JAMARA 461815 Ride on Jeep Willys MB Army Instructions

: June 11, 2024
: JAMARA

Table of Contents

JAMARA 461815 Ride on Jeep Willys MB Army
Product Information
General information
Suitable for children over 3 years
Parts
Charging your vehicle
Functions
Spare parts
Disposal restrictions
Service Center
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

JAMARA 461815 Ride on Jeep Willys MB Army

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-PRODUCT -IMG

Product Information

The product is a ride-on Jeep Willys MB Army, with product code No. 461815. The user manual includes instructions for the correct operation and use of the product, including assembly, loading, use, and selection of the appropriate area. The product is suitable for children over 3 years old, with a maximum weight of 30 kg. The product complies with Directive 2014/30/EU, 2014/35/EU, 2011/65/EU, and 2009/48/EC. The complete text of the EU Declaration of Conformity is available at www.jamara-shop.com/Conformity. Product Usage Instructions

Before using the product, read the entire instruction manual and safety instructions carefully. To prevent accidents and injuries, do not leave your child unattended during the operation of the vehicle. Never let your child out of your sight while driving the vehicle.

General information

JAMARA e.K. is not liable for any damage caused to the product itself or through this, provided this is due to improper operation or handling errors. The Customer alone bears the full responsibility for the proper use and handling, including without limitation, the assembly, the charging process, the use and choice of the operation area. Please refer to the operating and user instructions, it contains important information and warnings.

Suitable for children over 3 years

Warning: Not suitable for children under 36 months. RISK OF SUFFOCATION! Contains small parts which can be swallowed. Keep away necessarily from children
Due to its top speed, this toy is not suitable for children under 3 years!

Before playing, remove all protective films from all parts
This product is not intended for use by individuals (including children) with reduced physical, sensory or mental capabilities or lack of experience and/or knowledge.
Depending on the development, a minimum age of 4 years could be appropriate
Maximum weight: < 30 kg

Before assembly

Adults are required for assembly. Keep children away while assembling.
Tools (not included) needed for assembly: Screwdriver.

Certificate of Conformity

Hereby JAMARA e.K. declares that the product „Ride-on Jeep Willys MB Army, No. 461815″ complies with Directive 2014/30/EU, 2014/35/EU, 2011/65/EU and 2009/48/EC. The full text of the EU Declaration of Conformity is available at the following Internet address: www.jamara-shop.com/Conformity
Read the complete instructions and security instructions carefully before using the model.
To prevent accidents and injuries, DO NOT leave your child unattended during the operation of the vehicle. Never let your child out of your sight while driving a vehicle.
DO NOT use the vehicle on public roads or places or other dangerous locations.
ONLY operate the Ride On Car in places such as private parking, private land or other safe locations. Make sure that no person or animal is endangered.
The model stops after releasing the accelerator, independently on a horizontal surface. The vehicle has no brake or parking brake. Do not operate the vehicle uphill or downhill, and secure it when parking.

DANGER

For safe driving, you should make sure that your Child understands and adheres to the following rules:
- Always sit tight, do not get up during the ride.
- Never take additional Children for a ride. (The vehicle is only suitable for 1 person)
- Hold tight.
- Never drive without shoes.
- Never drive in the dark.
- To be used with protective equipment.
Keep hands, hair, loose clothing and any other item away from any rotating parts.
The Model should not be used in rooms or halls with high humidity, in the rain or on wet surfaces. Risk of malfunction or damage to electronics and housing.
The model is not water- or splash-proof. Only operate on asphalted surfaces (such as paving stones). The model is not suitable to be operated in grass or loose soil.

Attention!
Keep the not mounted kit away from small children as it contains swallowable parts. It must be assembled or checked by an adult to make sure the car is assembled on the right way before playing.

Only use in direct supervision of an adult!
To control the vehicle a minimum skill level and caution is needed. Make sure you are familiar with the operation of the model and its characteristics. The model is heavy. This is an increased risk of injury and damage in the event of loss of control. Avoid any kind of intentional or unintentional collisions with objects or hazards to persons.

Box Content

Model
Transmitter
Battery pack
Charger
Assembly tool
Instructions

Parts

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-2

Vehicle body: 1
Front bumper: 1
Gearbox: 2
Wheel cover: 4
Wheel: 4
Washer M10: 4
Nut M10: 4
Windshield: 4
Seat: 1
Backrest: 1
Toy shovel: 1
Toy shovel fastener: 1
Rearview mirror: 2
Steering wheel: 1
Charger: 1
Instruction: 1

Installing front bumper
Put the bumper (2) on the body of the car as shown. Tighten and fix with 6x M4*12 mm screws.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-3

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-4

Assembly of the front wheels
Remove the nuts and the washer from the front axle using the spanner. Now put the wheels (5) and one washer (6) each on the front axle and secure it with a nut (7). Finally, put a cover (4) on the wheel. Repeat this on the other side.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-6

Mounting the drive motor and the rear wheels
Put the drive motor (3) onto the rear axle, connecting the motor wire plug with the plugin at the motor clamp port, and insert the motor into the clamp slot. Put the wheel (5) and one washer (6) each on the rear axle and secures it with a nut (7). Finally, put a cover (4) on the wheel. Repeat this on the other side.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-5

Installing steering wheel
Connect the connecting wire on the steering wheel with the connecting piece on the instrument platform. Finally, the steering wheel (14) is clamped into the slot on the instrument platform and fixed with the M5*35mm screw and the M5 locknut.

Mounting the seat
Place the seat (9) in the car body slot. Tighten and fix it with 4 pieces of M4x12 mm screws.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-11

Installing backrest
Insert the backrest (10) into the body hole as shown in the figure.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-12

Installing windshield and rearview mirror
Press the windshield (8) and rearview mirrors (13) into position until it locks into place.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-10

Installing toy shovel fastener and toy shovel
First, fix the toy shovel fastener (12) on the rear box plate with a M4*12mm screw. Finally, the toy shovel (11) can be stuck on the fixed seat.

Battery connection
Open the cover underneath the seat and connect the connectors. Be careful not to reverse the polarity. Close the cover.

Charging your vehicle

The power switch must be turned in an OFF position when charging.
The charging port is under the seat.
Insert the charger into the socket – the LED lights up green. Connect the charger to the charging socket.
The LED on your charger lights up red as long as the battery is being charged. If the LED lights are green again, the battery is fully charged.
The charge time is 6 hours.
When the vehicle begins to run slowly, recharge the battery.
Do not charge the battery more than once within 24 hours.
Charger and battery heat up during the charging process.

Warning!

The charger is not a toy. Only use the charger supplied.
The battery may only be charged by or under the supervision of an adult.
The terminals must not be short-circuited.
The charger must be checked regularly for damage to the cable, plug, housing and other parts. If any damage is found, the charger must not be used until the damage has been repaired.
Let the model cool off sufficiently after each use before putting it back into operation.
When using additional batteries let it cool off for minimum 15 minutes until the model is operated again. Overheating can damage the electronics or may result in fire.
Always disconnect the model from the charger immediately after charging. Always disconnect the charger from the power supply immediately after disconnecting the model. Inserting the rechargeable model or charger after charging will result in damage to the model, charger, or power supply (fire hazard).
Only use the charger in dry rooms.

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-13

Functions

Horn
Soundboard
- A USB
- After inserting a USB stick, the soundboard starts playing the tracks one after the other. Only
- files with the extension .mp3 can be played back.
- B Bluetooth/Musik
- 1x kurz drücken um Bluetooth einzuschalten. Bei nochmaligem kurzen Drücken ertönt Musik.
- C Songtaste
- D Musik/Vdrücken
- = Titel rückwärts, langes drücken = Lautstärke leise
- E Musik/V+
  drücken = Titel vorwärts, langes drücken = Lautstärke laut
- F Spannungsanzeige
ON/OFF Switch
With the ON/OFF switch you start the vehicle.
Light button
Shift Lever:
- Forward: Press the “Forward-backward switch” on the “Forward” position.
- Press the “Foot pedal”, and the model drives forward
- Stop: The model will brake automatically when your child’s foot remove from the
- “Foot pedal”. Press the “Forward-backward switch” in the middle.
- Reverse: Press the “Forward-backward switch” on the “Backward” position.
- Press the “Foot pedal”, and the model drives backward.
- Important! The vehicle must be stationary before changing direction. Otherwise, the
  gear unit and/or the motor could be damaged.
Foot pedal
- To move the car, press the pedal down.
- To brake or slow down, release pressure from the pedal.

Caution
Always switch off the model immediately after each use. Immediately after each use the battery should be disconnected from the model. The battery can be deeply discharged
by leaving it switched on accidentally or leaving it plugged in. The deep discharge causes the battery to lose power or can be damaged to such an extent that charging or discharging
is no longer possible or the battery can self-ignite during charging or discharging (fire hazard). Never attempt to charge or discharge deeply discharged batteries. The
battery voltage should never fall below 11,9 volts to avoid deep discharge. The fully charged battery has a voltage of approx. 13 Volt. After use, the intact battery should be fully
charged immediately after a cooling phase of at least 10 minutes but at the latest after 12 hours to avoid subsequent deep discharge by self-discharge. If the battery is not used
or stored for a longer period of time, the battery should be checked for voltage (min. 12,3 volts) or damage at least every 3 months and charged or disposed of if necessary.

Problem	Source	Solution
No function	The battery is not or is incorrectly connected.	Connect the

battery (see instructions)
ON/OFF switch defective.| Check or replace the switch.
Can be switched on but does not drive.| Motor cable incorrectly connected or not connected.| Check and connect the motor cable (see instructions).
Can be switched on but does not move, or only direction.| Gas or direction switch defective.| Check or replace the switch.
Can be switched on but only travels in one direction| The directional switch is defective.| Check or replace the switch.
The active fuse blows and switches the unit off for a few seconds. You will

hear a single click at the beginning

| Overload or electrical short circuit.| Do not overload or have the until checked.
No sound function on the steering wheel/handlebars| the cable was torn or crushed during assembly.| Check or replace the steering wheel.
The vehicle has very high wear on switches.| Dirt and moisture damage the switches.| Do not drive in moisture or dirt such as meadows, gravel, sand, etc.
The rubber tires come loose on the wheels| Ridden on too hot a surface or in the dirt.| Change tires and avoid hot surfaces and dirt.
The wheel keeps falling off the axle.| Mounted incorrectly.| Check that the wheel is properly engaged (see instructions).

You can find further solutions to problems on the Internet in our FAQ at

https://jamara-shop.com/FAQ

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-14

Spare parts

JAMARA-461815-Ride-on-Jeep-Willys-MB-Army-FIG-15

Disposal restrictions

Batteries and accumulators must not be disposed of in domestic waste. You are obliged to dispose of batteries (seperate collection) appropriately. After use you can return batteries free of charge to the retail store. As batteries contain substances that can be irritant, can cause allergy and are highly reactive, separate collections and proper recycling is important to the environment and to your health. If the batteries are marked with a chemical symbol Hg, Cd or Pb below the crossed-out waste bin on wheels it refers to that more than 0.0005% of mercury (Hg), more than 0.002% of cadmium (Cd) or more than 0.004% Lead (Pb) is included.
Electrical appliances must not be disposed of in domestic waste and must be disposed of separately. You are obliged to take out the batteries, if possible, and to dispose of the electrical equipment at the communal collection points. Should personal data be stored on the electrical appliance you must remove them by yourself.