GE AWY14LSAZ Split Type Room Air Conditioner User Manual

R301 15M <5W>

R302 1.0K <1/10W>

C207 HCP 104
CN302 R3(6.0)B-PASK-1

2003.09.05

– 8 –

ERROR CONTENTS
Self-diagnosis function
This function memorizes the trouble diagnosis function (Flashing LED display) when trouble occurs at an indoor unit PC board. (The memory contents are not erased even when the power cord is disconnected from the power outlet.) The self-diagnosis function (LED display) allows detailed diagnosis by allowing switching to large division indication and small division indication.
Self-diagnosis function [LED display] (How to call memory)
(1) When trouble occurs, it is displayed by [Operation lamp (red)], [Timer lamp (green)], and temperature monitor (7 segments display) 2 digits.
(2) After the power plug is pulled, operation starts by remote control. [Normal operation display] (3) When the [Test run] button on the back of the remote controller is pressed, [Memory contents] display is performed. When there is no error memory memorization, the unit enters the [Test run] state.
Memory erase method
(1) The memory contents can be erased by pressing the [Service end button- emergency operation] button on the body for 3 seconds or longer during self- diagnosis function display. (The indoor unit buzzer buzzes for 3 seconds.) For 1 minute after trouble reset, the temperature and humidity monitor displays [–]. After 1 minute, the temperature and humidity monitor is displayed.

2003.09.16

9

2004.05.19

Self-diagnosis function table (LED display)
[Small division indication] [Table 2]

Large division indication

Display

Serial signal error

Operation : ON Timer : 1 sec ON/OFF

(1 / 3)

Temperature monitor display

Small division indication Display

Temperature monitor display

Error judgement

Body operation

02 to 07 Serial (reverse) Operation : 0.1 sec

error immediate- Timer : 0.5 sec 2 times

ly after operation

02

When the serial signal is not Operation cause: Indoor and

read even once within 7 sec- outdoor unit connection wire

onds from power relay ON after Outdoor unit

operation starts.

Reset when serial (reverse)

becomes normal.

Serial (reverse) Operation : 0.1 sec

error during op- Timer : 0.5 sec 3 times

eration

03

Serial (reverse) error 7 seconds Operation cause: Indoor and

after power relay ON.

outdoor unit connection wire

Reset when serial (reverse)

becomes normal.

Serial (forward) Operation : 0.1 sec

error immediate- Timer : 0.5 sec 4 times

04

ly after operation

When serial signal (forward) is Operation cause: Indoor unit

not read within 10 seconds af- Reset when serial (forward)

ter power relay ON.

becomes normal.

Serial (forward) Operation : 0.1 sec

error during op- Timer : 0.5 sec 5 times

05

eration

Indoor unit

Operation : 0.5 sec 2 times 22 to 25 Room tempera- Operation : 0.1 sec

thermistor abnormal Timer : 0.1 sec

ture thermistor Timer : 0.5 sec 2 times

22

faulty

Serial (reverse) error 10 seconds after power relay ON.

Operation cause: Indoor unit Reset when serial (forward) becomes normal.

When thermistor detected val- Operation cause: Indoor unit

ue open (Detected only when Reset when detected value be-

power on)

comes normal.

10

Piping thermistor Operation : 0.1 sec

(intermediate) Timer : 0.5 sec 3 times

23

faulty

Outdoor unit

Operation : 0.5 sec 3 times 32 to 37 Outlet thermistor Operation : 0.1 sec

thermistor abnormal Timer : 0.1 sec

faulty

Timer : 0.5 sec 2 times

32

When thermistor detected val- Operation cause: Indoor unit

ue open or shorted (Detected Reset when detected value be-

only when power on)

comes normal.

When thermistor detected val- Operation cause: Outdoor unit

ue open or shorted (constantly Reset when detected value be-

detected)

comes normal.

Heat exchange Operation : 0.1 sec

thermistor faulty Timer : 0.5 sec 3 times

33

When thermistor detected val- Operation cause: Outdoor unit ue open (constantly detected) Reset when detected value be-
comes normal.

Outside air ther- Operation : 0.1 sec

mistor faulty

Timer : 0.5 sec 4 times

34

When thermistor detected val- Operation cause: Outdoor unit

ue open or shorted (constantly Reset when detected value be-

detected)

comes normal.

2004.05.19

(2 / 3)

Large division indication Display

Temperature monitor display

Small division indication Display

Temperature monitor display

Error judgement

Indoor unit control unit faulty

Operation : 0.5 sec 4 times Timer : 0.1 sec

Filter reset –

Operation : 0.1 sec

forced automatic Timer : 0.5 sec 2 times

switch faulty

42

When filter reset ? forced automatic SW is ON for 30 secs or more

Body operation
Operation cause: Indoor unit Other than display operate normally. Display performed only during normal operation. Goes off if operation stops.

Main relay welded

Operation : 0.1 sec Timer : 0.5 sec 3 times
43

When serial signal (reverse) in- Operation cause: Indoor unit put even though mail relay OFF Permanent stop condition after 2 mins after operation stopped.

Power interrupt Operation : 0.1 sec

42 to 48 faulty

Timer : 0.5 sec 4 times

44

When power frequency

Operation cause: Indoor unit

(50/60Hz) cannot be judged Permanent stop

even after 2 secs have elapsed

after power was turned on.

Outdoor unit

Operation : 0.5 sec 5 times 52 to 57 Transistor mod- Operation : 0.1 sec

control unit faulty

Timer : 0.1 sec

ule overcurrent Timer : 0.5 sec 2 times

52

When outdoor unit overcurrent 2nd operation occurs within 40 secs from starting and 3rd operation occurs within 15 minutes

Operation cause: Outdoor unit Permanent stop

Outdoor unit in- Operation : 0.1 sec

put current ab- Timer : 0.5 sec 3 times

53

normal

When current during operation Operation cause: Outdoor unit 1 min or more after compressor Permanent stop starts is 0A

11

2004.05.19

(3 / 3)

Large division indication Display

Temperature monitor display

Small division indication Display

Temperature monitor display

Error judgement

Body operation

Outdoor unit

Operation : 0.5 sec 5 times 52 to 57 Compressor po- Operation : 0.1 sec

When position detection abnor- Operation cause: Outdoor unit

thermistor abnormal Timer : 0.1 sec

sition abnormal Timer : 0.5 sec 5 times

55

mal 2nd operation occurs within Permanent stop

40 secs from starting

Outdoor unit fan Operation : 0.1 sec

When fan motor current, posi- Operation cause: Outdoor unit

abnormal

Timer : 0.5 sec 6 times

56

tion detection, or abnormal op- Permanent stop

erated 2 times within 10 mins

Indoor unit fan motor abnormal

Operation : 0.5 sec 6 times Timer : 0.1 sec

62 to 63

Fan motor locked

Operation : 0.1 sec

When detected value after 56 Operation cause: Outdoor unit

Timer : 0.5 sec 2 times

62

secs after fan motor starts is Permanent stop

0 r.p.m.

Fan speed ab- Operation : 0.1 sec

When detected speed after 56 Operation cause: Outdoor unit

normal

Timer : 0.5 sec 3 times

63

secs after fan motor starts is Permanent stop

1/3 or less of target speed

Refrigerating cycle

abnormal

Operation : 0.5 sec 7 times 72 to 75 Discharge tem- Operation : 0.1 sec

When compressor stopped 2 Operation cause: Outdoor unit

Timer : 0.1 sec

perature

Timer : 0.5 sec 2 times

72

times by discharge protection Permanent stop

abnormal

Cooling exces- Operation : 0.1 sec

Cooling excessive high pres- Operation cause: Outdoor unit

sive high pres- Timer : 0.5 sec 3 times

73

sure rise protection operated Compressor stopped

sure rise protec-

and displayed in 3 mins delay During 3 mins delay

tion faulty

12

DC 4-way valve, Operation : 0.1 sec

When 4-way valve switching per- Operation cause: Outdoor unit

solenoid value Timer : 0.5 sec 4 times

formed and operated 5 times con- Permanent stop

faulty

74

secutively when room temperature

and indoor unit piping thermistor

temperature difference of 10oC or

more detected

Active filter abnormal Operation : 0.5 sec 8 times 82 to 83 Active filter volt- Operation : 0.1 sec

When active filter output volt- Operation cause: Outdoor unit

Timer : 0.1 sec

age detection ab- Timer : 0.5 sec 2 times

82

age abnormal (300V or more, Permanent stop

normal (when op-

or 80V or less) operated 2 con-

erated 2 times)

secutive times within 40 secs

Active filter voltage Operation : 0.1 sec

detection abnor- Timer : 0.5 sec 3 times

83

mal (1 time instant

operation)

Active filter abnormal / active fil- Operation cause: Outdoor unit ter instant interruption abnormal Permanent stop

Power supply voltage Operation : 0.1 sec

AA

abnormal

Dash: 0.1 sec

Indoor unit buzzer sound

200V model: When 100V

AA

impressed

100V model: When 200V

impressed

Operation cause: Outdoor unit Permanent stop

Outdoor unit control Operation: 0.1 sec

Ab

unit board faulty

Timer: 0.1 sec

Dash: 0.1 sec

UV negative ion: 0.1 sec

When model information ROM Operation cause: Outdoor unit

Ab

on control board cannot be read Permanent stop

How to take UV unit to pieces
UV unit

Take off screws, and take out UV unit.
UV unit

Screws UV unit
Screws

Lamp cover

Lamp

Control box

Take off screws, and take out Control box (with lamp) from lamp cover.

2003.11.11

– 13 –

UV lamp and control box
Take off screws, and pull lamp out of control box.

2003.11.11

– 14 –

DISASSEMBLY ILLUSTRATION
Models : AWY14LSAZ, AWH14LSAZ AWY17LSAZ, AWH17LSAZ
2003.09.09 15

9 Air Filter

Dust Box Assy 56
Open Panel 6 Decoration Plate 7

Air Filter 9 Top Cover 8
Dust Box Assy 56 5 Front Panel

1 Top Grill 1
2 Top Panel

Models : AWY14LSAZ, AWH14LSAZ AWY17LSAZ, AWH17LSAZ

2003.09.09

Duct Assy 57

UV Lamp Cover Evaporetor Holder-R 53

Bracket Panel 22

– 16 –

Drain Pan 14 Casing Cover-F 15

Bearing-C 39 Casing 13

45 UV Unit
Evaporetor 52 51 Crossflow Fan

25 Rear Blacket

54 Evaporetor Holder-L

28 Louver L/R Casing Cover-R 17

12 Connector Box

20 Louver Cum

Spring Holder 21

27 Drain Cap

46 Step Motor 16

Casing Cover-B

19 Step Motor

31 Diffuser-Z

Bushing-A 24

Louver Frame 32

50
Fan Motor ( Brushles Motor )

36 Room Thermistor Holder

37 Control Box

44 Ion Cover

Control Box Cover 38

43 Ionizer 46 Step Motor

40 Terminal

55 Controller PCB Assy

26 Drain Hose

42 Cord Clamp 41 Earth Terminal

18 Casing Cover-L

11 Display Case 10 Main Frame

34 Louver-U Assy

30 Louver-U

Shaft

29 Louver-Z 33 Gear Holder

– 17 –

2003.09.07

1 Top Panel

27 TR PCB

26 Inverter PCB

Top Panel Seal
16 Propeller Fan
Motor Bracket 18

Transformer 31
28 ACTPM

17 Nut
Grip 7
Intake Grill 4

Fan Motor 34
6 Fan Ring

3 Cabinet

36 Emblem

33 Chock Coil
30 PTC Thermistor
29 25 Fuse Terminal

19 Separater

35 Compressor

13 Condenser

20 Base

24 Cord Clamp 23 Valve Bracket

Thermistor Spring 15

Expansion Valve Coil

32

38

Discharge Temp. Thermistor

10 4-Way Valve

11 Expansion Valve

39 Solenoid Coil

Dryer 12

22 2-Way Valve

Cabinet-R

21 3-Way Valve

Protective Net
14 Thermistor Spring-A 37 Heat Exchanger Thermistor Switch Cover

Models : AOY14LSAWC, AOH14LSAWC AOY17LSAWC, AOH17LSAWC

PARTS LIST

INDOOR UNIT

Ref. No.

Description

1 Top Grill 2 Top Panel 5 Front Panel Assy 6 Open Panel 7 Decoration Plate 8 Top Cover 9 Air Filter 10 Main Frame

11 Display Case 12 Connector Box 13 Casing total Assy 14 Drain Pan total Assy 15 Casing Cover-F 16 Casing Cover-B 17 Casing Cover-R 18 Casing Cover-L

19 Step Motor ( MP24ZAN ) 20 Louver Cam 21 Spring Holder 22 Bracket Panel 24 Bushing-A 25 Rear Bracket 26 Drain Hose 27 Drain Cap

28 Louver L / R 29 Louver-Z 30 Louver-U 31 Diffuser-Z 32 Louver Frame 33 Gear Holder 34 Louver-U Assy 36 Room Temp. Thermistor Holder

37 Control Box 38 Control Box Cover 39 Bearing-C 40 Terminal 41 Earth Terminal 42 Cord Clamp 43 Ionizer Assy 44 Ion Cover

AWY14LSAZ
9311962014 9311963011 9312251025 9311959021 9311964025 9311982012 9311983019 9311973010
9312009015 9312008018 9312240012 9312241019 9312023011 9312022014 9312403011 9312021017
9703477010 9312000012 9311999010 9312011018 9303529010 9312416011 9310357019 9304150008
9311997016 9311996019 9311993018 9312003013 9311994015 9311995012 9312243013 9311948018
9312005017 9312006014 9306628017 9306489120 9312809011 9302271002 9312244010 9312185016

45 UV Unit 46 Step Motor ( MP24GA ) 50 Fan Motor Assy 51 Crossflow Fan 52 Evaporator Total Assy 53 Evaporator Holder-R 54 Evaporator Holder-L 55 PCB Assy
(Controller + Connector)
56 Dust Box Assy 57 Duct Assy
– Gear Box L Assy – Gear Box R Assy

9900144012 9305780006 9601423041 9312004010 9312776016 9311985013 9311986010 9705164017
9312787012 9312412013 9312511013 9312255016

2005.11.17

Part No.

AWH14LSAZ

AWY17LSAZ

9311962014 9311963011 9312251032 9311959038 9311964025 9311982012 9311983019 9311973010

9311962014 9311963011 9312251025 9311959021 9311964025 9311982012 9311983019 9311973010

9312009015 9312008018 9312240012 9312241019 9312023011 9312022014 9312403014 9312021017

9312009015 9312008018 9312240012 9312241019 9312023011 9312022014 9312403014 9312021017

9703477010 9312000012 9311999010 9312011018 9303529010 9312416011 9310357019 9304150008

9703477010 9312000012 9311999010 9312011018 9303529010 9312416011 9310357019 9304150008

9311997016 9311996019 9311993018 9312003013 9311994015 9311995012 9312243013 9311948018

9311997016 9311996019 9311993018 9312003013 9311994015 9311995012 9312243013 9311948018

9312005017 9312006014 9306628017 9306489120 9312809011 9302271002 9312244010 9312185016

9312005017 9312006014 9306628017 9306489120 9312809011 9302271002 9312244010 9312185016

AWH17LSAZ
9311962014 9311963011 9312251032 9311959038 9311964025 9311982012 9311983019 9311973010
9312009015 9312008018 9312240012 9312241019 9312023011 9312022014 9312403014 9312021017
9703477010 9312000012 9311999010 9312011018 9303529010 9312416011 9310357019 9304150008
9311997016 9311996019 9311993018 9312003013 9311994015 9311995012 9312243013 9311948018
9312005017 9312006014 9306628017 9306489120 9312809011 9302271002 9312244010 9312185016

Ord. Q’ty

9900144012 9305780006
9601423041 9312004010 9312776016 9311985013 9311986010 9705164017

9900144012 9305780006
9601423041 9312004010 9312776016 9311985013 9311986010 9705164024

9900144012 9305780006
9601423041 9312004010 9312776016 9311985013 9311986010 9705164024

9312787012 9312412013 9312511013 9312255016

9312787012 9312412013 9312511013 9312255016

9312787012 9312412013 9312511013 9312255016

When you order parts, please make a photocopy of this page

18

and fill the number of the parts in the “Order” column.

OUTDOOR UNIT
Ref. Description No.
1 Top Panel 2 Top Panel Seal 3 Cabinet 4 Blow Down Grill 5 Cabinet-R 6 Fan Ring 7 Grip 8 Switch Cover
9 Protective Net 10 4-Way Valve Assy 11 Expansion Valve Assy 12 Dryer 13 Condenser 14 Thermistor Spring-A 15 Thermistor Spring 16 Propeller Fan

Part No. Ord.
AOY14LSAWC AOH14LSAWC AOY17LSAWC AOH17LSAWC Q’ty

9308883025 9309228016 9308878021 9308884015 9308879028 9308885012 9308880017 9308882028

9308883025 9309228016 9308878021 9308884015 9308879028 9308885012 9308880017 9308882028

9308883025 9309228016 9308878021 9308884015 9308879028 9308885012 9308880017 9308882028

9308883025 9309228016 9308878021 9308884015 9308879028 9308885012 9308880017 9308882028

9312026012 9312571017
9312340019 9312056002 9312323012 313728262708 9300089012 9309909014

9312026012 9312571017 9312340019 9312056002 9312323012 313728262708 9300089012 9309909014

9312026012 9312571017
9312340019 9312056002 9312323012 313728262708 9300089012 9309909014

9312026012 9312571017 9312340019 9312056002 9312323012 313728262708 9300089012 9309909014

17 Nut 18 Motor Bracket 19 Separater 20 Base Assy , Painted 21 3-Way Valve Assy 22 2-Way Valve Assy 24 Cord Clamp 25 Terminal
26 Inverter PCB Assy 27 TR PCB Assy 28 ACTPM 29 Fuse 30 PTC Thermistor 31 Diode bridge 32 Expansion Valve Coil 33 Choke Coil
34 Fan Motor 35 Compressor Assy 36 Emblem 37 Heat Exchanger Thermistor 38 Discharge Temp. Thermistor 39 Solenoid Coil
– Outdoor Thermistor

9304902003 9308872029 9312032013 9308869081 9313067014 9313062019 9307271014 9306489038
9704936035 9704949035 9703457012 0600036027 9900041014 0100122107 9900057015 9703458019
9601405030 9313192006 9312633012 9704220028 9704219091 9970033018 9900149017

9304902003 9308872029 9312032013 9308869081 9313067014 9313062019 9307271014 9306489038
9704936035 9704949035 9703457012 0600036027 9900041014 0100122107 9900057015 9703458019
9601405030 9313192006 9312635016 9704220028 9704219091 9970033018 9900149017

9304902003 9308872029 9312032013 9308869081 9313067014 9313062019 9307271014 9306489038
9704936028 9704949035 9703457012 0600036027 9900041014 0100122107 9900057015 9703458019
9601405030 9313192006 9312633012 9704220028 9704219091 9970033018 9900149017

9304902003 9308872029 9312032013 9308869081 9313067014 9313062019 93007271014 9306489038
9704936028 9704949035 9703457012 0600036027 9900041014 0100122107 9900057015 9703458019
9601405030 9313192006 9312635016 9704220028 9704219091 9970033018 9900149017

When you order parts, please make a photocopy of this page and fill the number of the parts in the “Order” column.

2005.11.17

19

ST A N D A R D A C C E S S O R I E S

The following installation accessories are supplied. Use them as required.

Name and Shape

Part No. Q’ty

Wall hook bracket

Name and Shape
Cloth tape

Part No. Q’ty

9312011018 1

9308117007 1

Remote control unit
Battery

AWY14,17 9312226023

Tapping scr ew(big) ( 4×20)

1 AWH14,17 9312226030

Tapping screw(small)

0600185046 2

0700076046 8 0700019036 2

Remote control unit holder

Drain pipe (outdoor unit)

9310082010 1

9301102000 1

2003.08.11

– 20 –

0308G2368

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>