Numatic WV 470 Wet or Dry Vacuum Cleaner Owner’s Manual
- June 11, 2024
- Numatic
Table of Contents
WV 470 Wet or Dry Vacuum Cleaner
Owner’s Manual
www.numatic.co.uk
WV 470 Wet or Dry Vacuum Cleaner
CVC Machine – Kit AS21
WV Machine – Kit A11/85
Wet – Assembly
370 drum – Wand Docking
470 Handle Locking Instructions
Fitting the face
Removing the face
1| Company Name & Address| (GB) About your machine
---|---|---
2| Model
3| Voltage/Alternating Current
4| Frequency
5| Rated Input Power
6| Weight
7| Ingress Protection
8| WEEE Logo
9| Protection Class 2 Symbol
10| Approval Mark
11| Machine yr/wk Serial Number
Daily
Keep the machine clean, including hoses and tubes.
Ensure the bag and filter are fitted, (Dry use). Empty dust bag if required.|
MAINTENANCE
Clean and check float safety valve for signs of damage.
Regularly examine the power cord.
Check filters are clean.
Weekly – as daily and:-
Check for any worn or damaged parts and replace immediately.
WEEE Legislation (Waste, Electrical and Electronic Equipment)
Vacuum cleaner, accessories and packaging should be sorted for environmentally
– friendly recycling.
(Only for EU Countries)
Do not dispose of vacuum cleaner into household waste! According to the
European Directive 2012/19/EU on waste electrical and electronic equipment
and its incorporation into national law.
Vacuum cleaners that are no longer suitable for use must be separately
collected and sent for recovery in an environmentally – friendly manner.
PPE (personal protective equipment). That may be required for certain operations.
|
| | | ****
Ear Protection
| Safety Footwear| Head Protection|
Safety Gloves
|
|
| ****
Eye Protection
| Protective Clothing| Dust / Allergens Protection|
Hi Viz Jacket
| Caution Floor Sign
NOTE: A risk assessment should be conducted to determine which PPE should
be worn.
Failure to rectify the problem or in the event of a breakdown contact your
Nomadic dealer or the Nomadic Technical helpline +44 (0)1460 269268
Safety Critical Components
Mains leads: HO5VV-F 10 m x 2 Core x 1.00 mm²
Information for WET & DRY use Vacuum Cleaners
Warning
Read the instruction manual before using the machine.
Operators shall be adequately instructed on the use of these machines.
As with all electrical equipment, care and attention must be exercised at all
times during use, in addition to ensuring that routine and preventative
maintenance is carried out periodically to ensure safe operation.
Failure to carry out maintenance as necessary, including the replacement of
parts to the correct standard could render this equipment unsafe and the
manufacturer can accept no responsibility in this respect.
The machine shall be disconnected from the mains power by removing the plug
from the power supply socket during cleaning or maintenance and when replacing
parts or converting the machine to another function.
This machine is not to be used by children or persons with reduced physical,
sensory or mental capabilities, or lack of experience or knowledge.
Children being supervised are NOT to play with the machine.
This appliance is intended to be assembled, cleaned and maintained by an
adult.
This machine is not a toy.
This machine is not suitable for picking up hazardous or explosive dust.
Contact your local distributor if you require a machine capable of performing
these tasks.
Caution
If foam/liquid comes out of machine exhaust, switch off immediately.
Allow the accumulated liquid to drain out through the machine exhaust, check
the fl oat assembly to ensure correct operation, empty the container if full of
liquid, reassemble the machine.
Immediately upon start up there will be a certain amount of liquid issuing
from the machine exhaust which will be the residue of liquid still within the
power head. This will be quickly discharged after which the machine should
function normally.
Liquid ejected from the machine could be hazardous as a result of its
temperature, pressure or chemical content.
Ensure that the filtration system fitted to the machine is suitable for the
material being collected.
This machine is for indoor use only.
This machine shall be stored indoors only. .
When moving from one place to another, consider the weight of the machine.
Notes
You must ensure that the filtration system fitted to the machine is suitable for
the material being collected.
This product complies with the requirements of clause 20 of IEC/EN 60335-2-69
Stability and Mechanical Hazards.
The primary use for this machine is commercial, for example in hotels,
schools, hospitals, factories, shops and offices.
If the vacuum cleaner stops working, remove the plug from the power supply
before investigating where the fault lies.
The vacuum cleaner should be inspected after use for damage.
The power light will illuminate, when your machine is connected to a suitable
power supply (where fitted).
Do
- Use a bag and filter at all times when using ‘dry’.
- Keep your machine clean.
- Keep filters clean.
- Regularly clean the water level limiting fl oat safety valve and examine for signs of damage or correct operation.
- Keep hoses and tubes clear.
- Replace any worn or damaged parts immediately.
- Regularly examine the power cord, if damage is found, power cord must be replaced by a qualifi ed person using the correct Nomadic original part.
Don’t
- Use steam cleaners or pressure washers to clean the machine or use the machine in the rain.
- Immerse in water for cleaning.
- Allow any inexperienced repairs. Call the experts.
- Use wet if float valve is not functioning or fitted.
- Use to suck up hot ashes, or lighted cigarette ends.
- Run the machine over the power cable during operation as a hazard may occur.
- Pull on the cable to unplug the machine from the power supply.
- Walk over-wet carpets, upholstery or fabrics.
- Walk on clean carpets until fully dry.
- Attempt machine maintenance or cleaning unless the power supply plug has been removed from the supply outlet.
- Under any circumstances place foreign objects including (but not limited to) air fresheners, air freshener capsules or scented beads of any type into the top filter of the machine. Doing so can be dangerous and risk damage to the machine and may invalidate the machine warranty.
Fault Finding
Dry Mode maintenance/fault finding
If the vacuum cleaner stops working switch off and remove the plug from the
wall before investigating were the fault lies.
If the vacuum cleaner will not pick up any debris from the surface, switch off
and remove the plug from the wall, inspect the floor tool, wands and hose for
blockages, if no blockages are found, the dust bag may be full if the dust
bag is not full the filter may be blocked.
Wet mode
If the vacuum cleaner stops working switch off and remove the plug from the
wall before investigating were the fault lies.
If the vacuum cleaner has a blockage and will not pick up liquid, switch off
and remove the plug from the wall, has the float valve operated, this will shut
off the suction and the pitch of the vacuum motor will change.
Remove the power head and empty the liquid out of the container, if the
container is empty, check that the floor tool wands and hose are not blocked.
Flush the system with clean water after use.
After use always inspect the machine for damage.
Replacement Parts
Trite Filter
604165| Trite Filter
Heptathlon Dust Bags
604016| 370 / 380 (NVM 2BH) Pack of 10
604018| 470 (NVM 3AH) Pack of 10
Data
| Motor | Airflo | Suction | Cleaning Range | Class |
|---|---|---|---|---|
| 1000 W | 49 L/sec | 2400 mm | 26.4 m | II |
| Capacity Dry | Capacity Wet | Solution Tank | Size (mm) | Sound Pressure (LpA) |
| Uncertainty (KpA) | Weight |
370: 15 L
380: 15 L
470: 27 L| 9 L
9 L
20 L| 6 L
6 L
15 L| 360 x 370 x 510mm
360 x 370 x 510mm
360 x 370 x 710mm| 73-77 dB (A)
0.5 dB| 9 kg
9 kg
9.6 kg
Wiring Diagram
Notes ……………………………………………………
Nomadic International
Warranty
Nomadic International Limited warrant to the original purchaser that its
products are free of defects in both material or workmanship for the period
shown below:- Homecare and Clean care Vacuum cleaners ………..2 Years
Rotary Floor Machines ………………………………………2 Years
Twente Auto Scrubber Dryer ……………………………..1 Year
Varo Ride-On Scrubber Dryer …………………………….1 Year / 1500 hours
Mopping, Compacts, Combi and Servo care Products ……1 Year
Individual Accessories and Spare Parts…………………………. 6 Months
Note: This warranty expressly excludes consumable parts such as carbon
brushes, floor brushes, mops, batteries etc. that are considered replaceable
from time to time during the normal working life of the machine.
Using non Nomadic dustbins can be detrimental to both machine performance and
life and may invalidate the Warranty.
A. The warranty period commences from the date the goods are purchased.
B. All warranty claims must be processed through the Dealer from whom the
equipment was purchased. The Dealer will co-operate with the purchaser
throughout the warranty claims procedure and will arrange any necessary
repairs using genuine Nomadic parts.
C. If the original Dealer is no longer able to fulfil his obligations please
contact Nomadic International Limited with full details of the claim and proof
of purchase so that this may be processed without delay.
D. Any warranty claim can only relate to the specific part that is proven to
be at fault and for which a replacement will be supplied but cannot be
extended to constitute a claim against the complete machine.
E. Nomadic International will supply the Dealer with any warranty parts
required, subject to the claim being validated, after return of the faulty
items in accordance with Nomadic International Limited’s General Conditions of
Sale.
F. Claims will not be accepted if they are the result of fair wear and tear,
misuse or abuse of any kind.
G. No replacement will be given unless the appropriate evidence of the
validity of the claim has been provided to the satisfaction of Nomadic
International Limited.
H. Nomadic International Limited reserve the right to charge for any
unnecessary work carried out as a result of an invalid claim.
I. No variation to this warranty may be made or implied by any member of
Nomadic International Limited or its Dealers unless such variation is in
writing and authorised by the Company
Nomadic
Nomadic International Limited. Chard, Somerset, TA20 2GB
Telephone: 01460 68600 Fax: 01460 68458
Nomadic International Limited
Declaration of Conformity
Manufacturer:| Nomadic International Limited
Chard Somerset
TA20 2GB
www.numatic.co.uk
---|---
Product:| CVC, WV, WCT, WVP, HWD, WVT, CDC
Description:| Vacuum Cleaner – Commercial – Wet & Dry
2006/42/EC| Machinery Directive| EN60335-1:2012 + AC:2014 + A11:2014 +
A13:2017
EN60335-2-69:2012
EN62233:2008
---|---|---
2014/30/EU| EMC Directive| EN55014-1:2017 + A11:2020
EN55014-2:1997 + A1:2001 + A2:2008
EN61000-3-2:2014
EN61000-3-3:2013
2011/65/EU| RoHS Directive|
Authorised Signatory: Mr. Matthew Coles
Signed: Date: 04th May 2022| Position: Head of Technology Nomadic
International Limited Chard,
Somerset, TA20 2GB, UK
---|---
UKCA Declaration of Conformity
Manufacturer:| Nomadic International Limited Chard
Somerset TA20 2GBwww.numatic.co.uk
Product:| CVC, WV, WVT, WVP, HWD, CDC
Description:| Vacuum Cleaner – Commercial – Wet & Dry
We, Nomadic hereby declare under our sole
responsibility, that the above-mentioned product(s) is/are in conformity
with the following directives and standards.
S.I. 2008: 1597| Supply of Machinery Regulations| EN60335-1:2012 + AC:2014 +
A11:2014 + A13:2017
EN60335-2-69:2012
EN62233:2008
---|---|---
S.I. 2016: 1091| EMC Regulations| EN55014-1:2017 + A11:2020
EN55014-2:1997 + A1:2001 + A2:2008
EN61000-3-2:2014
EN61000-3-3:2013
S.I. 2012: 3032| RoHS Regulations|
Authorised Signatory: Mr. Matthew Coles| Position: Head of Technology
---|---
Signed:
Date: 1st Dec 2021| Nomadic International Limited, Chard,
Somerset, TA20 2GB, UK
DEC-008 V2.0
numatic.com
Nomadic International Limited. Chard, Somerset TA20 2GB ENGLAND
Tel: 01460 68600 www.numatic.co.uk
Specification subject to change without prior notice
www.numatic.com © Nomadic International Limited
908909 11/22 (A11)
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>