sides and back of unit to combustible construction, 91 cm / 36 in. from sides and 91 cm / 36 in. from back
All internal packaging removed. Knobs turn freely. Burners are tight and sitting properly on orifices.
Pressure regulator connected and set. Gas connections to grill using hose & regulator assembly provided (pre-set for 11 in. water column).
Unit tested and free of leaks. User informed of gas supply shut off valve location

USER, PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE.
PROPANE CYLINDER CAUTIONS
a) DO NOT store a spare LP-gas cylinder under or near this appliance.
b) NEVER fill the cylinder beyond 80 percent full.
c) If the information in “a” and “b” is not followed exactly, a fire or explosion causing death or serious injury may occur.

7

Leak Testing

GENERAL
Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas leak test check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks following the procedures listed below. If the smell of gas is detected at anytime you should immediately check the entire system for leaks.
BEFORE TESTING
Make sure that all packing material is removed from the grill including tie- down straps. DO NOT SMOKE WHILE LEAK TESTING. NEVER PERFORM LEAK TEST WITH AN OPEN FLAME. Make a soap solution of one part liquid detergent and one part water. You will need a spray bottle, brush, or rag to apply the solution to the fittings. For the initial leak test, make sure the L.P. cylinder is 80% full.
TO TEST
1. Make sure the control valves are in the “OFF” position, and turn on the gas supply.
2. Check all connections from the L.P. gas regulator and supply valve up to and including the connection to the manifold pipe assembly (the pipe that goes to the burners). Soap bubbles will appear where a leak is present.
3. If a leak is present, immediately turn off the gas supply and tighten the leaky fittings.
4. Turn the gas back on and recheck. 5. Should the gas continue to leak from any of the fittings,
turn off the gas supply and contact customer service at 1-800-913-8999 in USA.

ALWAYS CHECK FOR LEAKS AFTER EVERY L.P. TANK CHANGE
Check all gas supply fittings for leaks before each use. It is handy to keep a spray bottle of soapy water near the shut-off valve of the gas supply line. Spray all the fittings. Bubbles indicate leaks.
Your grill is ready to use!

Only those parts recommended by the manufacturer should be used on the grill. Substitution will void the warranty. Do not use the grill until all connections have been checked and do not leak. GAS FLOW CHECK Each grill burner is tested and adjusted at the factory prior to shipment; however, variations in the local gas supply may make it necessary to adjust the burners. The flames of the burners should be visually checked. Flames should be blue and stable with no yellow tips, excessive noise or lifting. If any of these conditions exist, check to see if the air shutter or burner ports are blocked by dirt, debris, spider webs, etc. If you have any questions regarding flame stability, please call customer service at 1-800-913-8999 in USA.
8

Operating Instructions

GENERAL USE OF THE GRILL
Each main burner is rated at 12,000 BTU/HR. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. The knobs are located on the lower center portion of the control panel. Each knob is labeled on the control panel.
USING THE GRILL
Grilling requires high heat for searing and proper browning. Most foods are cooked at the “HIGH” heat setting for the entire cooking time. However, when grilling large pieces of meat or poultry, it may be necessary to turn the heat to the lower setting after the initial browning. This cooks the food through without burning the outside. Foods cooked for a long time or foods basted with a sugary marinade may need the lower heat setting near the end of the cooking time. NOTE: This grill is designed to grill efficiently without the use of lava rocks or briquettes of any kind. Heat is radiated by the stainless steel flame tamers positioned above each burner.

NOTE: The hot grill sears the food, sealing in the juices. The more thoroughly the grill is preheated, the faster the meat browns and the darker the grill marks.
DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING.
Lighting Instructions

WARNING: IMPORTANT!
BEFORE LIGHTING
Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose assembly supplied with the unit should be used. Never substitute regulators and hose assembly for those supplied with the grill. If a replacement is necessary, contact the manufacturer for proper replacement. The replacement must be that specified in the manual.
WARNING
Always keep your face and body as far away from the burner as possible when lighting.
TO LIGHT THE MAIN BURNER
Make sure all knobs are off then turn on the gas supply from the LP (Liquid Propane) tank. Always keep your face and body as far from the grill as possible when lighting.
LIGHTING INSTRUCTIONS:
1. Open lid before lighting.
2. Check control knobs are all OFF and then turn on the gas supply.
3. Push and turn the knob slowly to HIGH. The burner should ignite within three attempts.
4. If burner does not ignite, turn the knob to OFF, wait 5 minutes and then repeat step 3.

Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use.
Do not attempt to light the grill if odor of gas is present. Call for service 1-800-913-8999.
Each burner is adjusted prior to shipment; however, variations in the local gas supply may make minor adjustments necessary.
CAUTIONS Place dust cap on cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. The gas must be turned off at the supply cylinder when the unit is not in use. If the appliance is stored indoors the cylinder must be disconnected and removed from the appliance. Cylinders must be stored outdoors in a well-ventilated area out of the reach of children.

9

Match Light
1. If the burner will not light after several attempts then the burner can be match lit, before using the match allow 5 minutes for any accumulated gas to dissipate.
2. Clip a match on one end of the lighting rod. 3. Light match. 4. Hold lighting rod and insert lighted match right
next to the burner ports. 5. Push and turn the designated control knob to
HIGH. 6. Burner should ignite immediately.

Main burner

Component Identification
Note: Remove all packaging, including straps, before using the grill

Main Burners

OFF

1. Push 2. Turn knob to HIGH 3. Adjust flame

HIGH

10

Push In
LOW Control Knob

Care and Maintenance

STAINLESS STEEL
There are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. To touch up noticeable scratches in the stainless steel, sand very lightly with dry 100 grit emery paper in the direction of the grain. Specks of grease can gather on the surfaces of the stainless steel and bake on to the surface and give the appearance of rust. For removal use a mild abrasive pad in conjunction with a stainless steel cleaner.
GRILL GRATE
The easiest way to clean the grill is immediately after cooking is completed and after turning off the flame. Wear a barbeque mitt to protect your hand from the heat and steam. Dip a brass bristle barbeque brush in water and scrub the hot grill. Dip the brush frequently in the bowl of water. Steam, created as water contacts the hot grill, assists the cleaning process by softening any food particles. If the grill is allowed to cool before cleaning, cleaning will be more difficult. ENSURE THAT THE GAS SUPPLY AND THE KNOBS ARE IN THE “OFF” POSITION. MAKE SURE THE RANGE TOP BURNER IS COOL BEFORE REMOVAL.
GRILL BURNERS
Extreme care should be taken when moving a burner as it must be correctly centered on the orifice before any attempt is made to relight the grill. Frequency of cleaning will depend on how often you use the grill.
MAIN BURNER CLEANING
Ensure the gas supply is off and the knobs are in the “OFF” position. Make sure the grill is cool. Clean the exterior of the burner with a wire brush. Clear stubborn scale with a metal scraper. Clear any clogged ports with a straightened paper clip. Never use a wooden toothpick as it may break off and clog the port. Please note if insects or other obstructions are blocking the flow of gas through the burner, and if so you will need to call our customer service line at 1-800-913-8999 in USA.

Warning: If you wish to replace main burner, we strongly recommend that you hire a professionally trained technician to replace it. Please understand that we will not be responsible for any liability, personal injury, or property damage resulting from an improperly assembled burner. HOW TO REPLACE MAIN BURNER Step 1. Remove the main burner “R” pin on the back wall of fire box by using needle nose pliers. Use a flathead screwdriver to remove burner pin cover, then remove the burner on the front wall of fire box, as shown below.
Step 2. Insert the burner onto the orifice and secure the burner pin cover on the burner, as shown below, make sure burner hole aim at orifice .
Step 3. Secure the main burner on the back wall of fire box with “R” Pin.

GREASE TRAY CLEANING
The grease tray should be emptied and wiped down periodically and wash with a mild detergent and warm water solution. A small amount of sand may be placed in bottom of grease tray to absorb the grease. Check the grease tray frequently, do not allow excess grease to accumulate and overflow out of the grease tray.

CAUTION 1. Keep outdoor cooking gas appliance area clear and
free from combustible materials, gasoline and other flammable vapors and liquids. 2. Do not obstruct the flow of combustible and ventilation air. 3. Keep the ventilation openings of the cylinder enclosure free and clear from debris.

11

Troubleshooting

SPIDER AND INSECT WARNING
Checking and cleaning burner/ venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill. Although an obstructed burner tube is not the only cause of “FLASH-BACK”, it is the most common cause. To reduce the chance of “FLASH-BACK”, you must clean the burner tubes before assembling your grill, and at least once a month in late summer or early fall when spiders are most active. Also perform this burner tube cleaning procedure if your grill has not been used for an extended period of time.
WHEN TO LOOK FOR SPIDERS
You should inspect the burners at least once a year or immediately after any of the following conditions occur:
1. The smell of gas in conjunction with the burner flames appearing yellow.
2. The grill does not reach temperature. 3. The grill heats unevenly. 4. The burners make popping noises.
BEFORE CALLING FOR SERVICE
If the grill does not function properly, use the following check list before contacting your dealer for service. You may save the cost of a service call. PREHEATING: The grill lid should be in a closed position during the preheat time period. It is necessary to preheat the grill before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking temperature needs a pre-heat period of five minutes; food that requires a lower cooking temperature needs only a period of two to three minutes.

COOKING TEMPERATURES
High setting-Use this setting for fast warm-up, for searing steaks and chops, and grilling. Low setting-Use this setting for all roasting, baking, and when cooking very lean cuts such as fish. These temperatures vary with the outside temperature and the amount of wind. Cooking with in-direct Heat: You can cook poultry and large cuts of meat slowly to perfection on one side of the grill by indirect heat from the burner on the other side. Heat from the lit burner circulates gently throughout the grill, cooking the meat or poultry without any direct flame touching it. This method greatly reduces flare-ups when cooking extra fatty cuts, because there is no direct flame to light the fats and juices that drip down during cooking.
CAUTION: If burners go out during operation, close gas supply at source, and turn all gas valves off. Open lid and wait five minutes before attempting to relight (this allows accumulated gas fumes to clear).
CAUTION: Should a grease fire occur, close gas supply at source, turn off all burners and leave lid closed until fire is out.
CAUTION: DO NOT attempt to disconnect any gas fitting while your grill is in operation. As with all appliances, proper care and maintenance will keep them in top operating condition and prolong their life. Your gas gill is no exception.
CAUTION: Side burner lid will get hot if used when lid is closed.

PROBLEM
When attempting to light my grill, it will not light immediately.
Rotisserie burner will not light when the igniter button is pushed.
Regulator makes noise.
Full size cover does not fit the grill.

SOLUTION
Make sure you have a spark while you are trying to light the burner (if no spark) . Check if the battery is installed properly. Ensure that the wire is connected to the electrode assembly. Clean wire (s) and / or electrode with rubbing alcohol and a clean swab. Wipe with a clean cloth. Check to see if the other burners operate. If so. Check the gas orifice on the malfunctioning burner for an obstruction.
Check to see if debris is blocking the electrode. Check to see if there is a spark that jumps to the burner from the electrode. If no spark is seen, check the battery located inside the igniter box. To open turn counter Does the infrared back burner light when attempting to light with a match ? If not, check to ensure the gas is on.
Vent hose on the regulator may be plugged or regulator may be faulty. Ensure the vent hole on the regulator is not obstructed. Clear the hole, close the gas control valves. Wait ten minutes and re-start. Check your flames for proper performance. If the flames are not correct, replace regulator.
Cover may be incorrect for your grill. It may be a tight fit. Ensure the cover is the correct length for your grill. Measure it left to right. Compare to the grill’s measurement. Compare the location and size of the hood portion of the cover to your grill. Spread the cover and allow it to relax, preferably in warm sunlight or in a warm room. For grill with a side shelf bunch the cover like a sock, put on left to right.

12

PROBLEM
Rotisserie motor will not turn Grill only heats to 93-149°C / 200-300°F.
Grill takes a long time to preheat. Burner flames are not light blue.

SOLUTION
Ensure the motor is connected to a properly grounded power supply. Ensure the on / off switch is in the on position. Ensure that the spit is fully inserted into the rotisserie motor. Ensure that the load does not exceed the 40 pounds operational capacity. Ensure that there is no encumbrance or drag.
Check to see if the fuel hose is bent or kinked. Make sure the grill area is clear of dust. Make sure the burner and orifices are clean. Check for spiders and insects. The regulator has a safety device that restricts the flow of gas in the event of a leak. This safety device can be triggered without a gas leak. To reset the safety device, turn off all burners and close the LP tank valve. Disconnect the regulator from the LP tank and wait one minute. Reconnect the regulator to the LP tank and slowly open the LP tank valve until the valve is fully open. Light all burners and observe the temperature.
Normal preheat 260-316°C / 500-600°F, takes about 10-15 min. Cold weather and wind may effect your preheat time. If you are using volcanic rock or briquettes they can increase the preheat time and maximum temperature.
Too much or not enough air for the flame. Elevation is the principal cause, however cold weather can affect the mixture. Burner adjustment may be required. Grill is in a windy location.

Ordering Parts

HOW TO ORDER REPLACEMENT PARTS
To make sure you obtain the correct replacement part (s) for your gas grill, please refer to the parts list on pages 54. The following information is required to assure getting the correct part. Please note the shipping cost for the delivery of any replacement parts will be on yourself. · Gas grills model number (see data sticker on grill). · Part number of replacement part needed. · Description of replacement part needed. · Quantity of parts needed.

To obtain replacement parts, contact our customer service hotline, U.S.A: 1- 800-913-8999.
IMPORTANT
Use only factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty. Keep this assembly and operating instruction manual for convenient referral, and for replacement parts ordering.

Grill Hints

The doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat.
The cooking time is affected by the kind of meat, the size and shape of the cut, the temperature of the meat when cooking begins, and the degree of doneness desired.
When defrosting meats it is recommended that it be done overnight in the refrigerator as opposed to a microwave. This in general yields a juicier cut of meat.

Use a spatula instead of tongs or a fork to turn the meat, as a spatula will not puncture the meat and let the juices run out.
To get the juiciest meats, add seasoning or salt after the cooking is finished on each side and turn the meat only once (juices are lost when the meat is turned several times). Turn the meat just after the juices begin to bubble to the surface.
Trim any excess fat from the meat before cooking. To prevent steaks or chops from curling during cooking, slit the fat around the edges at 51mm / 2-in. intervals.
DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING.

13

Grill Cooking Chart

FOOD
Vegetables
Fresh Beets Carrots Turnips
Onion
Potatoes Sweet White
Frozen Asparagus Peas Green beans
Sprouts

WEIGHT OR THICKNESS
1.3mm / 1/2 in. slices Whole
170 to 226g / 6 to 8 oz

HEAT SETTING

APPROXIMATE TIME

Medium 12 to 20 minutes

Medium 8 to 20 minutes

Medium High

40 to 60 minutes 45 to 60 minutes

Medium 15 to 30 minutes

SPECIAL INSTRUCTIONS AND TIPS
Slice. Dot with butter or margarine. Wrap in heavy -duty foil. Grill, turning occasionally.
Grill, turning once. Brush occasionally with melted butter or margarine.
Season with Italian dressing, butter, or margarine.
Wrap individually in heavy – duty foil. Grill, rotating occasionally.
Dot with butter or margarine. Wrap in heavy -duty foil. Grill, turning
occasionally.

French fries

Medium 15 to 30 minutes

Place in aluminum foil pan. Grill, stirring occasionally

Meats Beef Hamburgers

1-2 cm / 1/2 – 3/4 in.

Medium

10 to 18 minutes

Grill, turning once when juices rise to the surfaces.
Do not leave hamburgers unattended since a flare-up could occur quickly. Cook to internal
temperature of 160 degrees

Tenderloin

High

8 to 15 minutes

Rare
Medium
Well – done Lamb
Chop & Steaks Rare
Medium
Pork Chops
Well -done

2.5 cm / 1 in.

High

8 to 14 minutes

1.3 cm / 1/2 in. 2.5 cm / 1 in. 2.5 – 3.8 cm
/ 1-1/2 in.
2.5 cm / 1 in. 2.5 – 3.8 cm
/ 1-1/2 in.
2.5 cm / 1 in. 2.5 – 3.8 cm
/ 1-1/2 in.
2.5 cm / 1 in. 2.5 – 3.8 cm
/ 1-1/2 in.

High Medium to High

11 to 18 minutes 12 to 22 minutes 16 to 27 minutes

Medium Medium

18 to 30 minutes 16 to 35 minutes

Medium to
High
Medium to
High

10 to 15 minutes 14 to 18 minutes
13 to 20 minutes 18 to 25 minutes

2.5 cm / 1 in.

Medium 20 to 30 minutes

2.5 – 3.8 cm / 1-1/2 in.

Medium 30 to 40 minutes

Trim edges. Grill, turning once
Trim edges. Grill, turning once. Trim edges. Grill, turning once. Cook to
desired doneness.

14

FOOD
Ribs
Ham steaks (precooked)
Hot dogs
Poultry
Breasts well ­done
Fish and Seafood Halibut Salmon Swordfish
Whole Catfish Rainbow trout

WEIGHT OR THICKNESS
2.5 cm / 1 in. slices
900 to 1400 g / 2 to 3 lb
2 to 2.5 cm / 3/4 to 1 in.
113 to 226 g / 4 to 8 oz

HEAT SETTING
Medium

APPROXIMATE TIME
30 to 40 minutes

SPECIAL INSTRUCTIONS AND TIPS
Grill, turning occasionally. During last few minutes brush with barbecue
sauce. Turn several times.

High

4 to 8 minutes

Trim edges. Grill, turning once.

Low Low or Medium
Medium

5 to 10 minutes
Up to 1 hour
30 to 45 minutes

Slit skin. Grill, turning once. Place skin side up. Grill, turning and brushing frequently with melted butter,
margarine, oil or marinade.
Marinate as desired.

Medium to
High

8 to 15 minutes

Grill, turning once. Brush with melted butter, margarine or oil to keep moist.

Medium to
High

12 to 20 minutes

Grill, turning once. Brush with melted butter, margarine or oil. Brush with melted butter and lemon juice.

15

Grill Recipe Suggestion

BBQ SALMON
2 large salmon steaks 2 tbs. Oil Salt & pepper 2 oz. thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice Spring of parsley Lemon wedges
Preheat the BBQ. Brush the steaks with oil and season with salt and pepper. Place on BBQ grill and cook for 10 minutes, turning steaks over halfway cooking time.
Meanwhile, fry the bacon in a pan on the side burner. Drain on paper towels. Melt the butter in a small saucepan taking care not to discolor it. Arrange the fish and bacon on serving plates. Pour the butter over and sprinkle with lemon juice. Garnish with parsley springs and lemon wedges. Serve with boiled potatoes tossed in butter and sprinkled with chopped parsley and a crisp lettuce salad.
Note: Substitute catfish, halibut or cod for salmon.
BAKED CHILI CORN
6 medium ears corn, husked 3 tbs. Butter or margarine, melted Dash ground cumin Dash ground coriander
About ½ hour before cooking, turn the butter on for grill. Place each corn on a heavy-duty foil. In a bowl, combine remaining ingredients. Mix well. Brush 11/2 tsp. Butter mixture over each ear. Close foil and fold up ends to seal. Place on grill. Cook, turning packets occasionally 10 to 12 minutes or until cooked through.
TANGY SEAFOOD KABOBS
1 lb. Large shrimp, shelled & deveined ¾ lbs. sea scallops 2/3 c. chili sauce ¼ c. cider vinegar
butter and sprinkled with chopped parsley and a crisp lettuce salad
In medium bowl, combine shrimp and scallops. In small bowl combine chili sauce and next six ingredients. Pour over seafood. Toss to coat. Cover, refrigerate 2 hours.
3 tbs. chopped parsley 1 tbs. vegetable oil 1 tbs. Worcestershire sauce ½ tsp. prepared horseradish 1 cove garlic, minced

1 20 oz. Can pineapple chunks in juice, drained half hour before cooking, turn the burner to the grill on full. Drain seafood reserving marinade. On each of twelve 10″ skewers, thread 2 shrimps and 2 scallops, alternating with pineapple chunks. Place skewers on grill. Cook 7-10 minutes, often basting and turning.
PORK CHOPS
4 Pork chops Marinade 1 large onion 2 tbs. lemon juice or vinegar 2 tbs. oil ½ tsp. powdered mustard 2 tsp. Worcestershire sauce ½ tsp. freshly ground black pepper 1 tsp. sugar ½ tsp. paprika 1 clove garlic
Peel, grate onion, and add rest of the ingredients except the pork chops. Mix well. Pour over chops and marinate one hour in a cool place. Turn the BBQ grill on full. Heat 10 minutes.
BBQ the chops brushing with the marinade occasionally. Serve with mixed salad, dressed with vinaigrette flavored with fresh dill.
BARBECUED LONDON BROIL
4 to 6 servings ¾ c. Italian dressing 1 tsp. Worcestershire sauce 1 tsp. dry mustard ¼ tsp. thyme, crushed 1 medium onion, sliced 1 pound flank steak, scored 2 tbs. butter, melted
Combine first 4 ingredients, add onion and marinade flank steak with it. Refrigerate at least 4 hours or overnight. Remove steak and grill on your preheated BBQ grill. Grill 5 to 7 minutes on each side basting frequently with the marinade. In the meantime sauté onions from the marinade in butter in a skillet on your side burner for 3 minutes. To serve, slice steak diagonally into thin slices, sprinkle onions over top. Garnish with vegetable kabobs.
BARBECUED POTATOES and CHEESE
1-1/2 cups shredded cheddar cheese 1 can (10-3/4 oz.) condensed cream of mushroom soup 1/3 cup milk 2 tbs. barbecue sauce ¼ tsp. oregano ¼ tsp. salt

1/8 tsp. pepper 4 cups thinly sliced potatoes (4 mediumsized potatoes)
Preheat grill. Combine cheese, condensed soup, milk, BBQ sauce, oregano, salt and pepper in a large mixing bowl. Stir in potatoes until well coated. Turn into well buttered1-1/2 quart rectangular baking dish. Cover dish with aluminum foil. Bake covered 25 minutes on medium with the lid of your BBQ grill closed. Remove foil and continue baking 15 minutes longer or until potatoes are tender. Let stand 5 minutes before serving.
VEGETABLE KABOBS
3 medium-sized zucchini 12 cherry tomatoes 12 fresh mushrooms Grated Parmesan cheese
Parboil whole zucchini 5 minutes on your side burner or until just tender. Drain and cut into ½ inch slices. Thread zucchini, tomatoes and mushrooms alternately on each of six skewers. Brush with marinade made of Italian dressing, Worcestershire sauce, mustard and thyme. Grill 5 to 7 minutes turning and basting occasionally. Sprinkle liberally with Parmesan cheese.
FAJITAS
1-1/2 lb. flank steak or boned chicken breasts 2 tbs. oil ½ cup limejuice ½ tsp. salt ½ tsp. celery salt ¼ tsp. garlic powder ½ tsp. pepper ¼ tsp. oregano ¼ tsp. cumin Flour tortillas lemon
Pound flank steak to ¼ inch thickness or flatten chicken breasts. Mix oil, lime juice and seasonings in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a preheated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, taco sauce.

16

FAJITAS
1-1/2 lb. flank steak or boned chicken breasts 2 tbs. oil ½ cup limejuice ½ tsp. salt ½ tsp. celery salt ¼ tsp. garlic powder ½ tsp. pepper ¼ tsp. oregano ¼ tsp. cumin Flour tortillas lemon
Pound flank steak to ¼ inch thickness or flatten chicken breasts. Mix oil, lime juice and seasonings in a zip lock bag. Add meat and shake bag to coat the meat. Refrigerate overnight or at least 6 to 8 hours. Wrap tortillas in foil. Remove meat from marinade. Cook on a preheated gas grill for 5 to 8 minutes on each side. While meat is cooking, heat tortillas on grill. Slice meat across grain in thin slices. Place on hot platter. Squeeze lemon juice over. Wrap meat and any of the following toppings in tortillas: chopped tomatoes, guacamole, sour cream, taco sauce.
BEEF AND LAMB KABOBS
Serve 4
½ lb. boneless sirloin or beef cut into 1″ cubes ½ lb. boneless loin of lamb cut into 1″ cubes 2/3 c. water, divided ¼ c. chopped onion 2 tbs. soy sauce ¼ c. vegetable oil, divided 1 tbs. dark brown sugar 1 tbs. fresh lemon juice 2 cloves garlic, minced ¼ tsp. ground cumin ¼ tsp. ground coriander ¼ tsp. ground turmeric 1/8 tsp. ground red pepper 1/8 tsp. ground ginger 1 red pepper cut into chunks 1 large banana, cut into chunks 8 small mushrooms 1/3 c. smooth peanut butter
About ½ hour before cooking, turn the butter on for grill. Place each corn on a heavy-duty foil. In a bowl, combine remaining ingredients. Mix well. Brush 1-1/2 tsp. Butter mixture over each ear. Close foil and fold up ends to seal. Place on grill. Cook, turning packets occasionally 10 to 12 minutes or until cooked through. Bring marinade to boil on the side burner in a saucepan. Add remaining 1/3 c. water and peanut butter. Stir to blend. Heat through. If sauce gets too thick, add 1 tbs. water. Serve sauce with kabobs.

EGGPLANT CAVIAR

PORK ROAST

1 large eggplant 2 tbs. olive oil 2 tbs. wine vinegar 2 tbs. finely chopped onion ½ clove garlic, minced 1 medium tomato, chopped salt and pepper
Roast eggplant on gas grill over medium flame, turning occasionally until thoroughly cooked. This may take 30 minutes. Remove from grill and cool for handling. Strip off the skin and chop eggplant finely. Add all the seasonings. Chill thoroughly and serve on toast.
CHICKEN TANDOORI STYLE
8 large chicken thighs or drumsticks 1 c. plain nonfat yogurt ½ c. lemon juice 2 tsp. salt ½ tsp. cayenne ½ tsp. black pepper ½ tsp. crushed garlic ½ tsp. grated ginger 1 tbs. corn oil
Combine all the ingredients in a large mixing bowl and marinate the chicken for 8 hours in the refrigerator. Drain the chicken and spread on the spit running the rod on the fleshier side of the bone. Roast using the rotisserie burner. Cook on medium high heat for 40 minutes basting occasionally with the remainder of the marinade mixture. Serve with sliced onions and lemon wedges.

Apple cider vinegar basting sauce: 1 c. apple cider vinegar 6 oz. water ½ stick butter Salt, pepper, parsley and garlic seasoning 2 oz. lemon juice 10 lbs. pork roast
Time: 1-1/2 hours to 2 hours
Bring pork to room temperature before placing it on the spit rod. Place on the rod and test for balance. Light rotisserie burner. Turn control knob to high. Use the above basting sauce for rotissing.
TURKEY
12 lb. turkey Beer basting sauce: 1 can beer 12 oz. water 1 stick butter 1 tsp. salt 1 tsp. pepper ½ tsp. garlic flakes 1 tsp. parsley
Thaw the bird completely. Wash inside out. Securely tie the legs and wings. Light rotisserie burner. Turn to high. Combine all the ingredients for basting sauce in a shallow pan. Place it under the turkey 15 to 20 minutes. Cook for approximately 3 hours. The basting sauce combined with turkey drippings makes a delicious gravy.

SPARE RIBS

Marinade:

1 c. soy sauce
½ c. honey ½ c. vinegar ½ c. dry sherry 2 tsp. chopped garlic 2 tsp. sugar 1 c. water 1 chicken bouillon cube 1 can beer for basting sauce

Marinade ribs for 3 hours. Use marinade for basting by adding beer to it. Place pan under the ribs and baste frequently. To cook ribs select lean, meaty ribs and accordion pleat them with your spit. Slide four prong meat hook down the length of spit and tighten. At the beginning of the rack and to its center, penetrate the second rib with the pointed end of the spit and push it between the meat. Skip a couple and continue the process until the entire rack is accordion pleated. Fasten the second meat hook into the rack. Turn your rotisserie burner on high. Roast for 50 minutes or until done.

17

LIMITED WARRANTY

The manufacturer warrants to the original consumer-purchaser only that this product (Model #720-0864T) shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require photographic evidence of damage, or that defective parts be returned, postage and/or freight pre-paid by the consumer, for review and examination. Global Leisure Group’s obligation is limited to repair, replacement, or depreciated value, at the option of Global Leisure Group.
· TUBE BURNERS: 5 year LIMITED warranty against perforation. · COOKING GRIDS and FLAME TAMERS: 2 year LIMITED warranty; does not cover dropping, chipping, scratching, or surface damage. · STAINLESS STEEL PARTS: 2 year LIMITED warranty against perforation; does not cover cosmetic issues like surface corrosion,
scratches and rust. · ALL OTHER PARTS: 2 year LIMITED warranty (Includes, but not limited to, valves, frame, housing, cart, control panel, igniter, regulator,
hoses) *Does not cover chipping, scratching, cracking surface corrosion, scratches or rust.
Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts which are proven defective during the applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for shipping costs, as long as the purchaser is within the warranty period from the original date of purchase. The original consumer-purchaser will be responsible for all shipping charges of parts replaced under the terms of this limited warranty. This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not transferable. Manufacturer requires reasonable proof of your date of purchase. Therefore, you should retain your sales receipt and/or invoice. If the unit was received as a gift, please ask the giftgiver to send in the receipt on your behalf, to the below address. Defective or missing parts subject to this limited warranty will not be replaced without registration or proof of purchase. This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the discoloration of stainless steel surfaces. Surface rust, corrosion, or powder paint chipping on metal parts that does not affect the structural integrity of the product is not considered a defect in workmanship or material and is not covered by this warranty. This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage. If an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all shipping charges of parts replaced under the terms of this limited warranty.
MANUFACTURER WILL NOT PAY FOR: · Service calls to your home. · Repairs when your product is used for other than normal, single-family household or residential use. · Damage resulting from accident, alteration, misuse, lack of maintenance/cleaning, abuse, fire, flood, acts of God, improper installation,
and installation not in accordance with electrical or plumbing codes or misuse of product. · Any food loss due to product failures. · Replacement parts or repair labor costs for units operated outside the United States or Canada. · Pickup and delivery of your product. · Postage fees or photo processing fees for photos sent in as documentation. · Repairs to parts or systems resulting from unauthorized modifications made to the product. · The removal and/or reinstallation of your product. · Shipping cost, standard or expedited, for warranty/non warranty and replacement parts.
DISCLAIMER OF IMPLIED WARRANTIES; LIMITATION OF REMEDIES Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration, replacement of parts by anyone other than manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather, acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.
THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in addition to or inconsistent with those stated above. Manufacturer’s maximum liability, in any event, shall not exceed the documented purchase price of the product paid by the original consumer. This warranty only applies to units purchased from an authorized retailer and or re-seller. NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or exclusions may not apply to you; this limited warranty gives you specific legal rights as set for herein. You may also have other rights which vary from state to state.
If you wish to obtain performance of any obligation under this limited warranty, you should write to: Expert Grill’s Customer Relations 14050 Laurelwood PI Chino, CA 91710
All consumer returns, parts orders, general questions, and troubleshooting assistance can be acquired by calling 1-800-913-8999 in USA.
18

References

• The domain name eau.la is for sale
• full.to
• mecheros.2.La
• Universitetets symfoniorkester Oslo
• P65Warnings.ca.gov
• Repair Your Grill: Shop Replacement Parts for 24,880 Models
• Expert Grill Grill Parts - Select From 18 Models

Read User Manual Online (PDF format)

Download This Manual (PDF format)

Download this manual  >>