HENDI 282748 Popcorn Machine User Manual

: June 6, 2024
: HENDI

Table of Contents

282748 Popcorn Machine
Read User Manual Online (PDF format)
Download This Manual (PDF format)

282748 Popcorn Machine

POPCORN MACHINE 282748

You should read this user manual carefully before using the appliance.

Keep these instructions with the appliance.

rohs

For indoor use only.

Dear Customer,

Thank you for purchasing this Hendi appliance. Before using the appliance for the first time, please read this manual carefully, paying particular attention to the safety regulations outlined below.

Safety regulations

This appliance is intended for commercial use only.
The appliance must only be used for the purpose for which it was intended and designed. The manufacturer is not liable for any damage caused by incorrect operation and improper use.
Keep the appliance and electrical plug away from water and any other liquids. In the event that the appliance should fall into water, immediately remove plug from the socket and do not use until the appliance has been checked by a certified technician. Failure to follow these instructions could cause a risk to lives.
Never attempt to open the casing of the appliance yourself.
Do not insert any objects in the casing of the appliance.
Do not touch the plug with wet or damp hands.
Danger of electric shock! Do not attempt to repair the appliance yourself. In case of malfunctions, repairs are to be conducted by qualified personnel only.
Never use a damaged appliance! Disconnect the appliance from the electrical outlet and contact the retailer if it is damaged.
Warning! Do not immerse the electrical parts of the appliance in water or other liquids. Never hold the appliance under running water.
Regularly check the power plug and cord for any damage. If the power plug or power cord is damaged, it must be replaced by a service agent or similarly qualified persons in order to avoid danger or injury.
Make sure the cord does not come in contact with sharp or hot objects and keep it away from open fire. To pull the plug out of the socket, always pull on the plug and not on the cord.
Ensure that the cord (or extension cord) is positioned so that it will not cause a trip hazard.
Always keep an eye on the appliance when in use.
Warning! As long as the plug is in the socket the appliance is connected to the power source.
Turn off the appliance before pulling the plug out of the socket.
Never carry the appliance by the cord.
Do not use any extra devices that are not supplied along with the appliance.
Only connect the appliance to an electrical outlet with the voltage and frequency mentioned on the appliance label.
Connect the power plug to an easily accessible electrical outlet so that in case of emergency the appliance can be unplugged immediately. To completely switch off the appliance pull the power plug out of the electrical outlet.
Always turn the appliance off before disconnecting the plug.
Never use accessories other than those recommended by the manufacturer. Failure to do so could pose a safety risk to the user and could damage the appliance. Only use original parts and accessories.
This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge.
This appliance must not be used by children under any circumstances.
Keep the appliance and its cord out of reach of children.
Always disconnect the appliance from the mains if it is left unattended or is not in use, and before assembly, disassembly or cleaning.
Never leave the appliance unattended during use.

Special Safety Regulations

This appliance is designed only for making popcorns only. Not suitable for other food. Any other use may lead to damage to the appliance or personal injury.
This appliance must be operated and maintained by specialized trained personnel in kitchen of the restaurant or canteens or bar staff.
Do not place any objects on the top of the appliance. Do not place objects with open flames, e.g. candles on top of or beside of the appliance. Do not place objects filled with water.
Keep the appliance away from the hot surfaces and heat sources such as heat stoves, fire, ovens, gas burners or other flammable objects such as alcohol, fuels, etc.
When this appliance is to be positioned in close proximity to a wall, partitions, kitchen furniture, decorative finishes, etc., it is recommended that they are made of non combustible material; if not, they shall be clad with a suitable non-combustible heat insulating material, and that the closest attention be paid to fire prevention regulations.
Caution! Risk of burns! The surface of the appliance and adjacent areas are very hot. Touch only the power switch, and the temperature control knob only.
Do not cover the appliance during the operation.
Do not use hard utensils to hit the enclosure. Do not use water jet, flush directly with water or steam cleaner as the parts will get wet and electric shock might be resulted.
Leave at least 10cm surrounding the appliance for ventilation purpose. Use the appliance only in a well-ventilated area and avoid blocking the ventilation holes. Place the appliance on a stable, clean, dry, level and heat-resistant surface.
Clean the appliance after each use for the reason of hygiene.
WARNING! Allow completely cool down before cleaning and storage.
An equipotential bonding terminal is provided to allow cross bonding with other equipment.
Extreme caution must be used when unloading popcorn, always use oven mitts(not included). Be careful that residual hot oil or water does not come into contact with skin, as burns may occur.
No parts are dishwasher safe.

Intended use

The appliance is intended for professional use.
The appliance is designed only for making pop corns only. Not suitable for other food. Any other use may lead to damage to the appliance or personal injury.

Grounding installation

This appliance is classified as protection class I appliance and must be connected to a protective ground. Grounding reduces the risk of electric shock by providing an escape wire for the electric Preparation before using for the first time

• Remove all protective packaging and wrapping. Make sure no packaging debris remain on the appliance.

• Check for completeness (1 crumbs tray included) and any transport damage. In case of damages or incomplete delivery, please contact supplier (See — > Warranty page).

• Keep the packaging for storing your appliance when not in use for an extended period of time.

Main parts of the appliance

• Operating the appliance for any other purpose shall be deemed a misuse of the device. The user shall be solely liable for improper use of the device.

current. This appliance is equipped with a cord having a grounding wire with a grounding plug. The plug must be plugged into an outlet that is properly installed and grounded.

• Ensure there is enough clearance around the appliance. Place the appliance in a well-ventilated area.

Note: Due to the manufacturing residues, the appliance may emit a slight odor in the first few cycles. This is normal and does not indicate any defect or hazard. Make sure the appliance is well ventilated.

Crumbs tray
Glass doors
Light source
TURN switch: Control the motor
HEAT switch: Control the heating of the kettle
WARMING & LIGHT switch: Control the warming element(bottom of the chamber) and light
POWER switch
Kettle lid grip
Kettle grip
Kettle

Operation

Attention: Do not pop corn kernels in a dry pot (without oil).

To avoid overheating, always have oil and kernels ready before operating.
Make sure the light bulb is installed
Turn on the device using the POWER switch(7).
Turn on the light using WARMING & Light switch(6).
Pour 50ml oil into the kettle(10). Turn on the heater for kettle(10) using HEAT switch(5) to pre heat for 4-6 minutes.
Lift the kettle lid using the lid grip(8) carefully and pour 50g sugar(while the amount is dependent upon your taste) and 150g corn kernels.
Put the lid down and close the glass doors(2) firmly to avoid spilling of popcorns from the appliance.
Pay attention to the corn kernels while popping process to avoid burning.
Turn on the motor using TURN switch(4) to stir the corn kernels until there are all popped, then pour the popcorns out from the kettle to the chamber using kettle grip(9) carefully.
The popping cycle is approx. 2 minutes per portion.

Cleaning and Maintenance

WARNING! Always disconnect the appliance from the electrical power supply and allow the appliance completely cool down before cleaning.

• Never use abrasive sponges or aggressive deter gents, steel wool or metallic utensils to clean the heating area.

• Avoid the use of sprays as this may damage the heating area.

• Never immerse the appliance in water or any oth er liquid.

• Fix the kettle in horizontal position again and re peat upper procedures to make more popcorns.

Note:

• The appliance is equipped with “protective thermostat”. In case of overheating of the kettle, the protection will be activated and turns the appliance off. Disconnect the appliance from the electrical socket and wait for cooling down. Then, it may be used again.

• Do not put too many corn kernels at one time for even spacing and cooking.

• Do not drop any oil around the plate. Otherwise it will catch fire when it is heated to a certain temperature.

• Warning: Do not add any water to the plate while it is popping!

• This appliance should be cleaned regularly and any food deposit removed.

• Clean the surface of the heating area with a damp cloth (water with mild detergent).

Storage

• Always make sure the appliance has already been disconnected from the electrical wall outlet and cooled down completely.

• Store the appliance in a cool and clean place.

Troubleshooting

• If the appliance does not function properly, please check the below table for the solution.

• If you are unable to solve the problem, please contact the supplier/service provider.

Problem

|

Possible cause

|

Possible solution

---|---|---

Light bulb does not light on

|

1. Bulb is not connected firmly with the lamp holder

|

1. Fasten the screw of the bulb to the lamp holder

2. Bulb is burnt out

|

2. Replace the light bulb

Appliance does not heat up

|

1. Wire of heating element is loosed

|

Contact your supplier

2. Heating element is burnt out

3. The electrical components are damaged

Too high or too low temperature

|

Abnormal thermostat adjustment

|

Contact your supplier

Technical specification

Item no.: 282748

Operating voltage and frequency: 220-240V~ 50/60Hz Rated input power: 1500W

Protection class: Class I

Waterproof protection class: IPX4

Dimensions (W x D x H): 560 x 420 x (H) 770mm

Net weight: approx. 25kg

Light source: E27, Max. 60W

Oil filling(suggest): 50 ml/cycle Sugar filling(suggest): 50 g/cycle Corn kernels filling(suggest): 150g/cycle Cycle duration: approx. 2 mins

Remarks: Technical specification is subjected to change without prior notification.

Warranty

Any defect affecting the functionality of the appliance which becomes apparent within one year after purchase will be repaired by free repair or re placement provided the appliance has been used and maintained in accordance with the instructions and has not been abused or misused in any way. Your statutory rights are not affected. If the appliance is claimed under warranty, state where and when it was purchased and include proof of purchase (e.g. receipt). In line with our policy of continuous product development we reserve the right to change the product, packaging and documentation specifications without
notice.

Discarding & Environment

When decommissioning the appliance, the product must not be disposed of with other household waste. Instead, it is your responsibility to dispose to your waste equipment by handing it over to a designated collection point. Failure to follow this rule may be penalized in accordance with applicable regulations on waste disposal. The separate col lection and recycling of your waste equipment at the time of disposal will help conserve natural resources and ensure that it is recycled in a manner that protects human health and the environment. For more information about where you can drop off your waste for recycling, please contact your local waste collection company. The manufacturers and importers do not take responsibility for recycling, treatment and ecological disposal, either directly or through a public system.

Hendi B.V. Innovatielaan 6 6745 XW De Klomp, The Netherlands Tel: +31 317 681 040 Email: info@hendi.eu
Hendi Polska Sp. z o.o. ul. Firmowa 12 62-023 Robakowo, Poland Tel: +48 61 658 7000 Email: info@hendi.pl
Hendi Food Service Equipment GmbH Ehring 15 5112 Lamprechtshausen, Austria Tel: +43 6274 200 10 0 Email: office.austria@hendi.eu
Hendi Food Service Equipment Romania S.R.L. Str. 13 decembrie 94A, Hala 14 Braov, 500164, Romania Tel: +40 268 320330 Email: office@hendi.ro

PKS Hendi South East Europe SA 5 Metsovou Str. 18346 Moschato, Athens, Greece Tel: +30 210 4839700 Email: info@pks-hendi.com
Hendi Italia S.R.L. Via Leonardo da Vinci 4 39100 Bolzano (BZ), Italy Tel: +39 800 727 438 Email: office.italy@hendi.eu
Hendi HK Ltd. 1208, 12/F Exchange Tower 33 Wang Chiu Road, Kowloon Bay, Hong Kong Tel: +852 2154 2618 Email: info-hk@hendi.eu
Find Hendi on internet: www.hendi.eu www.facebook.com/HendiToolsforChefs www.linkedin.com/company/hendi-food-service-equipment-b.v. www.youtube.com/HendiEquipment

– Changes, printing and typesetting errors reserved.
© 2021 Hendi B.V. De Klomp – The Netherlands

Ver: 25-03-2021