ZIPPO Z8A20 Yellow Flame Butane Light Insert Instruction Manual
- June 13, 2024
- ZIPPO
Table of Contents
ZIPPO Z8A20 Yellow Flame Butane Light Insert
FILLED / UNFILLED TORCH INSERT WARNINGS:
WARNING: KEEP LIGHTER AND THEIR FUELS OUT OF REACH OF CHILDREN. Ignite
lighter away from face and clothing. Be sure flame is out after use. If
filled, contains flammable gas under pressure. If unfilled, when filled, will
contain flammable gas under pressure. Never expose to heat above 50°C (122’F)
or to prolonged sunlight. Never puncture or put in fire. Do not keep lit for
more than 30 seconds. Do not refuel over containers such as sinks or near a
flame. Butane tends to settle and collect in the lowest point.
If you have any problems with the operation of your Product, DO NOT return it
to the retail store. Instead, consumers should contact their local
distributors listed on zippo.com.
WARNING: Read all safety warnings and instructions. Failure to follow the
warnings and instructions may result in Product damage and/or serious injury.
Extra care should be taken to prevent burn, injury, or fire. Save these
instructions for future reference.
GENERAL SAFETY WARNINGS AND INSTRUCTIONS
-
Keep lighters and their fuels out of reach of children.
-
Ignite lighter away from face and clothing.
-
Be sure flame is out after use.
-
When filled, will contain flammable gas under pressure.
-
use butane fuel only.
-
DO NOT refuel over containers such as sinks or near a flame. Butane tends to settle and collect
in the lowest point -
Fill or refill in a well-ventilated area.
-
Hold insert or lighter away from face.
-
Use Zippo® butane fuel for best performance.
-
For safe refilling: ensure proper mating between refill can nozzle and lighter filling valve.
-
Wait at least 2 minutes after refilling before using the insert.
-
DO NOT keep lit for more than 30 seconds
-
Never expose to heat above 50°C (122° or to prolonged sunlight.
-
Never puncture or put in fire.
-
DO NOT point lighter towards face.
-
This insert is only designed to work with regular-sized genuine Zippo Windproof Lighter models including; Regular, Vintage, Armor®, and 1941 Replica.
-
DOES NOT work with Slim or 1935 Replica models.
-
DO NOT attempt to disassemble the Product for cleaning or modify it in any manner. This will void the warranty.
-
Always grasp lighter case edge(s) with fingers) and thumb when inserting or removing butane insert. Gripping face of lighter may cause difficulty.
-
Follow all instructions and warnings provided by manufacturer of any other item when using this product.
DISCLAIMER :
ZIPPO WILL NOT BE RESPONSIBLE OR LIABLE FOR ANY DAMAGES YOU OR ANY THIRD PARTY
MAY SUFFER AS A RESULT OF USE OR MISUSE OF THIS PRODUCT.
OPERATING INSTRUCTIONS
Install the Insert into your Zippo Lighter Case.
Butane Filling Instructions
Fill or refill in a well-ventilated area.
Ignition:
Strike the Flint Wheel in a downward motion then press the Ignition Button
with your thumb and hold to ignite flame.
Yellow Flame Butane Lighter Inserts
- Fint wheel
- Ignition button
- flame
- Cam
- Butane Filling Valve
- Flint screw
To re-flint your Insert:
Remove screw and attached spring from the bottom of the insert. Be sure flint
is removed from tube. Place new flint in tube and replace the spring, screw
lightly. Be sure screw is turned as far as it will go. If wheel binds after
new flint is inserted, turn it back wards few times.
Performance Tips
- Like all butane lighters, the performance of this lighter insert is affected by high altitudes over 5,000 feet (1,500 meters). For optimum performance, always use Zippo or Ronson® butane fuel. Use of other brands may result in clogging and poor ignition rate, especially at high altitudes and below-freezing temperatures.
- All butane lighters must be kept above freezing in order to operate. Storing lighter insert in an inner pocket or warming it in your hand for a few minutes will enable the lighter to be used at cold temperatures.
European Repair Clinic
Zippo GmbH
Groendahlscher Weg 87
46446 Emmerich am Rhein
DEUTSCHLAND
Tel: +49 (6)2822 7134 100
www.zippo.de
S. K. Beda Par Group Ltd.
Omni 13 Main Street
P. Q. Box 388 Gibraltar
Phone: + 350 200 74307
Fax: • 350 200 73103
www.omni-gib.com
[email protected]