PRINCE CASTLE WBTS0943 Tomato Saber 943-B Stainless Steel Stainless Steel 216mm Instruction Manual

**PRINCE CASTLE WBTS0943 Tomato Saber 943-B Stainless Steel Stainless Steel 216mm Instruction Manual

**

Prince Castle’s Tomato SaberTM slicer is designed to precisely slice whole tomatoes. With the exclusive Perma-TightTM disposable blade cartridge system, this unit never requires blade tightening or adjusting. Engineered for durability and long life, the Tomato SaberTM features self-lubricating bearings, a blade guard, and a contoured Tomato Pusher. The unit is shipped with a Tomato Catcher, Table Stop, and Tomato Core-ItTM’

PRODUCT SPECIFICATION

INSTALLATION

1. After you have removed the Tomato Saber TM from the carton, inspect the unit for signs of damage. If there is damage to the unit:
   • Notify carrier within 24 hours after delivery.
   • Save carton and packing materials for inspection purposes.
   • Contact your local Prince Castle dealer or the Prince Castle Customer Sales Department at 1-800-722-7853, if purchased directly, to arrange for a replacement to be sent.
2. Verify that all parts have been received.
   • Tomato SaberTM slicer and Perma-Tight blade cartridge.
   • Tomato Catcher—neatly catches tomato slices.
   • Table Stop Assembly—stabilizes unit for easier slicing.
   • Tomato Core-ItTm—easily removes cores before slicing.
3. Place slicer on prep table or flat surface.
4. Attach Tomato Catcher to slicer by sliding bottom
   **Figure 1

cutouts over Knobs at far end of unit. See figure 1
IMPORTANT:** Use of the Tomato Catcher is optional.

5. Attach Table Stop by first removing two knobs from the operator end of slicer. Align the two holes of Table Stop with the holes in the base of the slicer. Reattach the two previously removed knobs over the Table Stop. See figure 2

OPERATION

CAUTION: Blades are Extremly sharp.
Keep fingers away from blades.

IMPORTANT: The Tomato Saber TM is designed to slice tomatoes only. Using it to slice other products will damage the slicer and void the warranty.

1. For best results, use fresh, ripe tomatoes. Toma-toes should not exceed 3-1/2 inches (.76cm) in diameter.

2. Core the tomato using Prince Castle’s Tomato Core-ItTM. Make sure to remove the core com-pletely.

3. While holding top handle with one hand, grasp round pusher handle with other hand, and pull carrier assembly all the way back.

4. Position Tomato Against Tomato Pusher with Core

5. While Holding Bridge with One Hand, Grasp Round Pusher Handle with Other Hand, Push Tomato Completely  Through Blades with **ONE QUICK, FIRM

STROKE **until the pusher head stops. See Figure 4

6. After tomato has been sliced, remove tomato slices from Tomato Catcher.

CLEANING

CAUTION: Blades are extremly sharp.
keep fingers away from blades.

IMPORTANT: The Tomato SaberTM must be cleaned after each use.

1. Remove Tomato Catcher and Table Stop to clean separately. Note: Do not remove Perma-TightTM blade cartridge from unit.
2. Spray slicer with hot water to remove any tomato residue.
3. With hot, soapy water, scrub Tomato Pusher using a nylon brush. With same brush, clean blades from back side.
4. Rinse unit with hot water.

REPLACING BLADES

1. Grasp round, red handle and pull carrier assembly all the way back. 2. While holding the bridge with one hand, firmly grasp the blade cartridge by the finger grip with

2. While holding the bridge with one hand, firmly grasp the blade cartridge by the finger grip with other hand.pull the blade cartridge all the way out. The blade clip will release the cartridge. See Figure 5

3. Slide in the new blade cartridge with arrow facing up. See figure 6.

4. Firmly push the blade cartridge into place until it snaps into the blade clip . See figure 7.

5. Properly discard the old blade cartridge using the packaging from new blade cartridge.

EXPLODED VIEW

PARTS LIST

ITEM| PART NO.| DESCRIPTION| ITEM| PART NO.| DESCRIPTION
---|---|---|---|---|---
1| 943-038A| Blade Assy. 3/Is” (0.48 cm)| 6| 943-018S| Tomato Catcher
| 943-039A| Blade Assy. ‘/4″ (0.64 cm)| 7| 943-0335| Guide Rod Knobs (Pkg. of 2)
| 943-040A| Blade Assy. 318″ (0.95 cm)| 8| 943-012| Blade Guard
| 943-041A| Blade Assy. 7/32″ (0.55 cm)| 9| 943-002| Base
2| 943-0475| Table Stop w/Knobs| 10| 89-959S| Rubber Foot (Pkg. of 4)
| 76-626S| Knobs (Pkg. Of 2)| 11| 943-034S| Blade Latch Kit
3| 943-0495| Pusher Handle w/Mounting Screw| 12| 943-006S| Carriage with Bearings
4| 943-050| Tomato Pusher Assy.| 13| 943-017S| Guide Rods w/Cushions (Set of 2)
| | 3/ 16“ & 3/8“ (0.48 cm & 0.95 cm)| 14| 919-17S| Guide Rod Cushions (Pkg. of 4)
| 943-050WC| Tomato Pusher Assy. 3/16″| 15| 943-016| Carriage Plate
| | (For 943-W Only)| | |
| 943-051| Tomato Pusher Assy. 1/4″ (0.64 cm)| | |
| 943-052| Tomato PusherAssy. 7/32″ (0.55 cm)                        •| | |
5| 943-004S| Bridge w/Mounting Screws| | |

LIMITED WARRANTY

This product is warranted to be free from defects in material and/or workmanship for a period of two (2) years from date of original installation, not to ex-ceed 30 months from date of shipment from our factory with the exception of the blade car-tridge. Blade cartridge is warranted to be free from defects at time of delivery only. Any component which proves to be faulty in material and/or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) without cost to the customer for parts or labor. This warranty is subject to the following exceptions/ conditions:

• Use of products other than tomatoes will void this warranty.
• This equipment is portable; charges for on-loca-tion service (e.g., trip charges, mileage) are not included in the provisions of this warranty.
• Damage caused by carelessness, neglect, and/ or abuse (e.g., dropping, tampering or altering parts), equipment damaged in shipment, by fire, flood or an act of God is not covered under this warranty.

355 East Kehoe Blvd.
Carol Stream, IL 60188 Tel: 630-462-8800
Fax: 630-462-1460
Toll Free: 1-800-PCASTLE

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>