maxima MTT 150 Conveyor Toaster User Manual

MTT 150 Conveyor Toaster
User Manual **Toaster MTT 150 / MTT 300 / MTT 450
USER MANUAL

**

MTT 150 Conveyor Toaster

BEFORE USING THIS PRODUCT YOU SHOULD READ THIS USER MANUAL PROPERLY
Spangenberg International B.V. – Nijverheidsweg 19F – 3641 RP Mijdrecht
– Holland – T. +31 (0) 297 253969 – F. +31 (0) 297 256445
[email protected] – www.maximaholland.com

Introduction

Thank you for purchasing this Maxima product. In order to obtain the maximum benefit and use of this product, please read these instructions completely before attempting to install or use this product.
Your new Maxima product is manufactured with advanced production techniques. Every product is inspected before shipment and tested to ensure operator safety and product quality. All parameters have reached or exceeded the national standard.
The Maxima toaster can be used to toast different food products. The machines are safe, stable and easy-to-use. This appliance can be used for example to toast fresh bread. All parts in contact with food are made of stainless steel or food grade plastics.
At Maxima we are very proud of our products and are completely committed to providing you with the best products and service possible. Your satisfaction is our number one priority.
We know you will enjoy using this product and Thank You for choosing our product. We hope you consider Maxima for your future equipment purchases.

Safety regulations

• The appliance may only be used for the purpose for which it was intended and designed. The manufacturer is not liable for any damage caused by incorrect operation and improper use.
• Incorrect operation and improper use of the appliance can seriously damage the appliance and injure users.
• Keep the appliance and electrical plug away from water and any other liquids.
• In the unlikely event that the appliance should fall into water, immediately pull the plug out of the socket and have the appliance checked by a certified technician. Not following these instructions could give rise to life-threatening situations.
• Never try to open the casing of the appliance yourself.
• Do not insert any objects in the casing of the appliance.
• Do not touch the plug with wet or damp hands.
• Regularly check the plug and cord for any damage. When the plug or cord is damaged, you should have it repaired by a certified repair company.
• Do not use the appliance after it has fallen or is damaged in any other way. Have it checked and repaired by a certified repair company.
• Do not try to repair the appliance yourself. This could give rise to life-threatening situations.
• Make sure the cord does not come in contact with sharp or hot objects and keep it away from open fire. To pull the plug out of the socket, always pull on the plug and not on the cord.
• WARNING! Do not use an extension cord, but instead connect the appliance straight to the socket.
• This appliance is meant for toasting food.
• WARNING! Be careful not to burn yourself with the appliance. So do not touch heating elements or any parts that might be hot.
• Always keep an eye on the appliance when in use.
• Never let children near the appliance without supervision.
• Never use the appliance outside.
• Always pull the plug out of the socket when the appliance is not being used and always before cleaning.
• The electrical installation must satisfy the applicable national and local regulations.
• Warning! As long as the plug is in the socket the appliance is connected to the power source.
• Turn off the appliance before pulling the plug out of the socket.
• Never carry the appliance by the cord.
• Prevent overloading the appliance.
• Do not place any objects on top of the appliance.
• Do not place the appliance on its side or upside down, also not while the appliance is being transported. Do not turn the appliance in an angle of more than 45°.

Commissioning

• Check to make sure the appliance is undamaged. In case of any damage, contact your supplier immediately and do NOT use the appliance.
• Remove all the packing material.
• Mount the feet underneath the machine, this can be done by screwing them in the correct holes.
• Level the appliance on a stable surface to prevent it from falling and causing burn wounds for example. You can level the appliance by screwing in or out the lower parts of the feet.
• Make sure the appliance is placed with enough space between its sides and the wall or other objects, to prevent damage or problems caused by the heat of the machine.
• Make sure the appliance is not placed next to any sources that radiate heat (for example a heater, stove or oven).
• Position the appliance in such a way that the plug is accessible at all times.
• Clean the appliance on the outside with luke-warm water and a soft cloth (water with a mild detergent) before using it for the first time. Dry the machine after cleaning it.
• WARNING! Do not use any aggressive or caustic detergents. Also do not use any gasoline holding products. Make sure not water enters the appliance.
• Follow the steps shown in the next chapter ‘Operation’.

Exploded View

1. Guide shelf
2. Crumb collector
3. Power light (green)
4. Belt speed regulator
5. Dispensing shelf
6. ON/OFF switch
7. Toast catcher

Operation

• Wash the crumb collector, the dispensing shelf and the toast catcher thoroughly with a soft  cloth, water and a mild detergent before using them. Dry them thoroughly afterwards.
• Place the crumb collector in the fitting slot below the guide shelf until it clicks in place.
• Mount the guide shelf at the front of the unit.
• Mount the dispensing shelf by first sliding the round side under the unit, then hanging it on the hooks located at the lower edge of the opening at the rear end of the unit.
• Hang the toast catcher (with the appropriate front-side slots) on the rings under the opening at the rear end of the unit.
• Depending on the setup, toasted products may be dispensed in two ways:
  – From the front, using the dispensing shelf
  – From the rear, using the toast catcher

• If toast is to be dispensed at the front, close the opening in the rear wall of the unit using the hook on the rear metal flap.
• For rear dispensing of toast, the unit’s rear metal flap must be placed inside the unit.
• Ensure the unit’s ON/OFF switch is located in the OFF position.
• Connect the unit to a single power outlet.
• After activation, the green power light will come on to indicate the machine has power.
• First, set the speed of the conveyor belt (left switch, pos. 1-7) at the highest (quickest) setting (setting 1), and set the unit’s On/Off switch (right switch) to BREAD, and let the unit heat up for approx. 15 – 20 minutes.

Possible settings:
– Upper and lower heater = BREAD/TOAST,
– Upper heater = BUNS
– STBY = standby

• To test the unit, place two slices of bread on the guide shelf. Faster belt speed will result in lighter toasting, and slower belt speed will result in darker toasting.
• After toasting, the bread is dispensed, depending on the setup, either at the front with the dispensing shelf or at the rear end of the unit with the toast catcher.
• Best results can be achieved by selecting an average (3-4) conveyor belt speed.
• Products to be toasted may also be placed directly in the toaster. In this case, the guide shelf should be placed at the very back of the unit.
• If the toaster is not in use, to save energy you may switch the on/off switch to “STBY” mode. This way the toaster will use only 25% of its total power.
• During the process the crumbs will fall on the designated crumb tray. This can be cleaned by removing the crumb tray from the bottom of the appliance.
• When not using the appliance for a longer time, remove the plug from the socket.

Cleaning and maintenance

• WARNING! Always remove the plug from the socket before any cleaning or maintenance is being done to the appliance.
• WARNING! Let the appliance cool down before any cleaning or maintenance is being done to the appliance.
• Regularly check the plug and cord for any damage. When the plug or cord is damaged, it is forbidden to use the appliance. The cord or plug should first be repaired by a certified repair company.
• Any other maintenance or repairs may only be done by certified personnel with the use of original parts and accessories.
• WARNING! Never submerge the appliance or the plug in water or any other liquid substances.
• Clean the appliance with a damp cloth (water with mild detergent). Dry the appliance after cleaning. Do not clean any items with the dishwasher, the detergents can be to aggressive for the appliance.
• WARNING! Do not use any aggressive or caustic detergents. Also do not use gasoline holding products. Make sure no water enters the appliance.

Specifications

toasts / hour
Weight:| 14kg| 16kg| 21kg

Storage

Make sure the appliance is cleaned correctly before storing it.

• Coil the power cord and put it away.
• Store in a cool and dry place.

Warranty

Thank you for using our products, our company will follow related provisions from our “Algemene Voorwaarden”, and provide you services when you can show us the invoice.
We provide 12-month warranty from the date of purchase (invoice date). In the warranty period, our company is responsible for free parts if there is a device fault or quality problem of spare parts under correct operation.
The following does not belong to free services:

1. Damages result from transportation, installation, improper connections.
2. Component damages caused by failing to provide power and voltage as required in technical data.
3. Damages caused by disassembling products, adjust or change the mechanical and electrical structures without permission.
4. Damages caused by improper operation, cleaning and maintenance.
5. Non-man-made damage, such as damages from abnormal voltage, fire, building collapse, lightning, floods and other natural disasters, and damages from rats and other pests.
6. Failure in following the manual when operating.
7. Wearable and expendable parts.
8. Altered invoice or without invoice.

Discarding

• When discarding the appliance at the end of its useful life, please observe the regulations and guidelines in force at that time for discarding appliances.

Spangenberg International B.V.
– Nijverheidsweg 19F – 3641 RP Mijdrecht
– Holland – T. +31 (0) 297 253969 – F. +31 (0) 297 256445
[email protected]
www.maximaholland.com

References

• Welcome to the export and wholesale website of Maxima Holland!
• Welcome to the export and wholesale website of Maxima Holland!

Read User Manual Online (PDF format)

Download This Manual (PDF format)

Download this manual  >>