XUNDA PGS-4 Portable Gas Stove Home BBQ Camping Gas Cooker Single Burner Gas Stove User Manual

PGS-4 Portable Gas Stove Home BBQ Camping Gas Cooker Single Burner Gas Stove
User Manual

**TO START

**

Inserting the gas cartridge

1. Turn the ignition knob to OFF and set the cartridge lever to UNLOCK. ( Fig 1 ) Note: if the ignition knob is ON the gas cartridge cannot be loaded into the cooker.

2. Open the cartridge cover: slide the gas cartridge, top-end first and with its notch up, into the compartment. Align the notch with the loading guide in the compartment.
   ( Fig 2 ) Check that the seals between the appliance and the gas container are in place and in good condition before connecting the gas container.
   DO NOT use this appliance if it has damaged or worn seals.
   DO NOT use this appliance if it is leaking, damaged, or does not operate properly

3. Push the cartridge lockdown to LOCK in one firm motion ( Fig 3 )

WARNING!
THE OPENINGS AT THE BASE OF THE BURNER PROVIDE AIR FOR COMBUSTION, AND SHOULD NEVER BE OBSTRUCTED. IF THE FLAME BECOMES SIGNIFICANTLY ORANGE CHECK THESE OPENINGS FOR A BLOCKAGE.
IF THE APPLIANCE CAN NOT BE ADJUSTED TO PERFORM CORRECTLY IT SHOULD NOT BE USED UNTIL SERVICED OR REPAIRED.

LIGHTING THE COOKER

1. Turn the knob anti-clockwise past the high position until a click is heard.
2. If the burner fails to light, immediately turn the ignition knob to the OFF position and repeat step 1.

TO ADJUST HEAT

1. Flame can be controlled by turning the ignition knob between the LOW and HIGH positions.

TO SHUT OFF

1. Turn the ignition knob to shut off the fuel supply ( Fig 5 ). Wait until the flame is fully extinguished before performing the next step.
2. Raise the cartridge lock lever to UNLOCK and remove the gas cartridge from the compartment. Note: do not leave the gas cartridge inside the unit when not in use.

The cartridge may be disconnected even if some gas remains.
Check the contents by shaking and listening for the liquid gas.
Gas containers shall only be changed in a well-ventilated location, preferably outside. away from people and away from sources of ignition: such as naked flames pilot, electric heaters/ equipment.
If there is a leak on your appliance (smell of gas) and you cannot stop the gas flow, remove the appliance to a well-ventilated location away from any ignition source. Only check for leaks outdoors using soapy water. Do not try to detect leaks using a flame.
This appliance must only be serviced by an authorized person.

AFTER USE

1. Replace the cap on the gas cartridge after removing it from the unit. Store upright in a cool dry place.
2. Make sure the burner is cool to touch before packing the unit away.
3. Do not store the cartridge near other flammables.

DO NOT store the cartridge near sources of heat or direct sunlight.
DO NOT store it in the glove compartment or boot of your car.
DO NOT puncture or incinerate empty cartridges.

SAFETY TIPS

DO

• Turn gas off at ignition knob after use.
• Check that the burner is fully extinguished before disconnecting the gas container
• Remove the gas container outside and away from people.
• Change the gas container outside and away from people.
• Check the seals before connecting a new gas container to the appliance.
• Always remove the cooker from the carry box prior to use.
• Keep children away from this appliance
• Make sure there is adequate ventilation under the unit.
• Only operate on flat, horizontal surfaces
• Use the cooker in cool places or in the shade. Keep the cartridge compartment out of direct sunlight.
• Always check the gas cartridge position inside the compartment for leaks. If a leak occurs, turn off the supply and remove the gas cartridge.

DO NOT

• Do not operate in an enclosed area without ventilation
• Do not operate in a boat, caravan, or tent
• Do not modify this appliance.
• Do not use the cooker in sand or on gravel surfaces
• Do not move the cooker while it is lit.
• Avoid using the cooker in very windy conditions.
• Do not use a cooking pan that is smaller than 14cm and larger than 19 cm in diameter
• Do not use the appliance as a room heater or clothes drier.
• Do not place articles on or against this appliance.
• Do not place chemicals or flammable materials or spray aerosols near this appliance.

CARE AND CLEANING:

• The outside of the cooker can be wiped clean with a mild solution of dishwashing detergent and finished off with a dry cloth. Do not use abrasive pads.
• The drip pan can be washed thoroughly. Always dry after washing.
• We recommend the burner head be cleaned by gentle scrubbing with a dry brush at least annually. Ensure that the burner ports are free of any obstructions.
• Occasionally clean the point of the piezo plug with a hard brush.

Keep this appliance away from combustible materials
Minimum clearances: rear 600mm-side 600mm- top 500mm
Gas consumption: 2×2.3kw(166g/h)
Injector size: 0.56mm

Troubleshooting :

Problem →
Cause ↓
| No ignition| No burning| Unstable
flame| Uneven
ame| Slow-burning| Gas smell| Stopped
working
while in use| Continued
burning| solution
---|---|---|---|---|---|---|---|---|---
Lack of fuel| .| .| | | .| | .| | Replace cartridge
Piezo plug dirty| | | | | | | | | Clean spark point
Dirty burner| .| .| .| .| .| | | | Clean burner
Cartridge misaligned| .| .| .| | .| .| | | Reset correctly
A dirty burner or empty cartridge| .| .| | .| | | | | Request for inspection/ service
Faulty knob
mechanism| .| | | | | .| | .| Request for inspection/ repair
Internal gas pressure too high| | | | | | | | | Cooldown gas

Read User Manual Online (PDF format)

Download This Manual (PDF format)

Download this manual  >>