GIBSON KG8SA 80 G8SA Series Single Stage Furnaces Owner’s Manual
- June 15, 2024
- Gibson
Table of Contents
GIBSON KG8SA 80 G8SA Series Single Stage Furnaces
Product Information
Specifications:
- Model: 80% Ultra-Low NOx Series Single Stage Furnaces
- Voltage: 120 Volt
- Phase: 1
- Frequency: 60 Hz
Product Usage Instructions:
-
Installation Instructions:
Before using the product, please refer to the Installation Instructions provided with the furnace to ensure proper installation and setup. -
Wiring Diagram:
To wire the product correctly, follow the provided wiring diagram. Use copper conductors and replace any original wire with wiring material that has a temperature rating of at least 105°C. -
Field Wiring:
- Neutral (White)
- 120V Ground (Black)
- Low Voltage (Black, White, Green, Red, Gray)
- High Voltage (Black, Red)
-
Components and Controls:
The product consists of various components and controls. Here are some key ones:- Roll-Out Limit
- Supply Air Limit
- Pressure Switch
- Flame Sensor
- Gas Valve
- Single Stage Thermostat
- Ignitor
- Inducer Motor
- Blower Limit Switch
- Blower Motor
-
Diagnostic Description:
The product has built-in diagnostic capabilities. Here are some common fault conditions and their corresponding LED indicators:
| Fault Condition | LED Indicators |
|---|---|
| Control Fault (No Power) | Off Off |
| L1 / Neutral Polarity Fault | Flash Flash |
| 1 Hour Lockout | Alternating Flash |
| Pressure Switch Closed Fault | On On |
| Pressure Switch Open Fault | Flash On |
| Open Limit Switch Fault | Flash Off |
| Low Flame Sensor Signal | Continuous Flash |
| Flame Present | On |
FAQ :
-
Q: What should I do if I need to replace the wiring?
A: If any of the original wire as supplied with the furnace must be replaced, it must be replaced with wiring material having a temperature of at least 105°C. Use copper conductors only. -
Q: Where can I find the Installation Instructions?
A: The Installation Instructions are provided with the furnace. Please refer to that document for detailed installation guidance.
OVERVEIW
- www.gibsonhvac.com
- GIBSON is a pending or registered trademark of Electrolux Home Products Inc. and used under a license from Electrolux Home Products, Inc. © Nortek
- Global HVAC, LLC. All Rights Reserved.