aquafilter EXCITO-B Water Filtration Systems Installation Guide
- June 13, 2024
- aquafilter
Table of Contents
The clear choice
Water Filtration Systems
Installation Manual
Safety Precautions
WARNING!!! The system should not be used with biologically contaminated
water or water of unknown origin.
Product may be installed only by trained service professionals. Only original
replacement parts, filter cartridges and accessories made by manufacturer may
be used.
Compliance with the following instructions ensures:
- problem free product operation,
- manufacturer’s warranty.
Failure to comply with the following instructions will result in loss of warranty.
- Read carefully this Instruction Manual before beginning system installation.
- Check if all elements needed for the installation are included with the system. (refer to point 3 “Included in the Box”).
- Please note that after installing the system, as well as after each filter cartridge and hollow fiber membrane replacements, and in the case of long inactivity of the system, system flushing procedure must be conducted before resuming system usage.
- After inserting a tubing into a quick connector or a quick connector onto a stub the connected place should be secured with a safety clip.
- During disconnecting and connecting of tubing be sure not to break it (correctly installed tubing should be inserted 1.5 cm inside of quick connector).
- Secure quick connector with safety clip after tubing has been inserted.
- For sealing plastic components use only Teflon tape!
- Wash your hands thoroughly before and after filter cartridge or membrane element replacements.
- During the cartridge or capillary membrane installation one must consider water flow direction. An arrow put on each of our inline cartridges indicates water flow direction.
- In all cases of product returns, the system must be returned in its original packaging – otherwise the return will not be accepted.
- Manufacturer is not responsible for any damages resulted from the use of this product if used for other purposes than filtration of potable water.
- Manufacturer does not hold any responsibility for printing errors.
- Manufacturer reserve the right to introduce change or amendments to the provided technical information’s at any time and without s the necessity of a prior announcement.
Use only genuine Aqua Market® and Aqua filter® replacement parts, filter cartridges and membrane elements. In case of use of other manufacturers’ parts, Aqua filter is not responsible for any damages caused in the course of product use.
Technical Specifications
Inlet water temperature……………………………………………………between 2°C and 45°C
Water supply pressure……………………………………………………………………….3,5 bar
Water supply adapter……………………………………………………………………..1/2”
Outlet tubing…………………………………………………………………………………………1/4”
Dimensions (height x width x depth)………………………………………………….438 mm x 100 mm x 360
mm
IMPORTANT NOTE! The system must be secured from high pressures and rapid
pressure changes caused by local water supply systems. Pressure regulator must
be installed on the inlet of the system’s water supply. The system’s optimal
performance pressure is 4 bar. Failure to install pressure regulator will
result in loss of warranty. Regulator may be purchased separately – catalog
nr. ADV-REG_K.
Included in the Box
Connection diagram
System Installation
Faucet Installation
Cartridge replacement
UF membrane replacement
Filtration Cartridges
| Cartridge Type | Description | **Longevity*** |
|---|---|---|
| AIPRO-20M-QM The cartridge is made of polypropylene, which effectively |
stops mechanical sediments with a diameter of 20 µm. The cartridge is highly
effective for filtering sand, clay, rust and other sediments.| 3 – 6 months
| AISTRO-2-QM The cartridge contains specialty water softening-iron removing
filtration media. Reduces the water hardness and lowers the concentration of
iron.| 3 – 6 months
| AICRO-3-QM Granulated activated carbon cartridge made of the high grade
activated coconut carbon. It is designed to remove up to 99% of chlorine,
sediments and organic contaminants. It also improves the taste and aroma of
water.| 3 – 6 months
| AICRO-4-QM Granulated activated carbon cartridge with KDF media made of the
high grade activated coconut carbon. It is designed to remove up to 99% of
chlorine, sediments and organic contaminants. In addition, a special
filtration media removes heavy metals such as lead, nickel, chromium and many
others. It also improves the taste and aroma of water.| 3 – 6 months
| TLCHF-2T removes mechanical impurities such as rust, sand, silt, suspended
solids and some bacteria and viruses. Offered
hollow fiber in the new, transparent PET housing.| 6 – 12 months
-
Depends on amounts of filtered water, its quality and level of contamination
Before the first use of system and after each cartridge replacement, the system should be flushed with water for at least 10 minutes. Next, allow the system to standby for 5-6 hours to activate its filtration ability. After these procedures, filtered and conditioned water may be consumed.
WARNING! Filter cartridges are not subject to complaint at the time of:- after opening protective packaging,
- after first use of filter cartridges.
The producer does not hold any responsibility for printing errors.
We reserve the right to introduce change or amendments of the provided
technical information’s at any time and without the necessity of a prior
announcement.
Headquarters
Aqua filter, Inc.
P.O. Box 709, Sparks
MD 21152, USA
www.aquafilter.com
e-mail: info@aquafilter.com
Made in Aqua filter Europe
Copyright 2012
All rights reserved. XI-EXCITO-B
Marketing Aqua filter.
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>