HENDI 199961 Smoke Generator User Manual

Smoke infuser, Hendi no. 199961, 199992.

Important Safety Instructions

Read this instruction manual carefully before using the product and retain for future reference. It contains important information for your safety as well as operating and maintenance advice.

• This product is intended use for smoke infusing to the finished food such as meat, vegetables, fish, sauce, etc.

• Use the product only as described in this manual. Do not use this product for anything other than its intended use as it may lead to personal injury or damage to the product.

• This product is intended for household use and indoor use only.

• This product is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge.

• Keep this product out of the reach of the children.
  CAUTION! Hot surface. Danger of burns! The front metal barrel and burning chamber of the product will become very hot during and after use. Allow the product to cool completely before touching barrel or burning chamber for cleaning or storing.

• Always ensure the product is properly assembled before use. Follow the instructions in this manual. Do not use a damaged product.

• Do not attempt to burn anything other than small wood chips, wood sawdust, dried herbs, cooking spices, or tea leaves in the burning chamber.

• Do not use the product near explosive, flammable materials or any other heating sources.

• Do not place any part of the product in a gas, electric or microwave oven or on a hot gas or electric burner.

• WARNING: ALWAYS switch OFF when not use. Do not leave the product unattended when in use.

• Keep using this product clear of walls, curtains and other heat or steam sensitive materials.

• Leave at least 30 cm spacing around the food and the product for ventilation purpose during use.

• Use the product in a well-ventilated area, the burning of wood chips/dust, dried herbs, cooking spices, and/or tea leaves may result in the emission of combustion by-products which is not good to health for long period of exposure.

• Always empty ash when igniting material into a non-flammable receptacle.

• Exercise extreme care when igniting the wood chips in the burn chamber of the product; improper ignition of flammable materials may result in explosion or fire hazard. Do not overturn the product during operation.

• Always use a match or lighter to ignite the materials in the burning chamber of the product. DO NOT use a kitchen torch or other heat device as the excessive heat may damage the product.

• Do not point the product at any person or flammable object.

• Do not block the exit or bend the hose when in use to avoid damage to the hose.

• CAUTION! Never switch ON the product without the metal barrel or mesh filter put in place properly.

• Never disassembly of any parts of the product other than the front barrel for cleaning purpose.

• Avoid using the product in areas where smoke may activate smoke alarms, smoke detector or fire suppression systems.

• Do not immerse the product in water or other liquids for cleaning as this may damage the product. No parts are dishwasher safe.

Battery Safety Instructions

• Danger of explosion! Batteries must not be re-chargeable or throw in the fire or short-circuited.
• Do not expose batteries to extreme temperature such as from direct sunlight or fire. Do not place the product on a heating source.
• If batteries are already leaked, remove them from the battery compartment with a clean cloth. Dispose the batteries in accordance with the provisions. Avoid to contact the leaked battery acid.
• CAUTION! There is a danger of explosion if the batteries are inserted incorrectly. Use only the same battery types. Do not use old and new batteries together and of different type from different manufacturer.
• Always insert batteries in accordance (+) and (-) polarity as illustrated in the battery compartment.
• Batteries are life-threatening if swallowed. Store all batteries out of the reach of the children. Seek medical help immediately if batteries are swallowed.
• Do not allow children to change batteries.
• Remove the batteries when you are not going to be using the product for a long period of time.

Preparations before use

• Remove all packaging and check the machine for completeness and transport damages. In case of damage, contact supplier immediately. DO NOT use the product. (See ==> Warranty).
• Ensure the surrounding have sufficient ventilation.

Battery installation

• Remove the battery compartment cover (6) by pressing the locking clip at the bottom of the product.
• Insert 2 batteries of same type (3V 2 x 1,5V , battery type AA, not included) according to the polarity markings at the bottom of the rear barrel (5) with the batteries.
• Do not use new and old or different types of batteries together.
• Then, close the battery compartment cover (6) afterwards.

Operation

• Insert the soft extension hose (7) into the rigid hose (3).

• Place a small amount of wood chips (not included) into the burning chamber (1).
  Note: Do not overfill the burning chamber (1). The wood chips should just cover the inside mesh filter area with a thin layer.

• Press down the ON/OFF button (4) as below to switch ON the product. Press again the ON/OFF button (4) to switch OFF the appliance.

• Use a march or lighter (not included) to apply a small flame to the top surface of the wood chips. Move the flame around so as to ignite the entire exposed surface. For best results, make sure the burning area is evenly distributed or centered.
  Note: Dry wood chips are available in grocery stores and hardware stores.
  WARNING! DO NOT use a kitchen torch or butane torch style lighter.

• Once the smoke is seen emission from the end of the hose (7). Direct and place the hose (7) to where the food required. Then, put under the cover/plastic wrap (not included) to prevent the smoke from escaping.

• Trap the smoke for few seconds until inside area filled with a dense smoke.

• Remove the appliance together with the soft extension hose (7), still let the food be covered with plastic wrap for several minutes.

Main parts of the product
Model: 199961

Model: 199992

1. Burning chamber
2. Front barrel
3. Rigid hose
4. ON/OFF push button
5. Rear barrel
6. Battery compartment cover (detachable)
7. Soft extension hose

Cleaning

• Always remove all the ash or remaining wood chips before cleaning.
• Never immerse the appliance in water or other liquids for cleaning as this may damage the product. Clean the product with a slightly damp cloth or sponge with some mild soap solution.
• Never use abrasive sponges, detergents, steel wool or metallic utensils to clean the interior or exterior parts of the appliance.

Warranty

Any defect affecting the functionality of the appliance which becomes apparent within one year after purchase will be repaired by free repair or replacement provided the appliance has been used and maintained in accordance with the instructions and has not been abused or misused in any way. Your statutory rights are not affected. If the appliance is claimed under warranty, state where and when it was purchased and include proof of purchase (e.g. receipt). In line with our policy of continuous product development we reserve the right to change the product, packaging and documentation specifications without notice.

Discarding & Environment

When decommissioning the appliance, the product must not be disposed of with other household waste. Instead, it is your responsibility to dispose to your waste equipment by handing it over to a designated collection point. Failure to follow this rule may be penalized in accordance with applicable regulations on waste disposal. The separate collection and recycling of your waste equipment at the time of disposal will help conserve natural resources and ensure that it is recycled in a manner that protects human health and the environment. For more information about where you can drop off your waste for recycling, please contact your local waste collection company. The manufacturers and importers do not take responsibility for recycling, treatment and ecological disposal, either directly or through a public system.

Hendi B.V.
For technical information and Declarations of Conformity see
www.hendi.eu.

References

• hendi.com
• Welkom - HENDI Tools for Chefs
• Welkom - HENDI Tools for Chefs
• hendi.pl

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>