emerio VS-121116 Vacuum Sealer Instruction Manual

VS-121116 Vacuum Sealer
Instruction Manual

SAFETY INSTRUCTIONS

Before use make sure to read all of the below instructions in order to avoid injury or damage, and to get the best results from the appliance. Make sure to keep this manual in a  safe place. If you give or transfer this appliance to someone else make sure to also include this manual.
In case of damage caused by the user failing to follow the instructions in this manual, the warranty will be void. The manufacturer/importer accepts no liability for damages caused by failure to follow the manual, negligent use, or use not in accordance with the requirements of this manual.

1. This appliance can be used by children aged 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance.
   Cleaning and user maintenance shall not be made by children without supervision.

2. If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or similarly qualified persons in order to avoid a hazard.

3. Before inserting the plug into the main socket, please check that the voltage and frequency comply with the specifications on the rating label.

4. If an extension cord is used it must be suited to the power consumption of the appliance, otherwise overheating of the extension cord and/or plug may occur. There is a potential risk of injuries from tripping over the extension cord. Be careful to avoid dangerous situations.

5. Disconnect the mains plug from the socket when the appliance is not in use and before cleaning.

6. Ensure that the mains cable is not hung over sharp edges and keep it away from hot objects and open flames.

7. Do not immerse the appliance or the mains plug in water or other liquids. There is a danger to life due to electric shock!

8. To remove the plug from the plug socket, pull the plug.
   Do not pull the power cord.

9. Do not touch the appliance if it falls into the water. Remove the plug from its socket, turn off the appliance and send it to an authorized service center for repair.

10. Do not plug or unplug the appliance from the electrical outlet with a wet hand.

11. Never attempt to open the housing of the appliance, or to repair the appliance yourself. This could cause electric shock.

12. Children are unable to recognize the hazards associated with incorrect handling of electrical appliances. Therefore, children should never use electric household appliances unsupervised.

13. Never leave the appliance unattended during use.

14. This appliance is not designed for commercial use.

15. Do not use the appliance for other than intended use.

16. Do not wind the cord around the appliance and do not bend it.

17. Do not place the appliance in a wet, dusty, or easily wet place.

18. Do not shake or drop the appliance, and prevent the appliance from being impacted.

19. Please do not place the appliance near the gas furnace or heat dissipation items.

20. The heating tape of the vacuum sealer will become hot during use. Even if the lid is open, the sealing strip may become hot. There is a burn hazard.

21. WARNING!!
    Please do not touch surfaces while in use. The temperature of accessible surfaces may be high when the appliance is operating.

PARTS DESCRIPTION

OPERATION

1. A roll of plastic film is provided with the appliance. Cut the length of the plastic film according to the size of the food that needs to be packed (6cm longer than the food).
   The appliance has an “integrated foil cutter” on the backside, you can use it to cut the plastic film/foil within 30cm width.
   (1) Pull down the integrated foil cutter, place the plastic film in a place like below picture A;
   (2) Close the integrated foil cutter, and then push the cutter (C) to cut the film. (Fig. B)
   

2. Plug the appliance into a properly installed mains socket.

3. Open the cover, and put one side of the plastic film that needs to be sealed onto the heating tape. (See fig. 1)
   

4. Close the cover, and press the two ends of the cover (where marked with icon “ ”) to lock it. Two “click”
   sounds will be heard.

5. Press the “seal only” button. The red light illuminates and the appliance begins to seal, the sealing time is about 10 seconds. When ready, the red light goes out. The appliance is in standby mode now.

6. Press the unlock button in both sides, open the cover and take the plastic film out. Now it’s a plastic bag.

7. Put the food in the plastic bag.

8. Open the cover again, put the open end of the bag onto the heating tape, and lock the cover.

9. Press the “Vacuum-package and seal I” or “Vacuum-package and seal II” button. The green light illuminates. The vacuum function is started. When it reaches a certain vacuum degree, the appliance will automatically convert to the seal function. At this time, the green light goes off and the red light illuminates. When the seal is ready, the red light goes off.  Select“Vacuum-package and seal I” to vacuum-package soft, sensitive items or food (soft vacuumpackaging). Select the“Vacuum-package and seal  II” function button for normal vacuum packaging.

10. Press the unlock button on both sides, open the cover and remove the complete vacuum-packed bag.

11. Wait at least 40 seconds before using the appliance again. Unplug the appliance after use.

Tips

• If you want to stop running, please press the “cancel” button.
• Use a plastic film or bag with embossing and 0.2-0.29mm thickness.
• Try to keep the bag smooth during the vacuum sealing process. Wrinkles in the bag can keep residual air in the bag and cause food spoilage.
• Although the plastic material of the bags is quite strong, it can be punctured by sharp items. So if you are sealing foods with sharp edges (pasta, dried fruits, etc.), use some common plastic wrap before vacuum sealing. This will protect the bag from being punctured.
• If the vacuum pump continues to run. Press the “cancel” button to make it stop. Check if the condition of the sealed seal is good. Then place the open end of the bag smoothly and correctly, and lock the cover. Start the appliance again.

Attention

1. To pack the food containing little water
   The water will flow into the interior of the appliance, resulting in failure. So please use a kitchen towel o remove the moisture, or use a plastic wrap or a disposable plastic wrap to carry out vacuum packaging.
   A slightly frozen state will facilitate the vacuum packaging.

2. To pack powder food
   The powder may be inhaled. Before the vacuum packaging, please put it into a disposable plastic bag.

3. To pack fruits and vegetables
   It is not recommended to vacuum fruits and vegetables which are fragile or with a high amount of water.
   When vacuum-packed, the food will be pressured to generate extra water and gas to make the bag bulge.

4. To pack the liquid food
   It must not be vacuum packed, only need to be sealed.
   When sealing liquid food, place the appliance higher than the food.

Storage
For vacuum-packed food (except dehydrated food), frozen storage is advised.
For packaged vegetables, please eat in 2 weeks, to avoid rot.

Microwave
If you want to put the vacuum-packed food in a microwave, punch a hole in the plastic bag first. SUITABLE FOR THAWING IN THE MICROWAVE TO MAX. 70 ° C.

CLEANING

1. Unplug the appliance. Always let the appliance cool off completely before you clean it.
2. Wipe the appliance with a soft damp cloth. It should be kept as its cover unlocked.

PROBLEMS AND SOLUTIONS

If there is an exception, please check the following:

2. Check if the plug is damaged.
3. Check whether it is used continuously.
Cannot be sealed| 1. Check whether the bag is folded or uneven.
2. Check whether the cover is locked in place.
3. Check whether the heating tape is damaged.
4. Check if there is any leftover food along the sealing line.
Cannot be vacuum-packed| 1. Check if the plastic bag is placed correctly in the vacuum area.
2. Check whether the bag is folded or uneven.
3. Check whether the plastic bag is broken.
4. Check whether the food in the bag is too much.
5. Check whether the air suction is blocked.
6. Check whether it is a special plastic bag.
7. Check the top or bottom of the seal is intact.
8. Check the vacuum valve is in the state of the press.
9. Check the two vacuum packaging running time interval of 40 s
After vacuum packaging, plastic
bags gradually leak| 1. For sharp objects, please use some common plastic wrap before vacuum packaging.
2. If the plastic bag is too thin, the air may penetrate the bag. So please use a bag with embossing and 0.2-0.29mm thickness.
3. The plastic bag containing food (itself exuding gas), might seem like a vacuum disappears.

TECHNICAL DATA

Operating voltage: 220-240V~ 50Hz
Power consumption: 110W

GUARANTEE AND CUSTOMER SERVICE

Before delivery, our devices are subjected to rigorous quality control. If, despite all care, the damage has occurred during production or transportation, please return the device to your dealer. In addition to statutory legal rights, the purchaser has an option to claim under the terms of the following guarantee:
For the purchased device we provide 2 years guarantee, commencing from the day of sale. If you have a defective product, you can directly go back to the point of purchase.
Defects that arise due to improper handling of the device and malfunctions due to interventions and repairs by third parties or the fitting of non-original parts are not covered by this guarantee. Always keep your receipt, without the receipt you can’t claim any form of warranty. Damage caused by not following the instruction manual will lead to a void of warranty, if this results in inconsequential damages then we will not be liable.
Neither can we hold responsible for material damage or personal injury caused by improper use if the instruction manual is not properly executed? Damage to accessories does not mean free replacement of the whole appliance. In such case please contact our service department. Broken glass or breakage of plastic parts is always subject to a charge.  Defects to consumables or parts subjected to wearing, as well as cleaning, maintenance, or the replacement of said parts are not covered by the warranty and are to be paid.

ENVIRONMENT-FRIENDLY DISPOSAL
Recycling – European Directive 2012/19/EU
This marking indicates that this product should not be disposed of with other household wastes. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmentally safe recycling.

Emerio Holland B.V.
Zomervaart 1A
2033 DA Haarlem
The Netherlands
Customer service:
T: +31(0)23 3034369
E: info.nl@emerio.eu

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>