HENDI 267240 Kebab Knife Electric User Guide

HENDI 267240 Kebab Knife Electric User Guide

You should read this user manual carefully before using the appliance.

Keep these instructions with the appliance.

For indoor use only.

For item 267420 only.

Dear Customer,

Thank you for purchasing this Hendi appliance. Before using the appliance for the first time, please read this manual carefully, paying particular attention to the safety regulations outlined below.

Safety regulations

• This appliance is intended for commercial use.
• The appliance must only be used for the purpose for which it was intended and designed. The manufacturer is not liable for any damage caused by incorrect operation and improper use.
• Keep the appliance and electrical plug away from water and any other liquids. In the event that the appliance should fall into water, immediately remove plug from the socket and do not use until the appliance has been checked by a certified technician. Failure to follow these instructions could cause a risk to lives.
• Never attempt to open the casing of the appliance yourself.
• Do not insert any objects in the casing of the appliance.
• Do not touch the plug with wet or damp hands.
•   Danger of electric shock! Do not attempt to repair the appliance yourself. In case of malfunctions, repairs are to be conducted by qualified personnel only.
• Never use a damaged appliance! Disconnect the appliance from the electrical outlet and contact the retailer if it is damaged.
• Warning! Do not immerse the electrical parts of the appliance in water or other liquids. Never hold the appliance under running water.
• Regularly check the power plug and cord for any damage. If the power plug or power cord is damaged, it must be replaced by a service agent or similarly qualified persons in order to avoid danger or injury.
• Make sure the cord does not come in contact with sharp or hot objects and keep it away from open fire. To pull the plug out of the socket, always pull on the plug and not on the cord.
• Ensure that the cord (or extension cord) is positioned so that it will not cause a trip hazard.
• Always keep an eye on the appliance when in use.
• Warning! As long as the plug is in the socket the appliance is connected to the power source.
• Turn off the appliance before pulling the plug out of the socket.
• Never carry the appliance by the cord.
• Do not use any extra devices that are not supplied along with the appliance.
• Only connect the appliance to an electrical outlet with the voltage and frequency mentioned on the appliance label.
• Connect the power plug to an easily accessible electrical outlet so that in case of emergency the appliance can be unplugged immediately. To completely switch off the appliance pull the power plug out of the electrical outlet.
• Always turn the appliance off before disconnecting the plug.
• Never use accessories other than those recommended by the manufacturer. Failure to do so could pose a safety risk to the user and could damage the appliance. Only use original parts and accessories.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge.
• This appliance must not be used by children under any circumstances.
• Keep the appliance and its cord out of reach of children.
• Always disconnect the appliance from the mains if it is left unattended or is not in use,and before assembly, disassembly or cleaning.
• Never leave the appliance unattended during use.

Special Safety Regulations

• This Kebab slicer is a portable machine and equipped with mechanically driven cutting knife.
• This machine is intended only for cutting any type of grilled meat in profession conditions for commercially use.
• Use the machine only as described in the manual.
• This machine should be operated by specialized trained personnel and used in food industry such as catering, restaurant, bar, etc.
• All maintenance and repair works should be performed by specialized trained authorized technicians.
• Wear protective clothing, mask, or protective glasses if necessary (not supplied) during operation.
•   WARNING: Take great care and strong concentration when handling the cutting knife during operation
• Only use the machine with knife correctly mounted with the knife protector and adjustments ring.
• DO NOT use the machine with a damaged knife protector or damaged adjustment ring.
• WARNING: ALWAYS switch off the machine and unplug from electrical power supply before cleaning, maintenance or storage.
• WARNING! ALWAYS keep hands, fingers, long hair and clothing away from the cutting knife.
• WARNING! DO NOT pointed at the people with the machine during operation.
• Caution! Securely route the power cord if necessary in order to prevent unintentional pulling or accident.
• DO NOT continuously operate the machine to avoid overheat the motor. The maximum continuous operation time is about 15~20 minutes. Operate the machine again after it has been cooled down.
• Keep the power cord away from heating soures, oil, sharp edges or moving device part.
• Check regularly whether the moving parts function properly and make sure there is no jam.
• Operate the machine in a clear, tidy workplace and observe the hygiene regulations of each country.
• Do not wash the machine with water or a waterjet. Washing with water can cause leakage and increase the risk of electric shock. No parts are dishwasher safe.
• Do not clean or store the machine unless it is completely cooled down & stopped.
•  For item 267240, it is classified as protection class II machine.
• For item 267257, it is charged by a supplied battery charger.

Intended use

• This appliance is intended for professional use.
• The appliance is designed solely for cutting any type of grilled meat in profession conditions. Any other use may lead to damage of the appliance or personal injury.
• Operating the appliance for any other purpose shall be deemed a misuse of the device. The user shall be solely liable for improper use of the device.

Product description

Main technical parameters

Unit: mm

Remark: DO NOT continuously operate the machine to avoid overheat the motor. The maximum continuous operation time is about 15~20 minutes. Operate the machine again after it has been cooled down.

Replacement of the circular knife

Risk of death

Due to unintended starting up of the Kebab slicer

Disconnect the Kebab slicer from the power supply.

Risk of injury!

The knife is sharp.
Deep cuts can be caused.

Remove the knife carefully.

CAREFUL: Malfunction!

Incorrect installation of the knife.
Prevents correct functioning of the Kebab slicer.

Always install the knife with the sharpened side toward the motor.

Cutting meat

Meat is grilled from the outside to the inside. The inside meat is still raw.

Cutting thicknesses of 0.5 mm to 8 mm can be set.

In order to do so, turn the adjusting screw to the left (larger) or right (smaller).

WARNING: Risk of injury!

• Check that the knife protector is correctly seated
• Ensure a secure stand
• Always work from top to bottom
• Only cut grilled meat
• Only turn the kebab knife on when it has been applied to the kebab.

Overheat protection (For item: 267240)

Please note that the RESET button is located under the handle for overheat protection.

• Unplug the machine from the electrical outlet first.
• Allow the machine to cool down.
• Press the RESET button under the handle
• Plug in & ready for use again.

Hygiene/cleaning

Hygiene instructions

General hygiene instructions

• Wash hands before and after contact with food.
• Cover open wounds with a waterproof plaster.
• Avoid touching food with naked hands.
• Clean and disinfect all devices daily

Cleaning

Attention! Always unplug the machine from the electrical power outlet and let it cool down completely before cleaning and storage.

• Clean the machine after each use.
• Never immerse the machine in the water.

WARNING! Take great care when cleaning. The knife is sharp. Deep cuts can be caused.

• Remove the knife carefully.
• Remove heavy soiling on the knife, clean the protector with cleaning aids, such as sponges and brushes.
• Spray all surfaces with a fat solvent and some disinfectant and allow it to take effect for at least 5 minutes.
• Rinse off the cleaning aids on kebab knife, knife protector with a damp cloth.Keep it dry and assembly.

Handling food

• Heat meat through to at least 70ºC.
• Store meat at below 5ºC or freeze (below-18ºC).
• Avoid contact between raw and cooked food.

Clean the knife and body prior to sharpening. After the sharpening process, carry out cleaning and disinfection again.

Sharpening the knife

For item: 267257 battery & charger
Technical data of charger
Input: 100-240V~ / 50-60Hz
Power: 20W
Output: 12Vdc / 1.5A
Capacity: 2000 mAh

Battery pack safety

• Battery pack shall be stored and charged in a well-ventilted, dry, cool and clean environment.
• Do not expose battery pack to extreme or high temperatures, like direct sunlight or fire. Do not place the battery pack on or near any heat source.
• Avoid unintentional switching on, ensure the on/ off switch is the off position before inserting battery pack.
• Do not disassembly the battery pack.
• In case of damage and improper use of the battery, vapors may be emitted. Provide for fresh air and seek medical help in case of complaints.
• When the battery is defective, liquid can escape and come into contact with adjacent components. Check any parts concerned.
• Use the battery only in conjunction with your kebab knife.
• Only use the provided charger to charge the battery pack. DO NOT use other charger to charge this battery pack.
• Do not crush, drop or damage the battery pack. Do not use a battery pack or charger that has been dropped or received a sharp blow. A damaged bat- tery is subject to explosion. Properly dispose of a dropped or damaged battery immediately.

Charger safety

• Protect the battery charger from rain and moisture.
• Do not use this charger to charge other batteries.
• Do not operate the charger on easily inflammable surface (e.g. paper, textiles, etc.) or combustible surrounding.
• Operate the charger in a well-ventilated, dry, cool and clean environment.
• Plug the charger within the listed voltage range on the charger.
• Unplug the charger from the electrical outlet before attempting any maintenance or cleaning to reduce the risk of electric shock.
• Disconnect charger from the power supply when not in use.
• Do not touch the uninsulated portion of output connector or uninsulated battery terminal.

Charging the battery

• Use only the original charger. Only this charger is matched to the Lithium-ion battery of the kebab slicer.
• The battery is supplied partially charged. To ensure full capacity of the battery, please completely charge the battery before using the kebab slicer for the first time.
• Do not allow children to replace the battery pack or charging the battery pack.
• The battery pack can be charged at any time without reducing its service life. Interrupting the charging procedure does not damage the battery.
• To remove the battery, press the battery release button and pull out the battery. Do not exert any force.
• Caution! Danger of explosion if battery pack is incorrectly replaced. Replace battery pack with the supplied battery pack.

WARNING: Do not continue to press the on/off switch after the machine has been automatically switched off. The battery pack may be easily damaged.

LED functions of charger

Warranty

Any defect affecting the functionality of the appliance which becomes apparent within one year after purchase will be repaired by free repair or replacement provided the appliance has been used and maintained in accordance with the instructions and has not been abused or misused in any way. Your statutory rights are not affected. If the appliance is claimed under warranty, state where and when it was purchased and include proof of purchase (e.g. receipt).

In line with our policy of continuous product development we reserve the right to change the product, packaging and documentation specifications without notice.

Discarding & Environment

When decommissioning the appliance, the product must not be disposed of with other household waste. Instead, it is your responsibility to dispose to your waste equipment by handing it over to a designated collection point. Failure to follow this rule may be penalized in accordance with applicable regulations on waste disposal. The separate collection and recycling of your waste equipment at the time of disposal will help conserve natural resources and ensure that it is recycled in a manner that protects human health and the environment. For more information about where you can drop off your waste for recycling, please contact your local waste collection company. The manufacturers and importers do not take responsibility for recycling, treatment and ecological disposal, either directly or through a public system.

Part list for item 267240

Part list for item 267257

References

• hendi.com
• Welkom - HENDI Tools for Chefs

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>