SUNJOE 24V-BBQ-LTE Cordless Fire Starter Owner’s Manual

SUNJOE 24V-BBQ-LTE Cordless Fire Starter

Safety Instructions

All Operators Must Read These
Instructions Before Use
Read all safety warnings and instructions. Failure to follow the warnings and instructions may result in electric shock, fire and/ or serious injury.

General Safety WARNINGS!

Notice the personal safety alert symbol m used in this manual to draw your attention to a WARNING given along with the particular operating instruction. This means that the operation
requires special ATTENTION, CAUTION, and AWARENESS. When using this fire starter, basic safety precautions, including the following, should always be followed to reduce the risk of fire, electric shock, personal injury and material damage.

• WARNING! To reduce the risk of fire or electric shock, do not expose this product to rain or moisture. Store indoors. Do not leave it outdoors.
• NEVER submerge the unit in any liquid.
• Be aware that heat from this tool could ignite flammable materials in hidden areas such as walls, ceilings, floors or soffit boards. The ignition of these materials may not be obvious and could result in property damage and personal injury.

1. Read all the instructions before using the appliance.
2. To reduce the risk of injury, close supervision is necessary when an appliance is used near children.
3. Do not contact hot parts.
4. This appliance is not intended to be used by persons (including children) with reduced physical, sensory or mental capabilities, or persons with lack of experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by someone responsible for their safety.
5. Children should be supervised to ensure that they do not play with the appliance.
6. Do not immerse in water.
7. For use only with Snow Joe® + Sun Joe® 24V iON+ series batteries and chargers.
8. Ensure that the fire starter is properly positioned before turning on.
9. Allow the fire starter to cool completely before storage.
10. Do not allow the hot parts of the fire starter to touch any flammable materials.
11. Remove the battery from the fire starter before charging.
12. Do not mix different batteries, or new and used batteries.
13. Check the polarity of the battery before inserting into the fire starter.
14. Remove the battery before storing the fire starter.
15. The supply terminals are not to be short-circuited.

Work Area Safety

1.  Keep work area clean and well lit. Cluttered or dark areas invite accidents.
2. Do not operate the fire starter in explosive atmospheres, such as in the presence of flammable liquids, gases or dust.
3. Keep children and bystanders away while operating a fire starter. Distractions can cause you to lose control.

Electrical Safety

WARNING! Read all safety warnings and instructions. Failure to follow the warnings and instructions may result in electric shock, fire and/or serious injury.

1. Do not expose the fire starter to rain or wet conditions. Water entering the unit will increase the risk of electric shock.
2. Recharge only with the charger specified by the manufacturer. A charger that is suitable for one type of battery pack may create a risk of fire when used with another battery pack.
3. Use appliances only with specifically designated battery packs. Use of any other battery packs may create a risk of injury and fire.
4. When the battery pack is not in use, keep it away from other metal objects, like paper clips, coins, keys, nails, screws or other small metal objects that can make a connection from one terminal to another. Shorting the battery terminals together may cause burns or a fire.
5. Under abusive conditions, liquid may be ejected from the battery; avoid contact. If contact accidentally occurs, flush with water. If liquid contacts eyes, additionally seek medical help. Liquid ejected from the battery may cause irritation or burns.
6. Do not use a battery pack or appliance that is damaged or modified. Damaged or modified batteries may exhibit unpredictable behavior resulting in fire, explosion or risk of injury.
7. Do not expose a battery pack or appliance to fire or excessive temperature. Exposure to fire or temperature above 104°F (40.5°C) may cause explosion.
8. Follow all charging instructions and do not charge the battery pack or appliance outside of the temperature range specified in the instructions. Charging improperly or at temperatures outside of the specified range may damage the battery and increase the risk of fire.
9. Do not modify or attempt to repair the appliance or the battery pack except as indicated in the instructions for use and care.

Personal Safety

WARNING! Do not touch the hot part while operating and until unit is completely cooled down. Touching hot surface can cause severe burns, personal injury or property damage.

1. Stay alert, watch what you are doing and use common sense when operating the fire starter. Do not use the unit while you are tired or under the influence of drugs, alcohol or medication. A moment of inattention while operating the unit may result in serious personal injury.
2. Do not force the appliance. It will do the job better with less likelihood of injury if it is used at the rate for which it was designed.
3. Use the right appliance. Do not use the appliance for any job except that for which it is intended.
4. Do not use the appliance if the switch does not turn it on and off. Any appliance that cannot be controlled by the switch is dangerous and must be repaired.
5. Disconnect the battery pack from the appliance before making any adjustments, changing accessories or storing the appliance. Such preventative safety measures reduce the risk of starting the appliance accidentally.
6. Store the idle appliance out of the children’s reach and do not allow persons unfamiliar with the appliance or these instructions to operate the appliance. Appliances are dangerous in the hands of untrained users.
7. Maintain appliance with care. Check for misalignment or binding of moving parts, breakage of parts and any other condition that may affect the tool’s operation. If damaged, have the tool repaired before use. Many accidents are caused by poorly maintained power tools.
8. Keep the product dry, clean and free from oil and grease. Always use a clean cloth when cleaning. Never use brake fluids, gasoline, petroleum-based products, or any strong solvents to clean your product. Following this rule will reduce the risk of loss of control and deterioration of the enclosure plastic.
9. Use the appliance and accessories in accordance with these instructions and in the manner intended for the particular use of the appliance, taking into account the working conditions and the work to be performed. Using the tool for operations different from those intended could result in a hazardous situation.
10. Battery tools do not have to be plugged into an electrical outlet; therefore, they are always in operating condition. Be aware of possible hazards when not using your battery tool or when changing accessories. Following this rule will reduce the risk of electric shock, fire, or serious personal injury.
11. The unit can becomes very hot. Do not lay the fire starter on flammable surfaces while operating or immediately after shutting off. Always set it on the stand with the outlet tip pointing in a safe direction.
12. Never point the tool at yourself or others.

Service

1. If your appliance requires service, contact an authorized Snow Joe® + Sun Joe® dealer or call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563). Only identical replacement parts should be utilized for repairs. This will ensure that the safety of the power tool is maintained.
2. If the battery charger cable is damaged, it must be immediately replaced to avoid a hazard. Contact the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563) for assistance.

Battery & Charger Safety Instructions

We pay a great deal of attention to the design of every battery pack to ensure that we supply you with batteries that are safe, durable and have a high energy density. The battery cells have a wide range of safety devices. Each individual cell is initially formatted and its electrical characteristic curves are recorded. This data is then used exclusively to be able to assemble the best possible battery packs.
Despite all the safety precautions, caution must always be exercised when handling batteries. The following points must be obeyed at all times to ensure safe use. Safe use can only be guaranteed if undamaged cells are used. Incorrect handling of the battery pack can cause cell damage.
IMPORTANT! Analyses confirm that incorrect use and poor care of high- performance batteries are the main factors responsible for personal and/or product damage.

WARNING! Use only approved replacement batteries; other batteries may damage the power tool and cause it to malfunction, which can lead to serious personal injury.

• WARNING! Do not use a battery pack or appliance that is damaged or modified. Damaged or modified batteries may exhibit unpredictable behavior resulting in fire, explosion or risk of injury.
  Do not modify or attempt to repair the appliance or the battery pack except as indicated in the instructions for use and care.
  Have your battery pack serviced by a qualified repair person using only identical replacement parts. This will ensure that the safety of the battery pack is maintained.

• CAUTION! To reduce the risk of injury, charge the
  Sun Joe® 24V lithium-ion battery pack only in its designated Sun Joe® lithium- ion charger. Other types of chargers present risk of fire, personal injury and damage. Do not wire a battery pack to a power supply plug or car cigarette lighter. Such misuse will permanently disable or damage the battery pack.

• Avoid dangerous environments – Do not charge the battery pack in rain, snow or in damp or wet locations. Do not use the battery pack or charger in the presence of explosive atmospheres (gaseous fumes, dust or flammable materials) because sparks may be generated when inserting or removing the battery pack, which could lead to a fire.

• Charge in a well-ventilated area – Do not block the charger vents. Keep them clear to allow for proper ventilation. Do not allow smoking or open flames near a charging battery pack. Vented gases may explode.
  NOTE : The safe temperature range for the battery is 41°F – 105ºF (5°C – 40.5°C). Do not charge the battery outside in freezing weather; charge it at room temperature.

• Maintain charger cord – When unplugging the charger, pull the plug, not the cord, from the receptacle to reduce the risk of damage to the electrical plug and cord. Never carry the charger by its cord or yank it by the cord to disconnect it from the receptacle. Keep the cord away from heat, oil and sharp edges. Make sure the cord will not be stepped on, tripped over or subjected to damage or stress when the charger is in use. Do not use the charger with a damaged cord or plug. Replace a damaged charger immediately.

• Do not use an extension cord unless it is absolutely necessary – Using the wrong, damaged or improperly wired extension cord poses a risk of fire and electric shock. If an extension cord must be used, plug the charger into a properly wired 16 gauge or larger extension cord with the female plug matching the male plug on the charger. Make sure that the extension cord is in good electrical condition.

• Charger (24VCHRG-AC) is rated for 100 – 240 volt AC only – The charger must be plugged into an appropriate receptacle.

• Use only recommended attachments – Use of an attachment not recommended or sold by the battery charger or battery pack manufacturer may result in risk of fire, electric shock or personal injury.

• Unplug charger when not in use – Make sure to disconnect battery pack from unplugged charger

• WARNING! To reduce the risk of electric shock, always unplug the charger before performing any cleaning or maintenance. Do not allow water to flow into the charger. Use a Ground Fault Circuit Interrupter (GFCI) to reduce shock hazards.

• Do not burn or incinerate battery pack – Battery pack may explode, causing personal injury or damage. Toxic fumes and materials are created when battery packs are burned.

• Do not crush, drop or damage battery pack – Do not use the battery pack or charger if they have sustained a sharp blow, been dropped, run over or have been damaged in any way (i.e. pierced with a nail, hit with a hammer, stepped on, etc.).

• Do not disassemble – Incorrect reassembly may pose a serious risk of electric shock, fire or exposure to toxic battery chemicals. If the battery or charger is damaged, contact an authorized Snow Joe® + Sun Joe® dealer or call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563) for assistance.

• Battery chemicals cause serious burns – Never let a damaged battery pack contact the skin, eyes or mouth. If a damaged battery pack leaks battery chemicals, use rubber or neoprene gloves to safely dispose of it. If skin is exposed to battery fluids, wash the affected area with soap and water and rinse with vinegar. If eyes are exposed to battery chemicals, immediately flush with water for 20 minutes and seek medical attention. Remove and dispose of contaminated clothing.

• Do not short circuit – When battery pack is not in use, keep it away from other metal objects, like paper clips, coins, keys, nails, screws or other small metal objects that can make a connection from one terminal to another. Shorting the battery terminals together may cause burns or a fire.

• tore your battery pack and charger in a cool, dry place – Do not store the battery pack or charger where temperatures may exceed 105ºF (40.5ºC), such as in direct sunlight or inside a vehicle or metal building during the summer.

Information about the battery

1. The battery pack supplied with your cordless fire starter is only partially charged. The battery pack has to be charged completely before you use the tool for the first time.

2. For optimum battery performance, avoid low discharge cycles by charging the battery pack frequently.

3. Store the battery pack in a cool place, ideally at 77°F (25°C) and charged to at least 40%.

4. Lithium-ion batteries are subject to a natural aging process. The battery pack must be replaced at the latest when its capacity falls to just 80% of its capacity when new. Weakened cells in an aged battery pack are no longer capable of meeting the high power requirements needed for the proper operation of your cordless fire starter, and therefore pose a safety risk.

5. Do not throw the battery pack into an open fire as this poses a risk of explosion.

6. Do not ignite the battery pack or expose it to fire.

7. Do not exhaustively discharge batteries. Exhaustive discharge will damage the battery cells. The most common cause of exhaustive discharge is lengthy storage or non-use of partially discharged batteries. Stop working as soon as the performance of the battery falls noticeably or the electronic protection system triggers. Place the battery pack in storage only after it has been fully charged.

8. Protect the battery and the tool from overloads. Overloads will quickly result in overheating and cell damage inside the battery housing even if this overheating is not apparent externally.

9. Avoid damage and shocks. Immediately replace batteries that have been dropped from a height of more than 3 feet (1 meter) or those that have been exposed to violent shocks, even if the housing of the battery pack appears to be undamaged. The battery cells inside the battery may have suffered serious damage. In such instances, please read the waste disposal information for proper battery disposal.

10. If the battery pack suffers overloading and overheating, the integrated protective cutoff will switch off the equipment for safety reasons.
    IMPORTANT! Do not press the power supply button any more if the protective cut-off has been activated. This may damage the battery pack.

11. Recharge only with the charger specified by the manufacturer. A charger that is suitable for one type of battery pack may create a risk of fire when used with another battery pack.

12. Use appliances only with specifically designated battery packs. Use of any other battery packs may create a risk of injury and fire.

13. Under abusive conditions, liquid may be ejected from the battery; avoid contact. If contact accidentally occurs, flush with water. If liquid contacts eyes, additionally seek medical help. Liquid ejected from the battery may cause irritation or burns.

14. Do not use a battery pack or appliance that is damaged or modified. Damaged or modified batteries may exhibit unpredictable behavior resulting in fire, explosion or risk of injury.

15. Do not expose a battery pack or appliance to fire or excessive temperature. Exposure to fire or temperature above 265ºF (130°C) may cause explosion.

16. Follow all charging instructions and do not charge the battery pack or appliance outside of the temperature range specified in the instructions. Charging improperly or at temperatures outside of the specified range may damage the battery and increase the risk of fire.

Information about the charger and the charging process

1. Please check the data marked on the rating plate of the battery charger. Be sure to connect the battery charger to a power supply with the voltage marked on the rating plate. Never connect it to a different mains voltage.
2. Protect the battery charger and its cord from damage. Keep the charger and its cord away from heat, oil and sharp edges. Have damaged cords repaired without delay by a qualified technician at an authorized Snow Joe® + Sun Joe® dealer or call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563).
3. Electrical plugs must match the outlet. Never modify the plug in any way. Do not use any adapter plugs with grounded appliances. Unmodified plugs and matching outlets will reduce the risk of electric shock.
4. Keep the battery charger, battery pack and the cordless tool out of the reach of children.
5. Do not use the supplied battery charger to charge other cordless tools.
6. During periods of heavy use, the battery pack will become warm. Allow the battery pack to cool to room temperature before connecting with the charger to recharge.
7. Do not overcharge batteries. Do not exceed the maximum charging times. These charging times only apply to discharged batteries. Frequent insertion of a charged or partially charged battery pack will result in overcharging and cell damage. Do not leave batteries in the charger for days on end.
8. Never use or charge the battery if you suspect that it has been more than 12 months since the last time they were charged. There is a high probability that the battery pack has already suffered dangerous damage (exhaustive discharge).
9. Charging batteries at a temperature below 41°F (5°C) will cause chemical damage to the cells and may cause a fire.
10. Do not use batteries that have been exposed to heat during the charging process, as the battery cells may have suffered dangerous damage.
11. Do not use batteries that have suffered curvature or deformation during the charging process or those that exhibit other atypical symptoms (gassing, hissing, cracking, etc.).
12. Never fully discharge the battery pack (maximum recommended depth of discharge is 80%). A complete discharge of the battery pack will lead to premature aging of the battery cells.

Protection from environmental influences

1. Protect your cordless tool and the battery charger from moisture and rain. Moisture and rain can cause dangerous cell damage.
2. Do not use the cordless tool or the battery charger near vapors and flammable liquids.
3. Use the battery charger and cordless tools only in dry conditions and at an ambient temperature of 41ºF – 105°F (5°C – 40.5°C).
4. Do not keep the battery charger in places where the temperature is liable to reach over 105°F (40.5°C). In particular, do not leave the battery charger in a car that is parked in the sunshine.
5. Protect batteries from overheating. Overloads, overcharging and exposure to direct sunlight will result in overheating and cell damage. Never charge or work with batteries that have been overheated – replace them immediately, if possible.
6. Store the charger and your cordless tool only in dry locations with an ambient temperature of 41ºF – 105°F (5°C – 40.5°C). Store your lithium-ion battery pack in a cool, dry place at a temperature of 77°F (25°C). Protect the battery pack, charger and cordless tool from humidity and direct sunlight. Only place fully charged batteries in storage (charged to at least 40%).
7. Prevent the lithium-ion battery pack from freezing. Battery packs that were stored below 32°F (0°C) for more than 60 minutes must be discarded.
8. When handling batteries, be wary of electrostatic charge. Electrostatic discharges can damage the electronic protection system and the battery cells. Avoid electrostatic charging and never touch the battery poles.

Know Your Cordless Fire Starter

Read the owner’s manual and safety instructions carefully before operating this cordless fire starter. Compare the illustration below to the cordless fire starter in order to familiarize yourself with the location of the various controls and adjustments. Save this manual for future reference.

1. Heat shield
2. Mode switch
3. Power switch
4. Handle grip
5. Battery compartment
6.  iON+ 24V lithium-ion battery (24VBAT-LTE) featuring exclusive EcoSharp® technology
7. Charge socket
8. Push lock buttons (2)
9. Push button for battery indicator
10. Battery indicator
11. Stand/Bottle opener
12. 24V iON+ lithium-ion charger (24VCHRG-AC)
13. Charger plug

Technical Data

• Motor ……………………………………………………………………. 480 W
• Battery Voltage* Max …………………………………………… 24V D.C.
• Battery Capacity …………………………………………………….. 2.0 Ah
• Battery Runtime Max ……………………………………………… 6.5 min Continuous heating
• Charger Input …………………………………………… 100 – 240 V AC, 50 – 60 Hz, 50 W
• Charger Output …………………………………… 25.2V DC | 1400 mA
• Charge Time Max …………………………………………….. 1 hr 20 min
• Air Speed Max ……………………………………………………… 35 Mph
• Max Temperature ……………………………………… 1470 °F (800 °C)
• Working Temperature ……………………………….. 1380 °F (750 °C)
• Heating Speed ………………………. Up to 1380 °F (750 °C) in 30 s
• 2 Working Modes ………………………………………… Heat + blower Blower only
• Heating Element ……………………… Ferrochrome resistance wire
• Net Weight …………………………………………………. 2.8 lbs (1.3 kg)
  *Initial no-load voltage, when fully charged, peaks at 24 volts; nominal voltage under typical load is 21.6 volts.

Unpacking

Carton Contents

• Cordless fire starter
• iON+ 24V lithium-ion battery
• iON+ 24V lithium-ion battery charger
• Manual with registration card

1. Carefully remove the cordless fire starter and check to see that all of the above items are supplied.
2. Inspect the product carefully to make sure no breakage or damage occurred during shipping. If you find damaged or missing parts, DO NOT return the unit to the store. Please call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563).
   NOTE : Do not discard the shipping carton and packaging material until you are ready to use your new cordless fire starter. The packaging is made of recyclable materials. Properly dispose of these materials in accordance with local regulations.
   IMPORTANT! The equipment and packaging material are not toys. Do not let children play with plastic bags, foils or small parts. These items can be swallowed and pose a suffocation risk!

Battery Pack Operation

The equipment is powered by a lithium-ion battery. The battery pack is completely sealed and maintenance free.

Battery Charge Level Indicator
The battery pack is equipped with a push button for checking the charge level. Simply press the push button to read off the battery charge level from the LEDs of the battery indicator:

• All 3 level monitoring LEDs are lit: Battery charge level is high.
• 2 level monitoring LEDs are lit: Battery charge level is decreasing. Turn off the fire starter as soon as possible.
• 1 level monitoring LED is lit: Battery is flat. Turn off the fire starter IMMEDIATELY and charge the battery. Otherwise the battery’s service life will be greatly shortened.

NOTE : If the charge level button does not appear to be working, insert the charger and charge as needed.
NOTE : Immediately after using the battery pack, the charge level button may display a lower charge than it will if checked a few minutes later. The battery cells “recover” some of their charge after resting.

Charger Operation

WARNING! Charge only Sun Joe® 24V lithium-ion battery pack with its compatible Sun Joe® 24V lithium-ion charger. Other types of batteries may cause personal injury and damage.
To reduce the risk of electric shock, do not allow water to flow into the charger’s AC/DC plug.

When to Charge the iON+ 24VBAT-LTE Lithium-iON Battery
NOTE : The iON+ 24VBAT-LTE lithium-ion battery pack does not develop a “memory” when charged after only a partial discharge. Therefore, it is not necessary to run down the battery pack before inserting the charger plug.

• Use the battery indicator lights to determine when to charge your iON+ 24VBAT-LTE lithium-ion battery pack.
• You can “top-off” your battery pack’s charge before or after a long day of use.

Charging the Battery

1. Push the push lock buttons on the battery to pull the battery pack out from the battery compartment (Fig. 1).

2. Check that the mains voltage is the same as that marked on the rating plate of the battery charger. Then, plug the charger adapter into an appropriate AC power outlet. Connect the charger plug into the charge socket of the battery to start charging (Fig. 2).

3. The battery will take approximately 1 hr 20 min to charge. The battery indicator LEDs will twinkle and illuminate one by one during the charging process. Unplug the charger immediately when the 3 LEDs are all illuminated.
   CAUTION! FIRE HAZARD. When disconnecting the charger from the battery, be sure to unplug the charger from the outlet first, then disconnect the charger from the battery.
   WARNING! This charger does not automatically turn off when the battery is fully charged. Please take care not to leave the battery plugged into the charger. Switch off or unplug the charger at the mains when charging is complete.

4. Timely recharging of the battery will help prolong the battery’s life. You must recharge the battery pack when you notice a drop in the equipment’s power.
   IMPORTANT! Never allow the battery pack to become fully discharged as this will cause irreversible damage to the battery.

Operation

Sun Joe® cordless fire starter ignites charcoal with super heated air, then uses the built-in blower to fan the flames. This safe and eco-friendly starter can light charcoal, paper, and wood in 60 seconds (depending on the fuel type) without using any dangerous chemicals.

WARNING! Do not allow familiarity with products to make you careless. Remember that a careless fraction of a second is sufficient to inflict serious injury.

Starting and Stopping

1. Insert the battery in the battery compartment. Push to make sure it is locked in place (Fig. 3).

2. Set up a pile of fuel you like – charcoal, twigs and sticks, wood chips, or logs. Make sure the mode switch is pushed forward and the fire starter is set in heat + blower mode, touch the fuel with the tip of the cordless fire starter nozzle and slide the power switch forward (Fig. 4).

3. Keep the cordless fire starter aimed towards the same spot. There should be a glowing spot in about 15 to 30 seconds.

4. When the fuel starts to burn, slide the mode switch back to the blower only mode, and pull the fire starter a few inches back. Giving it space will help the heated air to spread out (Fig. 5).
   NOTE : Get the grill ready to cook faster by continuing on blower only mode until the grill reaches the desired temperature.

5. When the grill is ready, slide back the power switch to turn off the fire starter. Remove the battery. Rest the fire starter on its stand to let it cool down completely.
   NOTE : When the machine is shut down the fan will continue to work for couple seconds to cool down the machine.

Mode Switch (Fig. 6)

The fire starter is equipped with 2 working modes:

• Heat + blower mode will heat the air and increase the temperature around the nozzle tip, therefore ignite the fuel.
• Blower only mode will increase the airflow and spread the heat after the fuel is ignited, to create strong flame.
  Adjust the unit’s mode with the mode switch next to the power switch. Slide it forward to set the fire starter to heat + blower mode. Slide it backward to set the fire starter to blower only mode.

Operating Tips

DANGER! Do not operate near explosive or flammable materials unless extraordinary safety precautions are observed. The fire starter produces air at extremely high temperatures and if exposed to explosive or flammable materials, will result in flame or possible explosion, causing serious personal injury, death or property damage.

1. Always make sure flammable objects are kept at a safe distance.

2. Never use near gas, petroleum products, or other explosive substances.

3. Do not use near combustible materials such as dry grass, leaves, and paper, which can scorch and catch fire.
   DANGER! Use extreme caution when starting a fire. Some charcoal contains impurities that cause sparks and popping. Sparks could cause minor or moderate injury or property damage.

4. Never bury tip under charcoal or wood.

5. Never leave the unit in the fire.

6. Sparks can be generated and fly towards you and others.

7. Sparks and ash can be blown out of designated burning area.

Maintenance

• WARNING! Always switch the product off, remove the battery and wait until the appliance is completely cool down before performing inspection, maintenance, and cleaning work.
• WARNING! When servicing, use only identical replacement parts. Use of any other parts could create a hazard or cause product damage.

General Cleaning Tips
Use a soft, dry brush to clean the air inlet area. Use only mild soap and a damp cloth to clean the housing. Do not use house-hold cleaners, since many contain chemicals, which could seriously damage the plastic housing of the fire starter. Do not use gasoline, turpentine, lacquer thinner, paint thinner, dry cleaning fluids or similar products on the fire starter.

WARNING! Never allow any liquid to get inside the fire starter or immerse any part of the fire starter into a liquid. Ensure the air inlet and the housing are clean and free of obstructions.
WARNING! Do not at any time let brake fluids, gasoline, petroleum based products, penetrating oils, etc., come in contact with plastic parts. Chemicals can damage, weaken or destroy plastic which may result in serious personal injury.

Storage

WARNING! Let the fire starter cool to room temperature before placing it in storage.

• Switch off the unit, remove the battery. Wait until it is completely cooled down. Thoroughly clean the housing.
• Store the fire starter, with the battery and charger indoors in a safe location out of the reach of children. Keep away from corrosive agents, such as garden chemicals and de-icing salt.

Disposal
Recycling the tool

• Do not dispose of electrical appliances as unsorted municipal waste. Use separate collection facilities.
• Contact your local government agency for information regarding the collection systems available.
• If electrical appliances are disposed of in landfills or dumps, hazardous substances can leak into the groundwater and get into the food chain, damaging your health and well-being.
• When replacing old appliances with new ones, the retailer is legally obligated to take back your old appliance for disposal at least free of charge.

Recycling + Disposal
The product comes in a package that protects it against damage during shipping. Keep the package until you are sure that all parts have been delivered and the product is functioning properly. Recycle the package afterwards or keep it for long-term storage. WEEE symbol. Waste electrical products should not be disposed of with household waste. Please recycle where facilities exist. Check with your local authority or local store for recycling regulations.

Battery Caution + Disposal
Always dispose of your battery pack according to federal, state, and local regulations. Contact a recycling agency in your area for recycling locations.

CAUTION! Even discharged battery packs contain some energy. Before disposing, use electrical tape to cover the terminals to prevent the battery pack from shorting, which could cause a fire or explosion.
WARNING! To reduce the risk of injury or explosion, never burn or incinerate a battery pack even if it is damaged, dead or completely discharged. When burned, toxic fumes and materials are emitted into the surrounding atmosphere.

1. Batteries vary according to device. Consult your manual for specific information.
2. Install only new batteries of the same type in your product (where applicable).
3. Failure to insert the battery in the correct polarity, as indicated in the battery compartment or manual, may shorten the life of the battery or cause the battery to leak.
4. Do not mix old and new batteries.
5. Do not mix Alkaline, Standard (Carbon-Zinc) or Rechargeable (Nickel Cadmium, Nickel Metal Hydride, or Lithium-Ion) batteries.
6. Do not dispose of batteries in fire.
7. Batteries should be recycled or disposed of as per state and local guidelines.

Service + Support
If your Sun Joe® cordless fire starter needs service or maintenance, please call the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE (1-866-766-9563).
Model + Serial Numbers
When contacting the company or reordering parts, you will need to provide the model and serial numbers of your product. These are found on the decal affixed to the housing of your cordless fire starter. Copy these numbers into the space provided below.

24V iON+ Lithium-Ion Charger (24VCHRG-AC)
Federal Communications Commission (FCC)

• WARNING! Any changes or modifications to this unit not expressly approved by the party responsible for compliance could void the user’s authority to operate
  the equipment.
  Class B device:
  NOTE : This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules.
  These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

• Reorient or relocate the receiving antenna.

• Increase the separation between the equipment and receiver.

• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.

• Consult the dealer or an experienced radio/TV technician for help.

Optional Accessories

WARNING! ALWAYS use only authorized Snow Joe® + Sun Joe® replacement parts and accessories. NEVER use replacement parts or accessories that are not intended for use with this cordless fire starter. Contact Snow Joe® + Sun Joe® if you are unsure whether it is safe to use a particular replacement part or accessory with your cordless fire starter. The use of any other attachment or accessory can be dangerous and could cause injury or mechanical damage.

NOTE : Accessories are subject to change without any obligation on the part of Snow Joe® + Sun Joe® to provide notice of such changes. Accessories can be ordered online at sunjoe.com or via phone by contacting the Snow Joe® + Sun Joe® customer service center at 1-866-SNOWJOE ( 1-866-766-9563).

ABOVE ALL ELSE , Snow Joe, LLC (“Snow Joe”) is dedicated to you, our customer. We strive to make your experience as pleasant as possible. Unfortunately, there are times when a Snow Joe®, Sun Joe®, or Aqua Joe® product (“Product”) does not work or breaks under normal operating conditions. We think it’s important that you know what you can expect from us. That’s why we have a Limited Warranty (“Warranty”) for our Products.

OUR WARRANTY:
Snow Joe warrants new, genuine, powered and non-powered Products to be free from defects in material or workmanship when used for ordinary household use for a period of two years from the date of purchase by the original, end-user purchaser when purchased from Snow Joe or from one of Snow Joe’s authorized sellers with proof of purchase. Because Snow Joe is unable to control the quality of its Products sold by unauthorized sellers, unless otherwise prohibited by law, this Warranty does not cover Products purchased from unauthorized sellers. If your Product does not work or there’s an issue with a specific part that is covered by the terms of this Warranty, Snow Joe will elect to either

1. send you a free replacement part,
2. replace the Product with a new or comparable product at no charge, or
3. repair the Product. How cool is that! This Warranty gives you specific legal rights, and you may also have other rights which vary from State to State.

PRODUCT REGISTRATION:
Snow Joe strongly encourages you to register your Product. You can register online at snowjoe.com/register , or by printing and mailing in a registration card available online from our website, or calling our Customer Service Department at 1-866-SNOWJOE (1-866-766-9563), or by e-mailing us at help@snowjoe.com. Failure to register your Product will not diminish your warranty rights. However, registering your Product will allow Snow Joe to better serve you with any of your customer service needs.

WHO CAN SEEK LIMITED WARRANTY COVERAGE:
This Warranty is extended by Snow Joe to the original purchaser and original owner of the Product.

WHAT IS NOT COVERED?
This Warranty does not apply if the Product has been used commercially or for non-household or rental applications. This Warranty also does not apply if the Product was purchased from an unauthorized seller. This Warranty also does not cover cosmetic changes that do not affect performance. Wearing parts like belts, augers, chains and tines are not covered under this Warranty, and can be purchased at snowjoe.com or by calling 1-866-SNOWJOE (1-866-766-9563).

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>